I was driving down the highway and lost complete power. Luckily was able to pull on shoulder before being hit by other vehicles on the road. Ecosport would no longer power on. Had towed and learned that the timing belt had failed due to lack of oil pressure. According to ford, the only way to fix the issue was by replacing the entire motor which took over 3 months to repair. The new motor sounds terrible and scares me every day now. I-??m just waiting for a repeat.

- Holts Summit, MO, USA

My drive belt or timing belt or something broke earlier this year due to unknown reasons, while travelling 65 mph on the highway. I have been unable to afford repair and was even without a vehicle for an extended period of time because of this. The engine required a special tool for my repair person to fully determine the cause and issue. However, since he did not own said tool, the engine has not been fully assessed. However, the engine no longer works and the vehicle does not run. It has remained parked for months. I saw that the NHTSA was investigating potentially faulty oil pumps on these vehicles (2019 Ford EcoSport) and believe that this issue also affected my vehicle, as well. It would explain a lot of unexplained things. I purchased the vehicle brand new from the dealership. My name is [XXX] on the purchase documents, however it was legally changed to [XXX] afterwards. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

- Fort Gibson, OK, USA

The contact owns a 2019 Ford EcoSport. The contact stated while driving 45 MPH, the low oil pressure warning light illuminated, and the vehicle lost motive power. The contact pulled over and checked the oil level, and the oil level showed full. The contact drove the vehicle to the gas station and added oil however, the failure persisted. While driving to the dealer, the Auto Start/Stop, Shift to Park, and Restart warning light illuminated. The vehicle was diagnosed by the dealer and was awaiting the repair. The manufacturer was made aware of the failure. The approximate failure mileage was 69,576.

- Porterville, CA, USA

It gave me an engine code saying there was a connection issue but the car was drivable and that i needed to schedule service. No code saying your engine is failing. It was the holidays. Dealers were closing so i figured I'd call and schedule it for service. Never got the chance as it seized up on the interstate at 60mph. Thankfully i was able to safely get it to the emergency lane and then towed to the dealer. They are now saying i need a new engine due to oil pump failure and are refusing to cover the cost. I feel like this is due to there malfunction and they should be responsible.

- Norfolk, VA, USA

After a few near death experiences and being stranded several times, my 2019 Ford EcoSport has had a new Sync 3 system, EVAP, and 2 -??new-?? engines. And it-??s still not functioning properly. (Was shooting out black smoke, jerking, stalling, screen blackout.) Jerking and the screen blacks out. But according to Ford, it-??s ok to drive. Might be the transmission -after a complete diagnostic test and test drive. The car cuts off (not from the start/stop feature).

- Killeen, TX, USA

So back on June 25th, I noticed that I got a low oil pressure warning on my dashboard and a wrench and red oil icon on the dashboard as well. I got my oil checked at Take 5 and they said oil level was o good and to see a mechanic. I took it to Midas next door, and I had total engine fail from a broken timing belt, and a broken oil pump. I had got this car used at 47k miles and had to replace the engine at 52k miles for $9,000. This car even had issues with it going into limp mode but Midas fixed it while I spent hundreds at Ford for diagnostics and they couldn-??t figure it out. This seems to be a common problem with Ford EcoSport and hopefully there can be an investigation into the poor design of their engine and turbo boost. If u need documentation of anything, I can provide

- Lakewood, OH, USA

Oil pressure drop with noticeable loss of power. Loss of Turbo. Engine is full of oil and has been maintained but engine is not being lubricated. Engine parts are grinding.

- Brandenburg , KY, USA

Low Oil Pressure. I had to get a whole new engine with only 95,000 miles.

- Salisbury, MD, USA

On the evening of 12/20/2023 suddenly the loss of engine oil pressure with an illuminated oil pressure warning lamp came on and the engine started knocking loudly. Then as we pulled out of traffic into a parking lot spot it died and would not restart. We were in heavy traffic and if we were not able to exit as quickly as we did our family would have been stranded and blocking in the heavy traffic. Was able to start it after it cooled but the engine continued to knock and within 1 minute the oil pressure warning lamp came on. We have not taken it to a repair shop as it is at 61k miles. I had to have it towed home and are currently in a out of pocket rental. It will have to be towed for any type of service.

- Oro Valley, AZ, USA

The contact owns a 2019 Ford EcoSport. The contact stated that while his daughter was driving at an undisclosed speed, the low oil pressure warning light illuminated, and the engine made an abnormal sound. The vehicle was towed to the dealer, where it was diagnosed that the engine needed to be replaced. The dealer replaced the engine. The manufacturer was made aware of the failure. The failure mileage was approximately 61,000. The VIN was not available.

- Everett, PA, USA

Oil pressure dropped and motor locked up. Only has 130,000 miles on it. Only car I own and now I'm walking.

- Independence, VA, USA

Motor failure when low oil pressure sensor came on. car had plenty of oil. up to date on oil changes and service. 69457 miles.

- Porterville, CA, USA

My car drove fine up until the 12th. I hoped in my car to go get some medicine at target which is 8 minutes away from them. My car began to make really loud noises and my oil light came on. I knew it was within the time for me to get another routine oil change. I bought one quart of oil just to hold me over for two days. I started my car to go home and my engine light and oil light and maintenance light all came on and my car would not drive over 45mphs. When you would press the gas, it would stall for a second. Thursday, I went for my oil change and was turned away due to the sound of my car and also the man smelled my dipstick and gas was in my oil. I was told to immediately take my car to the shop. The car shop has had my car for about a week and half and reached out at first saying that my problem was my camshaft and also turbo with a few other codes. I receive a class earlier this week saying I need a new engine. My car is a 2019 ecosport with 55k miles on it. They are working on an appraisal and so far it-??s already 6k. Still waiting for the final estimate to replace my engine

- Midlothian, VA, USA

oil pump failure and now motor failure.

- Gastonia, NC, USA

My daughter was driving on the highway and her oil light warning came on, followed by her car suddenly not allowing her to accelerate. This was followed by her check engine light coming on. She was able to make it to a Ford dealership in Lubbock, where they told her she needs a new engine. She seems to be one of many with similar issues. The vehicle has just over 80k miles.

- Prosper, TX, USA

The contact owns a 2019 Ford EcoSport. The contact stated that while his wife was driving at an undisclosed speed, the check engine warning light and low oil pressure warning light illuminated. The contact stated that an abnormally loud sound coming from the engine compartment. The contact's wife described the noise as a metal-on-metal grinding. Additionally, the vehicle was shaking erratically. The vehicle was towed to the dealer where it was diagnosed with catastrophic engine failure and that the engine needed to be replaced. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 81,111.

- Orange Beach, AL, USA

The contact owns a 2019 Ford EcoSport. The contact stated while driving approximately 80 MPH, the engine made an abnormally loud pop, and smoke came up from underneath the hood. The vehicle then lost motive power. The contact stated that several unknown warning lights were illuminated. The vehicle was towed to an independent mechanic and was diagnosed, and it was determined that the engine needed to be replaced. The vehicle was then towed to the dealer, where it was diagnosed that the piston had exploded, and the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 68,000.

- Jefferson City, MO, USA

Low engine oil pressure

- North Wilkesboro, NC, USA

Low engine oil pressure light came on and engine clanking noises occurred while I was traveling on the interstate. I immediately pulled the vehicle over to a safe location. Vehicle was towed to local Ford Dealership Service Center. Was told by the service manager that Ford has been having issue with oil pump not sending oil to the engine and that I would likely need a new engine. Due to backlog of service requests, Ford has not inspected my vehicle to verify the specific issue.

- Clayton, NC, USA

Oil flow light came on and I went to Walmart to have oil changed and to make sure oil filter was good. went to leave Walmart and oil flow light came on again. they took back in to take another look at it and could find anything noticeable. I was then told I should take it to a mechanic cause to him it seemed like the fuel pump wasn't flowing oil properly. I started home and while on the interstate I started smelling gas and the car started making a very loud whistling noise, like a teacup whistle. I was going 70mph and all of a sudden, the car jerked and quickly went to 30mph with all lights coming on. Had a tractor and trailer quickly coming upon me that had to serve to the next lane to keep from hitting me and almost hitting yet another car in that lane. Could get the car to get up past 30mph so I pulled off to the side of the road and once coming to a complete stop vehicle shut off and wouldn't restart. Had vehicle towed to a garage where I was informed that I need a engine replacement.

- Hagerstown, MD, USA