The coolent leaks into the engine causing engine failure. From research this is a common problem with the ecoboost turbo. Poor design, its like having a lawnmower engine and making it turbo. It needs to be recalled. I can provide estimates from Temecula Ford Dealership.

- Temecula, CA, USA

Vehicle: 2019 Ford Escape, VIN: [XXX] Issue: Coolant intrusion into engine cylinders, consistent with TSB 19-2346. Symptoms include coolant loss, white smoke, misfires, and rough idle. Safety Concern: Potential for engine failure or fire risk due to overheating. Manufacturer Response: No recall issued; seeking investigation and formal recall consideration. Related Litigation: [XXX] v. Ford Motor Company, U.S. District Court, Eastern District of California. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

- Frankfort , MI, USA

The flex plate is cracked. Possible missing dowels.

- Van Alstyne, TX, USA

According to my local ford dealership, the rattling/clicking sound in my engine is due to a faulty water pump which is apparently a known problem for a 2019 ford escape. I did not even have a check engine light appear and just happened to have my vehicle there for a different reason. This is an extensive and costly fix that should not be an issue with a 6 year old vehicle with 77k miles. With this being a common/known fault for EcoSport engines, it affects the safety of my engine and all passengers and other drivers.

- New Albany, IN, USA

My 2019 Ford Escape 2.0 Titanium has a KNOWN coolant intrusion issue where it is leaking into the engine. This began as my car shook on startup, then the check engine light would come on. Drove it a little ways, check engine turned off. Took my car into the repair shop and they looked up the stored code and it was P0301 cylinder #1 misfire detected and P0316 misfire detected on start up first 1,000 revolutions. Car seemed ok, so took it back. Happened again, 2x, check engine light on, off, then on again when I brought it back in. Same codes again. Mechanic said coolant low, removed cylinder #1 spark plug and sent camera into cylinder, found coolant leaking into cylinder. They said I need an entirely new engine, as this has been occurring a LOT with these EcoBoost vehicles. Ford had an open recall but only acknowledged a small amount of vehicles, mine not one of them, and there is currently a lawsuit against Ford because this has been happening to so many people. We are getting nowhere with Ford, they won't acknowledge the issue on the EcoBoost and now we have to come up with nearly $10k to replace an entire engine when the car isn't even worth $8k. PLEASE LOOK INTO THIS! Some people are having this issue at 50K Miles!!! This is not ok!!

- Oneonta, NY, USA

The contact owns a 2019 Ford Escape. The contact stated while driving 45 MPH, the vehicle stalled. The contact was able to pull over to the side of the road. The check engine warning light was illuminated, and the contact received a power train malfunction notification through the Mobile App. The vehicle was able to restart but failed to respond while depressing the accelerator pedal. The vehicle was towed to the dealer, where it was diagnosed with transmission failure. The dealer determined that the transmission needed to be replaced. The vehicle was repaired. Additionally, the contact stated that the vehicle was difficult to start but was started after several attempts. The vehicle was taken to Loganville Ford (3460 US-78, Loganville, GA 30052); where it was diagnosed and determined that the cam seals, the crankshaft sensor and harness, and the timing components needed to be replaced. The vehicle was not repaired. The contact stated that the engine was previously replaced in 2021, and the fuel pump was replaced in 2023 due to the stalling failure. The manufacturer was notified of the failure and a case was filed. The manufacturer referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 98,117.

- Loganville, GA, USA

The Ford dealer just advised that I need an entire new engine at a cost of $10,000 for a crack in the block, causing coolant to leak into cylinder three, potentially causing critical failure and danger while driving the vehicle. This is a known defect in this motor, which the manufacturer/Ford refuses to address.

- New Egypt, NJ, USA

at 96800 upon start up there was a cloud of white smoke and a check engine light. It was taken to the local ford dealer for diagnosis. Code was P303 and P316 indicating a misfire. the car was found to have coolant intrusion in cylinder 3 and would need a long block replacement. reference used was TSB 22-2229. This type of engine failure is know to ford due to design of coolant channels between cylinders. This could have cause sudden engine failure while drive resulting in an accident and injury or engine fire due to insufficient cooling causing loss of property and/or injury.

- Fullerton, CA, USA

The vehicle is suffering from an engine failure. It has a check engine light DTC PO303 with a heavy misfire. This causes to engine to lose power at times preventing proper acceleration which could lead to an accident. Ford has a technical service bulletin [TSB 22-2229 ] that describes the failure and the required repair. The problem is a design issue, but Ford is not covering any out of warranty repairs.

- Jacobus, PA, USA

Leaked coolant into second cylinder caused engine failure. This is a known issue with this model. No prior warnings, check engine light came on as the engine lost power. Risk of total engine failure.

- Eau Claire, WI, USA

Stop /Start button would kill the car would need a jump. Coolant leak in engine blew a gasket. Need a new engine. 54,000 moles on a 2019 Fors Escape

- San Diego , CA, USA

Coolant in cylinder causing overheating, misfiring of cylinder 3 and cracked engine block

- Reston, VA, USA

The contact owns a 2019 Ford Escape. The contact stated that while driving at an undisclosed speed, the vehicle shuddered abnormally. The contact believed that a fuel cleaner needed to be added to the fuel tank. The contact stated that the engine revved abnormally. While at a stoplight, the vehicle failed to drive forward and stalled. The contact stated that the axle and turbocharger had been repaired prior to the failure. There were no warning lights illuminated. The contact called the local dealer, but the vehicle was not diagnosed or repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 104,000.

- West Carrollton, OH, USA

There's currently a coolant intrusion issue with my 2019 Ford escape and I see that there was a recall on this for all Ford escapes from the years of 2017 through 2019 and I wanted to see if this will be covered for repairs

- Virginia Beach, VA, USA

Coolant is leaking and causing the cylinders to misfire. The check engine light is illuminated. This problem has been confirmed by the service department at my local Ford dealership. The repair is to replace the short block with an updated part and estimated cost is $5000-6000. My 2019 Ford Escape has only 79,000 miles on it and has been well-maintained. This leakage will definitely put myself and others at risk when my vehicle breaks down. The check engine light appeared on Thursday, July 31st. I brought the car immediately to the dealership. Since I did not have a scheduled appointment, they did a quick diagnostic and reset to see if it would happen again. The check engine light came back on the next day. I brought it in for a service appointment today after returning from being out of town last week.

- Roseville, IL, USA

Replaced engine blowing a lot of smoke out of the exhaust when starting engine and it didn't do that before the new remanufacured engine was installed.

- Watertown, NY, USA

Coolant leak into the engine.

- Marysville, OH, USA

coolent intrusion int the motor - no notice given regarding a previous recall

- Bethlehem, GA, USA

White smoke coming out of exhaust smelled of antifreeze. Took to Ford dealer in Eagle River, Wisconsin: Dealer found coolant in #1 cylinder and wrote on receipt - headgasket block failure, recommend replacing engine. Service writer said this is due to a defect in engine block being a slit machined in block between cylinders by Ford. Dealer quote for engine replacement was $9500.

- Hurley, WI, USA

2019 Ford escape titanium with 62000 miles.check engine light came on once and went off- took to dealer and was told the coolant was going into engine. Had an extended warranty to 75000 miles because of issue I had when car was brand new-brake release switch. Now I am told that warranty expired last year even though there is not 75000 on it yet. They are telling me I need a 8700 dollar new engine. I am [XXX] and this car is like new. Please help! I bought this brand new and only put about 10000 a year on it INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

- St Louis, MO, USA