I purchased this 2020 Ford Explorer ST, used while still under factory warranty. Within a week or two the IPMB module started malfunctioning, this affects all of the safety systems to include reverse brake assist, lane keeping assist, rear view camera and more. I have had the vehicle in two different dealerships over 9 times in the 15 months I have owned this suv, and within days of the problem being fixed the unit malfunctions again. I have tried to have the vehicle bought back by the dealer through their customer service program and the BBB of Michigan, to witch both claims have been denied claiming that the chicle does not fall under the NYS lemon law policy for used cars. The issue I have is this problem started within 1-2 weeks if purchasing the vehicle. What are the next steps that can be taken to have Ford Motor Company but this vehicle from me, as there is recall after recall on the unit in question.

- Mechanicville , NY, USA

The wiring harness in the back for the air was installed upside down, making the hot cold and the cold hot The vent in the ceiling that distributes air was kinked and had to be replaced The seatbelt on the drive side second row bucket seat was installed upside down The heater core had to replaced due to heat not blowing hot, still not and car was returned a second time Found out upon calling Ford that the car had two transmissions repairs by the previous owner and another "additional repair" done in 2022, would not disclose to me. I informed them the dealership gave me clean car facts. Car has less than 28,000 miles on it. I have had it less than ONE month.

- El Mirage, AZ, USA

Back up Camera goes blue or blank screen, we have called the Ford Dealer, we took it into their maintenance. Can-??t find issue We just received a recall in mail, we called the Ford Dealer today about our backup Camera recall. THEY told us they know nothing about it and Ford Manufacture has not confirmed this issue. ( todays date is 04/05/2023

- Potosi , WI, USA

Backup camera stays on the entire time driving or it will stay as a black or blue screen and not go back to original screen

- Thaxton , VA, USA

The issue was initiated when you turn the vehicle on. The vehicle would process through normal startup modes, and then produce several error codes and light illuminations, all within several seconds. The illuminations would consist of; Traction Control Error, Auto Hold Error, Descent Control Error, Lane Assistance Error, and Collusion Avoidance Error. This would then maintain the error during the trip or until the vehicle was powered off for several minutes. After the power cycle, the vehicle would start and show no symptoms of any error codes, at all. This would happen in several different instances a day, lasting several months. In several of my cases, this would disable traction control for longer periods of time throughout the day or week as well. This places extreme risk to drivers who may not know that there are so little standard safety features active while behind the wheel. Additionally, it affects drivers ability to stop, which traction control and auto hold disabled, and reduces the safety of everyone else on the road. I took the vehicle twice to a Ford Certified dealer and repair shop to investigate the issue. The technician was able to verify the codes that arose from the incidents. However, the first instance when I took the vehicle in, they were unable to locate a solution to the problem. After the second visit, they recommended a complete reprogram of 5 major computer modules that have created the system error. I inquired since this seems to be an issue widespread that they could not identify as a user error, but rather an equipment defect. They indeed charged me for the service when this should be something that should be issued a recall and fixed at a wide spread level. The safety of others while on the road are effected and may lead to serious vehicle accidents as a result of the failure of the vehicle component.

- Colorado Springs, CO, USA

Several electrical issues from day of purchase. Dealerships have looked at codes, but have been unable to repeat conditions or find an issues. Recently, on a random basis, the vehicle would become unresponsive & the accellerator pedal would not engage & for 10-20 seconds the vehicle wouldn't respond. At a point it reset itself and continued as if nothing had happened. This occurred on 6 or 7 occassions from June 2022 to Dec 2022. In Sept I took to dealership to check, they were unable to recreate condition & therefore no repair was made. In Dec the front brake pads went metal to metal. I decided to replace them myself. I put the Electronic Emergency Brake (EB) into the Maintenance Mode & changed the front pads and rotars. When I started to jack the front end up the car moved, so I immediately lowered the vehicle & verified the car was in park. At this time I discovered that the car, in park, could be moved by pushing it. I moved the car about 5 to 6 feet in either direction. I believed this was due to the EB being in the maint mode. I blocked the rear wheels & completed the repairs with no further incident. When I attempted to return the car to normal & take the EB out of maint mode, I was unsuccessful. I then bleed the brake system to ensure I hadn't inadvertently gotten air in the system. After multiple unsuccessful attempts to restore EB to normal, I contacted my local dealership for help. I was informed that even the site tech's had difficulties getting system into normal. I had AAA tow car to dealership, which then replaced the rear brakes, flushed brake fluid & renewed & restored sys to norm. When tech moved car to parking lot, they placed car in park and upon exiting car, it began rolling. When i contacted for pickup, I was informed of issue and gave permission to diagnose problem. Inspection of transmission found pin for parking mechanism broken, metal shavings in transmission. Need for extensive repairs or replacement of transmission.

- Syracuse, NY, USA

Transmission has been fixed twice, but it is still causing issues. It shifts hard and sometimes shutters. No dealership takes it seriously anymore. It is a known manufacturer defect that isn't being corrected promptly, probably to skirt by until warranty expires. The auto-hold system sporadically stops working. It will pop up on the dash that it is not available, but it will work after restarting the car a time or two. The info screen will randomly be a black screen after startup. The backup camera sometimes works and sometimes doesn't. Rarely, there will be no sound from any speaker. Radio, phone, turn signal, nothing works through the speaker like it should. The turn signal will make a strange noise through the dash that doesn't match normal sounds.

- Sand Springs, OK, USA

The rear hatch opens unexpectedly with no command given. It happened twice while in Drive pulling out of my garage. There was no audible or visual warnings the hatch was opening. The hatch impacted the garage door frame causing the glass to shatter and denting the metal. First incident was 4/2022 the second was 1/2023. Both were reported to my insurance provider and the Ford dealer. I also contacted Ford directly for reimbursement of my deductible and other expenses and they paid. See attached. Please see SSM 49015 - 2020 Explorer/Aviator -?" Partial Power Liftgate Opening And/Or False Anti-Theft Alarm Activation -?" Liftgate Ajar - Built On Or Before 17-Feb 2020. The problem is not resolved and I no confidence the hatch won't open whie I am on the road. If it does and something falls out this would be a major safety issue.

- Libertyville, IL, USA

Braking system stopped working. I had no breaks on the Highway! All systems lit up on my dash. Thankfully I was able to coast down the side of road in neutral until the car stopped. Whole time I was holding the brake down to the floor. Upon stopping it automatically threw into park. I turned the car off and then started again and everything seemed fine. I was scared to death to even drive it any further. I took it to the dealership to have it looked at. I see this is a problem with 2020 explorers and it needs to recalled. Someone is going be seriously injured or even die in the event of a wreck from this issue

- Laurel, MS, USA

Car did not respond to accelerator while driving on the freeway causing the car to decelerate on traffic creating a dangerous situation, other cars honked and swerved around

- San Diego, CA, USA

On March 14, 2021, a failure with the vehicle posed a serious safety hazard when my two children, another minor child and our dog were accompanying me, with the car fully loaded for spring break, and the brake system completely failed, among other electrical issues, as we were departing our neighborhood. The vehicle was subsequently towed to the dealership. I cringe to imagine what would have ensued if this defect would have occurred only a few minutes later, as we pulled into traffic or made it to the highway for our trip. I don't recall what lamps came on as it was very scary at the time, but the alerts on the Ford App were, Antilock Brake Fault, Hill Start Assist Warning, Hill Descent Control Fault Warning and Pre-Collision Assist Not Available.

- League City, TX, USA

The Ford Explorer ST when shifting into reverse, sporadically, the backup camera presents a blue screen, preventing all visibility while attempting to drive in reverse. It appears that none of the warning signals are operational when getting close to people or objects when the camera isn't working, thus presenting a hazardous condition as all safety features do not function. Apparently, there are similar recalls on some Explorer models but my particular vehicle is one that is not included in the previous pool of vehicles that are eligible for the recall repair.

- Accokeek , MD, USA

The contact owns a 2020 Ford Explorer. The contact stated while shifting into reverse the Back Over Prevention screen failed to operate as designed. Additionally, the vehicle would respond without the accelerator pedal being depressed. The contact also stated that while driving 35 MPH, the Forward Collision Avoidance warning system activated while there was no vehicle nearby. The contact stated that the vehicle was sputtering. There were no warning lights illuminated. The vehicle was taken to the dealer and the technician informed the contact that the brake assist was unavailable. The technician was unable to duplicate the failure with the Forward Collision Avoidance system. The vehicle was currently being repaired. The manufacturer was notified of the failure. The approximate failure mileage was 4,000.

- Visalia, CA, USA

The hands free lift gate closes on its own. This has happened more than a dozen times since I bought this vehicle 3 months ago. Any person standing at the rear bumper (not putting their foot under the bumper) activates this self closing process. The door hit me in the head twice.

- Aliso Viejo, CA, USA

When reversing the rear camera display turns blue and I'm not able to see anything behind me using the safety camera feature. I rely on the camera to assist with detecting people or objects in my blind spots while reversing and intermittently the display turns blue. There was a recall for this make and model and manufacture date, but the vehicle is not included in the recall. Recall information - Rearview Camera Recall 21C09. The dealership can't reproduce the issue because it's intermittent and there are no error codes, so they won't replace the camera. They've tried several software fixes but the problem continues. No warning messages displayed when the issue occurs. Thanks.

- Wilmington, DE, USA

Sometimes the rear camera view shows a blue screen while the other camera views work. I have to restart the vehicle to make it work.

- Madison, MS, USA

My car warnings were malfunctioning as they were all flashing on briefly. The car has done this before and has other issues with the panel such as now it has the icon for camera visibility is not working. I cleaned each camera and the light is still on. I backed out of the driveway put the car in drive and started to accelerate. I stepped on the brakes and they were not working, I repeatedly tried to stop but they were gone. My car finally stopped (I was not far enough to have started to build any speed. I turned the car off and back on and the brakes were back on. This happened March 31st, 2022.

- Plumas Lake, CA, USA

Our radio/navigational/climate control screen will go completely black while driving the vehicle. This has happened approximately 15 times since the purchase of the brand new car in August of 2020. Therefore, I lose all of my controls and my GPS. This will not come back on until the car is turned off and is given time to reset. This reset time varies from 30 minutes to 1 hour. The first time this occurred was one month after purchasing the vehicle. So, after three different visits to Ford dealerships, Hopkins Ford, Manning Ford and Dundee Ford, not one technician can duplicate this problem so it is still happening. Recently, I was in Columbus, Ohio and the screen went black while I was driving in an unfamiliar area. I'm aware that Ford had a massive recall on this very issue but somehow our VIN number is not included in this. I frequently travel across the Midwest because my fifteen year old daughter is in travel volleyball. I cannot afford for safety reasons for this to happen to the two of us when we are driving in unfamiliar places. This is a huge safety concern for my daughter and I.

- Genoa, IL, USA

A computer system fault caused the inability to start, move, turn off, turn on, lock or otherwise do anything with the vehicle with manual buttons or the remote. The drivers screen flashed through fault codes but would not allow any action. After discussing with the dealer on the phone, who mentioned something about a bad battery cell, I decided to disconnect the battery terminal, waited a period of time, and reconnected. The computer system reset and everything functioned correctly with no fault codes. At the time the vehicle was in a company drive lane causing a major hazard to the vehicles passing through. The vehicle was brought straight to the Dealer Service department who said they could not find anything wrong.

- Centereach, NY, USA

While driving at 70 mph the vehicle experienced the following issues all at once, the power steering shut off, all brake pressure was lost, the pre- collision system was turned off, parking brake engaged(at 70 mph) traction control system turned off, engine light turned on and all of the warning lights on the dash activated. This has happened 3 times and almost killed me twice. Ford has tried to repair this vehicle all three times and still have not corrected the issue. Ford has also refused to replace or buy back the vehicle.

- Aubrey, TX, USA