The contact owns a 2018 Ford F-150. The contact stated that while driving at 25 MPH, he was involved in a head-on collision with another vehicle. The contact stated the front end of his vehicle impacted the front driver-side wheel of the other vehicle. The contact stated that not a single air bag deployed during the impact, and no brake collision warning was activated. No warning lights illuminated on the instrument panel prior to the crash. The contact stated he received a pre-collision notification on his phone approximately 30 seconds after the accident occurred, but he was unable to avoid the collision. The vehicle was towed to a tow yard. The contact was the only occupant in the vehicle. The contact sustained neck pain, a herniated disc, and a bulging disk in the lower back. The contact was taking no pills and undergoing physical therapy. A police report was filed. The dealer was not notified of the failure. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 167,000.

- Bradford, AR, USA

Truck suffers problem associated with NHTSA 22V-150 but is not included in the recall. This occurs on highway driving while on cruise control. This can occur within just a few minutes of driving or extended period. Vehicle brake warning on dash occurs and says "Check Brake System", the brake pedal becomes very stiff and reduces braking of the vehicle. The brake light remains on until vehicle is shut off and restarted. This occurred most recently on a 3,000 mile trip through the Utah national parks and presents dangerous scenarios through mountain passes.

- Spokane, WA, USA

My truck has the same issue with the brake master cylinder bleeding back into the brake booster. Luckily I caught it before I left work. The reservoir was totally empty on the back half supplying the front brakes. At home pulled the vacuum hose and did the dip stick test and there was brake fluid in the brake booster. There is already a safety recall on the 2017-2018 f150 brake master cylinder but only with the 3.5motor. The 2.7 has the same brake master cylinder so I cannot see why only the 3.5 motor would have a recall"?" Ford will not do anything about it and they don-??t even have a part until sometime in March.

- Melbourne , FL, USA

ABS block leaking

- Daytona Beach, FL, USA

Master brake cylinder leaked into brake booster making my brakes not work and almost causing an accident. There is a similar recall on 2018 Ford F150 with eco boost. This appears to be a known issue with these Ford F150 models. Due to the issue I almost got in a serious accident.

- Ann Arbor, MI, USA

The brake system on my 2018 Ford F-150 2.7L EcoBoost began failing around early 2025 with a brake warning light illuminating and the pedal feeling soft, signaling a problem. The brake fluid reservoir dropped low repeatedly despite topping it off multiple times with DOT 3 fluid, indicating a persistent leak. By 09:52 AM CDT today, September 10, 2025, the brake pedal lost all pressure, making the vehicle completely undrivable and posing a severe safety risk due to significantly increased stopping distances and potential brake failure. At 10:37 AM CDT, thick white smoke started billowing from the exhaust each time the vehicle was started, likely from brake fluid leaking into the engine via the brake booster, a symptom matching Ford recall 25S37 (NHTSA 25V236) for a defective brake master cylinder seal. This failure endangers the driver, passengers, and other road users, as the truck is a primary vehicle, with the smoke suggesting a fire hazard and possible engine damage like stalling or misfires. The issue is reproducible, with the warning light, fluid loss, and soft/no pedal persisting since early 2025, worsening today with the smoke appearing consistently on startup. It has not been confirmed by a dealer or service center yet, as the vehicle is undrivable, but I plan to tow it to a Ford dealership for inspection under the recall. No manufacturer, police, insurance, or other inspection has occurred, as the smoke issue escalated this morning; prior rear left electronic parking brake actuator replacements in 2025 due to fluid leaks were done at home. The brake master cylinder and possibly the brake booster are the failed components, with the actuator issue likely related, and the vehicle is available for inspection upon request or at a dealership. Symptoms first appeared with the warning light and soft pedal in early 2025, followed by fluid loss, complete pedal failure, and smoke today at 09:52 AM CDT.

- Montgomery, TX, USA

Had a SUDDEN loss of braking ability. While starting to drive the truck home, the brake pad went flat. Checked the brake reservoir and it was empty. Refilled with brake fluid and drove 2 miles, brakes went out when arriving in the driveway. It went empty again within 15 minutes. No noticeable leak. No breaks on the truck to drive the vehicle. The vehicle had to be towed to the nearest dealer due to having NO brakes. Turns out the brake fluid was leaking into the booster. Noticed many other 2018 Ford F150 trucks were recalled for the same issue.

- Lake Havasu City, AZ, USA

My truck has been regularly serviced by FORD and yesterday out of the blue the brake pedal went soft and i got a check engine light saying low fluid. Upon inspection we noticed all brake fluid had leaked with no visible exit. We refilled the fluid and the next day, the fluid was completely drained again with no visible exit. Upon expert inspection it was noted the brake master cylinder is leaking into the booster.

- San Antonio , TX, USA

2018 Ford F-150 2.7 liter. Master cylinder and power brake booster failure. Confirmed by independent service center. Prior to failure there was a warning light indicating low brake fluid. I then lost all braking ability within 3 brake pedal depressions. My brake pedal touched the floorboard afterwards. Given right conditions I could have sustained major injury. Components were replaced by mechanic and unavailable for inspection. There is a recall on these components for 3.5 Ford truck but not 2.7 Ford truck, even though the components are identical. Again, confirmed by mechanic.

- Joliet , IL, USA

The electronic emergency break engages while on the highway crusing at normal highway speed. It has engaged randomly for a few months. Yesterday it engaged 15 times almost making me crash the 1st time. I had to pull over, shut off the truck to reset the brake to make it home.

- Cheyenne, WY, USA

Just got off the Interstate on to a frontage road when I received a low brake fluid light warning. Instantly lost braking power. Was traveling approximately 40mph downhill toward a traffic light where cross traffic was going full speed. I had to activate my emergency brake to stop from running into the cross traffic. Got the truck into a gas station, checked the brake fluid reservoir & it was below the minimum fill line. Purchased brake fluid at the gas station, filled it up & drove and the parking lot. The brakes partially worked, but the reservoir drained quickly again. I was lucky that there was a brake service repair shop within a quarter of a mile, so I refilled the brake fluid to the max & drove slowly with hazards on to the shop & left it there. Today they told me it was a brake master cylinder internal failure that caused brake fluid to leak into brake booster resulting in loss of braking power. While my truck is not covered under an existing recall, there is a recall for this exact issue for the same make & model of my vehicle (but with a different motor). That is NHTSA recall # 25V-236. I believe this recall should apply to my truck.

- Lake Kiowa, TX, USA

Break light and warning came on. -??Low Breakfluid-?? Next got off ramp put my foot on break and no breaks. Was able to stop using down shift and did not plow into anyone. thank goodness. There is a recall on other non diesel f150s fyu

- Mountainside, NJ, USA

Driving on a major freeway during rush hour traffic and my master brake cylinder failed causing me to lose brakes. Further more the cylinder vacuumed my brake fluid into the engine causing more costly repairs. I previously owned a 2015 F150 and know that master cylinder failed and was recalled. Ford assured me this was a better master cylinder in the 2018.

- Kaysville, UT, USA

The contact owns a 2018 Ford F-150. The contact stated while depressing the accelerator pedal, the vehicle accelerated at excessive speeds. The contact aggressively depressed the brake pedal and shifted into neutral to decelerate and slow the vehicle to a stop. The failure was intermittent and occurred at various speeds. The contact-??s son inspected the vehicle and determined that a fuse related to the cruise control might be defective. The contact-??s son had replaced the fuses. While driving approximately 10 MPH and coming to a stop sign, the contact decided to come closer to the stop sign however, the vehicle accelerated past the stop sign. The contact attempted to depress the brake pedal several times however, the vehicle failed to stop until approximately a block away from the stop sign. There was a certified mechanic nearby who inspected the vehicle but found no cause for the failure. The vehicle was taken to the dealer who diagnosed that the cruise control fuse had failed. The dealer replaced the fuse. The contact was uncomfortable with the fuse being in the vehicle, so the dealer removed the fuse to deactivate the cruise control. The manufacturer was made aware of the failure and a complaint was filed. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 90,000.

- Sweetwater, TN, USA

Master Brake Cylinder leaked brake fluid into brake booster resulting in complete loss of brakes. Warning light displayed low break fluid moments before complete loss of braking power, +/- 60 seconds before all breaking power was lost. Certain 2018 Ford F-150's currently qualify for this recall but my specific model does not. Reports online show many other's experience same issue with this 2018 model.

- Mount Pleasant , SC, USA

Vehicle warning for -??low brake fluid-?? came on while on freeway. Lost braking power and had to coast to a stop.

- Corona, CA, USA

While driving my low brake fluid light came on. I immediately pressed the brakes to pull over and almost could not stop causing danger to myself and other drivers around. I filled the reservoir for it to all leak out again in three miles. I filled it two more times and it keeps saying low fluid and losing my brakes. I inspect under the vehicle to find no visible fluid. It is leaking from the master cylinder into the brake booster. There is a recall for this on other 2018 f150 super crews. I will be bringing this to my local ford dealer to confirm the issue.

- Morristown, AZ, USA

Approximately 2 months ago I stopped to get a bagel breakfast and parked my 2018 Ford XFT on a slight 2 to 5 % slope parking lot. I put the truck emergency brake on and pressing on the brake petal put the truck into Park. I exited the store after picking up my order an got into my truck, depressed the brake petal and at the same time pulled the emergency brake button to release the vehicle still in Park mode.The shifter would not release the transmission to Drive mode or move at all and stayed I lock mode. After approximately 20 minutes to no avail to get it into Drive Mode I called the local FORD Dealership where I bought the truck and told them my problem at which time I was informed I needed to get the truck towed to the Ford Dealership. I then called a Tow Truck and waited for about half an hour until it arrived. Both myself and the Tow truck driver made several attempts to engage the truck to Drive Mode. The Two truck driver was sucessful on the last attempt not knowing how he got it into Drive Mode. I had to pay the tow truck driver the full amount and drove to the FORD Dealership which was approximately six miles away. Next day I got a call from the Dealership telling me my truck was done. I was informed there that they were not able to duplicate the problem and found nothing else wrong with the emergency brake. I paid that bill which was approximately $200 dollars. I had no problem with the brake since, until today 6/28/24 several months later. Problem repeated itself on miles 2 to 5% slope. Called the same FORD Dealership Service Dept. No Response. Called Sales Dept. women paged Service Rep. Informed him of past problem and repeated problem today. He informed me that NO One there or Any Ford Dealership Representative Anywhere in Region or National knows what to do in his situation. Further, stating I should have the truck towed th there Dealership ASAP. I repeated my problem and asked if he had any Phone Number for FORD HQ he said none.

- Sugarloaf, PA, USA

I have been having nothing but problems with this truck since I purchased it and I'm looking to see if anyone can help me out with this truck. I have had it now almost two years and the truck was in the shop for 3 months of it getting worked. I have had nothing but problems with the braking system as well. The dealer wouldn't sell me the original pads for it, they sent someone to car quest to get a set of pads. Whenever i gave them the vin i would always end up with the wrong parts somehow. So i dont know if there is vin fraud or what but something wasn't adding up. The dealer i purchased it from is not much of help. The water pump has gone out, the cam phasers were replaced(and are rattling again.) The starter was replaced due to clunking when started.( still clunks) Oil pan gasket was replaced. The transmission had to be replaced. I am just trying to see what my options are with this truck. It's clearly a lemon and just wondering if there's anything anyone can do to help because the reliability of this 35,000 dollar truck is out the window.

- Orlando, FL, USA

The contact owns a 2018 Ford F-150. The contact stated that while driving at 45 MPH, the vehicle lost braking capability. The vehicle was placed in Manual Mode. The low power steering fluid message was displayed. The contact was able to pull into a gas station to purchase power steering fluid. The contact added power steering fluid; however, while the vehicle was parked, the power steering fluid leaked out of the vehicle. The vehicle was towed to the residence. The contact stated that the failure was due to a failed seal and that the master pump had leaked from the rear seal. The contact called the local dealer, who referred him to the manufacturer. The vehicle was not diagnosed or repaired. The manufacturer was contacted and informed the contact that the vehicle was not covered under a recall. The failure mileage was approximately 132,401.

- Pelham, NH, USA