10.0

really awful
Crashes / Fires:
0 / 2
Injuries / Deaths:
1 / 0
Average Mileage:
25,549 miles

About These NHTSA Complaints:

The NHTSA is the US gov't agency tasked with vehicle safety. Complaints can be spread across multiple & redundant categories, & are not organized by problem. See the Back button — blue bar at the very top of the page — to explore more.

Get notified about new defects, investigations, recalls & lawsuits for the 2020 Ford F-150:

Unsubscribe any time. We don't sell/share your email.

Get free help with your lemon!
close ad
problem #101

Aug 222025

F-150

  • miles
This model year truck has an oil consumption problem. I had the truck repaired under the Ford bulletin, but I-??ll still need an oil consumption test after 1000 miles and continued frequent oil changes.

- Ashburn, VA, USA

problem #100

Sep 042025

F-150

  • miles
Cam Phaser failure causing the engine to knock and eventually lose power. Cost $4,900 out of my pocket to fix with 64,000 miles on the truck. Reading online forums, this is one of the MOST common issues with 2018-2022 3.5 and 5.0 f150s. The vehicle has a history prior to my ownership of this same issue. Check engine light is triggered when you hear the engine rattle and throws codes for Camshaft position error. Ford dealer replaced every sensor and harness on the truck before decided the cam phasers were bad, adding another $4,900 to my $2,600 bill. This was during my ownership of the truck between 63,000 and 65,000. First two thousand miles of ownership. Vehicle would stall at low rpm-??s after highway use, stalling the vehicle while rolling into an intersection.

- Corunna, MI, USA

problem #99

Aug 242025

F-150

  • miles
* What component or system failed or malfunctioned, and is it available for inspection upon request" Transmission/powertrain; currently available for inspection at time of submission * How was your safety or the safety of others put at risk" While stopped at stop sign/stop light, the vehicle would have long hesitation before advancing forward. I would initiate hazard lights to prevent driver behind me from crashing into the back of my vehicle. The vehicle would shift harshly and untimely as well as randomly downshift from 10th gear to 1st gear (x2 on 24Aug2025). I would have to pull vehicle off the road and when attempting to resume driving the vehicle would not move. The RPM-??s would rev, however the vehicle would not move. I would turn off the vehicle and then restart it and the vehicle would move forward, resuming with harsh shifting. Loss of power, delayed and harsh shifting pose a safety hazard while the vehicle is in operation. * Has the problem been reproduced or confirmed by a dealer or independent service center" Yes; by independent service center * Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? No * Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear" First check engine light illuminated on August 16, 2025. (Please note the check engine light disappears once the vehicle is turned off and then restarted). I took the vehicle to AutoZone on 25Aug2025. The tech placed the code reader on the vehicle. 2 codes, P0734-00 and P07F7-00, -??gear 4 incorrect ratio-?? and -??gear 10 incorrect ratio-?? respectively were displayed. Vehicle taken to independent service center on 25Aug2025 who also placed code reader on vehicle. I am not in possession of that information at time of writing. Monthly -??my vehicle report-?? has been clear with no issues whatsoever noted until report dated 25Aug2025 (attached)

- Zebulon, NC, USA

problem #98

Jul 302025

F-150

  • miles
fuel injector cracked and started spraying fuel in engine compartment and onto hot motor.

- New Johnsonville, TN, USA

problem #97

Jul 112025

F-150

  • miles
At roughly 9:55pm on Thursday, July 11th while traveling northbound at 70mph on the Dallas North Tollway, my 2020 Ford F-150 Shelby Baja Raptor had an instant catastrophic engine failure. All power to the truck was lost. A red solid battery light came on the a yellow engine light began flashing. I was EXTREMELY fortunate, in that I was able to guide and control the vehicle off of the freeway, on to the service road and glided into a hospital parking lot. The steering completely locked up while navigating from the service road into the hospital parking lot. Once again I was EXTREMELY lucky. This was a terrifying experience that is imporrible to describe with words. The next morning I had the truck towed to a reputable auto repair business close by. Later that day the owner of the business informed me that the crankshaft sheared into where it meets its connection to the engine. He cited that this is EXTREMELY rare and would visit with Shelby America on Monday morning(today 7-14-25). There were no warning lights of any kind that have come up within the last year. The vehicle was purchased locally in the Dallas/Fort Worth area. All maintenance...scheduled and non-scheduled have been performed at the same Ford dealership where the truck was purchased. The truck has had $40,000 worth of maintenance on it since the beginning of 2025. This failure doesnot make sense. The Auto Repair shop indicated that I need a new engine. They also didn't understand why this would happen.

- Frisco, TX, USA

problem #96

May 202025

F-150

  • miles
Transmission would shift into different gears when not intended

- Auburn, ME, USA

problem #95

Jun 012025

F-150

  • miles
There is a flaw in the design of the 2020 F150 and specifically the 5.0L V8 Engine. I have kept up to date on all maintenance, no visible oil spils and engine is consuming/burning significant amounts of oil. I've been told by numerous dealerships/mechanics that there is nothing that they can do and to try and join all of the class action lawsuits. I spent 50k on a vehicle that isn't even making it thru the life of the loan..... WHY DO I HAVE TO DO A CLASS ACTION. THIS SHOULD BE CONSUMER PROTECTION.

- Lebanon, IN, USA

problem #94

Mar 072025

F-150

  • miles
The truck is stuttering when you go wide open throttle

- El Paso, TX, USA

problem #93

Jun 302025

F-150

  • 80,000 miles
The contact owns a 2020 Ford F-150. The contact stated while driving 15 MPH, the vehicle failed to accelerate as intended while depressing the accelerator pedal and the engine seized. The contact was able to coast to the side of the road. The oil warning light was illuminated. The oil gauge indicator was at zero. The vehicle was towed to an independent mechanic who diagnosed the vehicle with a cracked crankshaft between cylinders #2 and #3 and a cracked oil pan. The contact stated that the short block showed signs of metal shavings. The contact was informed that the engine needed to be replaced. The vehicle was not repaired due to the cost. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was approximately 80,000.

- Palatka, FL, USA

problem #92

Jun 092025

F-150

  • miles
Ford 10r80 Transmission slips or revs for long period of time before banging into gear when accelerating. When accelerating and merging onto the highway I am unable to merge and accelerate to highway speed without the risk of being rear ended by oncoming vehicles already at highway speed. The vehicle has been inspected and confirmed that the transmission needs to be replaced. No other lights and absolutely not warnings at any time before problem started. As per TSB 23-2250 and several earlier TSB on this transmission, having a known defect, Ford should escalate this to a recall and compensate owners for the expensive repair when the vehicle should have plenty of more life in it.

- Flemington, NJ, USA

problem #91

Jun 202025

F-150

  • miles
Exhaust manifold leak due to factory turbo mounting and bolts issue. Due to improper amount of bolts in rear of exhaust manifold where ford designed the turbochargers to mount to there is warping of the exhaust manifold and the mounting bolts break off due to heating and cooling with the turbochargers weight. Very common issue with the f150, causing exhaust leaks and possible carbon monoxide to leak into cabin. This is a dangerous design flaw that owners should not have to pay out of pocket to repair due to fords poor engine design flaw. Ford should have to recall the engine manifolds

- Howell, NJ, USA

problem #90

Jan 202025

F-150

  • miles
Time Line for the problem: 10/14/2024 Oil Change completed by Joe Myers Ford @69,392 miles [XXX] Check engine light comes on; solid; not blinking;01/20/25 Immediately took vehicle to Joe Myer, within one mile;01/20/25 Requested service advisor, Brandon P to check vehicle; was told it would be 5 days before anyone was available to look at the vehicle 01/20/25 Immediately took vehicle to Cliff Auto Repair, approx 3 miles. They checked the oil level and found no oil on the dip stick. They emptied the oil and found only 3 quarts was in the crankcase; approximately 5.5 quarts low. They completed the oil change an topped off the oil Per the technician, the oil was not burnt. Per comment on receipt "it appears oil was not filled to correct level on last oil change 01/22/25 Took vehicle back to Joe Myers to be checked for excessive oil consumption 01/22/25 Received estimate for repair service 01/23/25 Picked up vehicle Repairs completed: (1) oil change (2) Reprogramming PCM (3) Replaced dipstick; was told to return after 3000 miles to be checked again 03/20/25 Brought vehicle to Joe Myers at 3000 miles; was told after inspection that entire engine replacement was necessary at a cost of $11,007.10; Service Advisor, Kevin Ryan said Joe Myers was not responsible for the damage 04/10/25 I was referred to Service Manager, Phillip Martinez. He referred me to the Ford Motor Company to ask for good will. He gave me the number to call and said that was all he could do 04/11/25 Mr. Martinez told me he would check with Ford good will himself on my behalf 04/16/25 Ford agree to pay $5000 total 05/01/25 I received the vehicle back from Joe Myers with the engine replaced; paid $5,369.19. The vehicle has been "inspected" by Joe Myers at minimum 10 times since purchase. Why was the Technical Service Bulletin from Ford (TSB)19-2365) completely ignored thru all 10 inspections? I also suspect that Joe Myers technicians did not fill it with oil. I should be reimbursed for either reason INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORM

- Houston, TX, USA

problem #89

Jan 282025

F-150

  • 100,800 miles
The contact owns a 2020 Ford F-150. The contact stated that upon starting the vehicle, there was an abnormal rattling sound coming from the engine, followed by a rough idle. There was no warning light illuminated. The vehicle was taken to a local dealer, where it was diagnosed that the cam phasers had failed and needed to be replaced. The vehicle was not repaired. The contact related to the failure to Ford Campaign Number: 21B10. No further information was available. The failure mileage was approximately 100,800.

- Gainesville, FL, USA

problem #88

May 152025

F-150

  • 137,000 miles
The contact owns a 2020 Ford F-150. The contact stated that the vehicle made an abnormal rattling sound on cold start. The vehicle was taken to the dealer, where it was diagnosed that the cam phasers had failed and needed to be replaced. The dealer informed the contact that the vehicle was not covered under Ford Campaign Number: 21N03. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that the VIN was not included in a recall. The manufacturer referred the contact to the NHTSA Hotline for the VIN to be added in a recall. The failure mileage was approximately 137,000. The VIN was not available.

- Sylva, NC, USA

problem #87

May 122025

F-150

  • miles
I was driving on Loop 610 with stop and go traffic and after a lot of restarts the engine almost did not restart. If it would have not restart I would have been trapped in traffic in a mid lane which would have resulted in a various dangerous situation. Ford needs to install a switch to allow owners to disconnect the device that kills the engine when you stop. We are getting ready for hurricane season and based on past history if we have to do a mass evaluation we have vehicles with this devise that could result in blocking traffic and not allow people to evacuate result in potentially many lives lost.

- Bellaire, TX, USA

problem #86

Apr 012025

F-150

  • 94,000 miles
The contact owns a 2020 Ford F-150. The contact stated while the vehicle was parked and occupied, while attempting to start the vehicle, the contact heard an abnormal ticking sound coming from the engine. A dealer was contacted. The vehicle was taken to a dealer where it was diagnosed with cam phaser failure. The contact was informed that the cam phaser needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure and opened a case. The approximate failure mileage was 94,000.

- Port St. Lucie, FL, USA

problem #85

Mar 152025

F-150

  • miles
I am writing to report a serious safety issue with my Ford F-150. On March 15th, 2025 while driving on State Route 167 - 410 in heavy rain, my vehicle experienced an intermittent engine shutdown while in motion. Second time happened to my wife while leaving the neighborhood on March 18th, 2025. Specifically, the engine completely shut off while driving at 40 mph. This occurred despite the Auto Start-Stop feature being manually disabled. Upon the engine shutdown, the Driver Information Center (DIC) displayed the message, "Auto StartStop Shift to P, then Restart Engine." The car did not lost power and I needed to do a full stop, shift to P, restart and switch back to D to continue driving. This malfunction occurred under hazardous conditions, specifically during heavy rain on a freeway. The sudden loss of engine power created a highly dangerous situation, placing myself and other drivers at significant risk. I am deeply concerned about the potential safety implications of this issue. The fact that the engine shut down while driving, even with the Auto Start-Stop feature disabled, suggests a critical malfunction that requires immediate attention. Despite having an extended warranty and the serious nature of this safety concern, the service department from Sunset charged me money for an unsuccessful diagnosis after two days, with service advisor unable to identify or replicate the problem.

- Bonney Lake, WA, USA

problem #84

Apr 022025

F-150

  • miles
*Engine failed - Rattle was detected and after dealership took a look at the vehicle, it was determined that the engine needed replaced because the truck was consuming oil at a high rate and there was metal found in the manifold. I continued to drive a truck with low oil, a failure of engine/engine fire could have occurred (oil was changed 2 weeks prior to inspection). *Confirmed by dealer *Vehicle was inspected by dealership warnings, just a very subtle rattle at low speeds that was concerning. Engine ran fine otherwise. Rattle first appeared around $45k miles.

- Greenwood, IN, USA

problem #83

Apr 042025

F-150

  • 126,000 miles
The contact owns a 2020 Ford F-150. The contact stated had received notification of Manufacturer Recall Number: 24E12. The contact stated that the vehicle had not experienced any failure; however, the vehicle was taken to a dealer where the PCM module was updated as per the recall. The contact stated that 15 hours after the repair, the check engine warning light illuminated. The manufacturer was notified of the failure. The failure mileage was 126,000.

- Prosper, TX, USA

problem #82

Dec 022024

F-150

  • 100,000 miles
The contact owns a 2020 Ford F-150. The contact stated that the check engine warning light was illuminated, and the contact became aware of a significant loss in fuel economy. The vehicle was taken to a certified mechanic who diagnosed that the catalytic converter had failed. The vehicle was not repaired. The vehicle was taken to the dealer, who diagnosed that the catalytic converters had failed. The contact was informed that the catalytic converters needed to be replaced. The vehicle was not repaired. The manufacturer was informed of the failure and opened a case. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 100,000.

- Mechanicsville, VA, USA

Read the next 20 complaints »