Airbag light came on at about 85,000 miles. Occurred after starting up after being parked facing the wind on a very windy day. Took to dealer, needs new rcm module. Was told no airbags would deploy until replaced. Apparently it is very expensive repair for something that concerns safety of the vehicle.

- Dodge City, KS, USA

The passenger side air bag quit working. The air bag warning light came on and would not go off. Do not know if automobile was moving or still. Had to have replace the inboard and outboard seat zero weight sensors, rail assembly and replace the passenger seat air bag module. It was very expensive for a part of the car that should last more than 54000 miles.

- Chattanooga, TN, USA

The contact owns a 2007 Ford Fusion. After starting the vehicle, the passenger side air bag warning light illuminated. The vehicle was taken to a dealer who was unable to diagnose or repair the vehicle; however, the failure recurred and the vehicle was taken back to the dealer. The contact was unsure about what part needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 30,000. The VIN was unavailable. Updated 1/27/2016

- Minooka, IL, USA

The contact owns a 2007 Ford Fusion. The contact stated that the passenger side dashboard was raised over the position of the air bag cover. Since the failure, the air bag sensor light would intermittently illuminate. The vehicle was taken to the dealer who indicated that the dashboard would need to be replaced. The manufacturer was not notified. The failure mileage was 97,000.

- Bloomington, IL, USA

I took my 2007 Ford Fusion to a dealership in regards to my passenger side dash had begun to bulge in the beginning of the year. They stated it was O.K. and I did not need to worry about the airbag deploying. I asked them how much would it be to fix it and they told me that it could not be fixed; and no one recommended how to fix it. The bulge has gotten worse and it looks as if the airbag is going to deploy. I took it back to the dealership on August 19, 2015 and was told that they does not fix cosmetic work or trim.

- Las Vegas, NV, USA

The contact owns a 2007 Ford Fusion. The contact stated that the air bag warning light on the passenger side illuminated as soon as the vehicle was started. The vehicle was taken to a dealer where it was diagnosed, as the passenger occupant control weight module that needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was 134,353.

- Copley, OH, USA

The air bag light came on and stayed on. I took it to the local Ford dealership. The service rep said that the passenger seat air bag sensor was defective. He said that there were no recalls and it would cost me $868 to fix it. I can't afford it so we're driving it with the light on. I think Ford should replace it because many people have the same or similar problem with their Fusion as well as a host of other makes makes, models, and years....updated 09/22/15 updated 11/28/2017

- Andover, MN, USA

Passenger side airbag is bulging out of dash.

- Lindenhurst, IL, USA

Passenger side dash around air bag is buldging

- Menasha, WI, USA

The dashboard on the passenger side around the airbag is bulging. It has gotten worse as time goes on. I am worried that if I was ever in an accident, the passenger would not be protected.

- Layton, UT, USA

Passenger side airbag is bulging up on one side. I park in a garage and I'm in wi so we don't get extreme heat, so I'm not sure why I'm having a issue. It's either an airbag issue or a dashboard issue. My passenger side airbag light appears to be working fine...it only goes on with a passenger or when my purse gets too heavy and its on the seat. Also, my accelerator petal makes a weird static-sounding noise when it's at a certain position. It has nothing to do with speed, it happens at various speeds, so it's only when the petal is held in the same spot which is about halfway down to the floor. If I press the petal down beyond this spot or raise my foot so the petal is above that spot, the noise stops...only to return again when the petal eventually lands back in that problematic spot (about halfway down).

- Manitowoc, WI, USA

There is a bulging on my passenger side airbag, my passenger light airbag comes on I have approximately 93000 miles on my Ford Fusion.

- West Bloomfield, MI, USA

Dashboard around front passenger airbag is bulging up and will likely interfere with proper deployment of the bag in case of accident. This is a chronic problem with first generation Fusion that Ford refuses to address.

- Novato, CA, USA

On several occasions, primarily in colder weather, the air bag indicator in the instrument cluster on the dash board remains on after starting. This happens unpredictably at random intervals. Once the engine is warm, shutting off the ignition and restarting will resolve the problem. I am told that the air bags will not deploy if the air bag light is on.

- Ann Arbor, MI, USA

The contact owns a 2007 Ford Fusion. The contact stated that the dashboard detached from the air bag. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 63,000.

- Deer Park, NY, USA

The contact owns 2007 Ford Fusion. The contact stated that when swerving from oncoming traffic the vehicle rolled over and the airbags failed to deploy. The contact mentioned that the seat belt on the rear left hand side failed to lock causing the passenger to be ejected from the vehicle. A police report was filed and minor injuries were sustained to 3 occupants. As a result of the crash, the ejected passenger was paralyzed. The manufacturer was not made aware of the failure. The failure mileage was unknown. The VIN number was unavailable.

- Yucca Valley, CA, USA

Air bag is bulging out of the dashboard. I heard lots of other complaints & thought there was a recall on these airbags!

- North Arlington, NJ, USA

Back in June,2014 I noticed something weird on my dash. For some reason the dash above the passenger side airbag is bubbling up. At first I thought it might be the heat from the sun, so I started parking my car in the shade to avoid higher temps hitting the dash. Unfortunately, it did not help. The bubble kept growing and growing. Now it's so large that I am worried that the airbag has become compromised. I am concerned that the airbag may deploy when I'm driving or possible not deploy if I am in a car accident. It appears there are quite a few people complaining about the same problem. Please fix this Ford!! very dangerous!

- Lockport, NY, USA

Dash under airbag, above glove box on passenger side. Bulging and airbag light on.

- Sunbury, PA, USA

The passenger side air bag above the glove compartment is exposed. Now my airbag like will not turn off.

- N. Las Vegas, NV, USA