On Saturday June 16th I was traveling North bound I-75 from rockcastle co. Ky to madison co ky which is about 45 miles. Was traveling 65 miles mph and suddenly the engine shut off. There was a semi in the right lane, we were in the middle lane with one semi in back of us. We were able to coast to the emergency side of the road. The semi in back of us locked his brake and almost hit us. I shut the car off and restarted it and drove in the slow lane and it happened 3 more times. I then left the car at my mother in-law's house and borrowed a car to get home in as I was afraid to drive it and put myself at risk plus someone's life at risk. On Monday, 6-18-12 I got the car to the dealership and the mechanic test drove it and it happened to him. I pulled up on the internet and saw that I am not the only one this has happened to. It definitely is a life ending crash getting ready to happen. Of course my vehicle is out of warranty as of 35000 miles, but that is not my issue. I would hate to see someone lose their life due a malfunction of a throttle body. Ford needs to step up to the plate and admit that know of this issue and fix it before someone loses their life or a child's life. The foreign makers such as Toyota stepped up and Ford needs to do so also. This is the fourth automobile I have brought from them and try to stay with the american made cars. Safety should be their concern instead of the almighty dollar.

- Mount Vernon, KY, USA

After stopping for a red signal in traffic (vehicle travel uphill) the vehicle lost drive (acted as if the vehicle had been shifted out of gear). After a harsh engagement, the vehicle regained drive. The vehicle was driven home without further incident that day. The vehicle was taken to a dealer to get the PCM "flashed", I assume with a new shift profile. The vehicle malfunctioned two more times with a data recorder from the dealership installed. The loss of drive occurred after rapidly decelerating to slightly less than 40 mph and then trying to accelerate to the previous speed. Again, engagement was harsh when the transmission began to provide drive. Ford has acknowledged at least one engine RPM spike from the recorder, but denies that it is significant or that it is indicative of a problem. I have had the transmission fluid from this vehicle tested at an independent laboratory. The sample results showed the transmission fluid to be high in aluminum (7 times the average for a unit with similar miles), and high in iron about 1.6 times the average. This problem is a great safety concern because if the vehicle were to lose drive when pulling out into traffic, an accident involving injury or death could occur! I have found a youtube video posted that represents the problem I am experiencing by using the google search engine and using the querry "Ford Fusion transmission problems" since the PCM flash the automatic transmission seems to behave at times like a manual transmission. On a coastdown it seems like the transmission is "pushing " the car like a manual transmission with the clutch engaged even though I want the car to coast down. The reprogramming has made shifting more harsh in some gear changes, and seem to skip over the problem gears in other shifts.

- Aliquippa, PA, USA

I was driving down the highway when I lost the ability to accelerate. My rpms dropped and I had to pull over. I called Ford roadside services, they came and picked up my car. After being looked at by the Ford dealership, it was determined my throttle body needed to be replaced. My car is less than 2 years old and only has 40,000 miles on it. The part and labor totaled around $500 this is ridiculous for a new car to already have this issues. I did some research on the internet and found that multiple Ford Fusion are having the same issue. This item needs to be recalled and replaced. I can only thank god it was during the day and in a public area. If this had been at night with my 7 year in a bad area, no telling what could have happened. I was lucky the people behind me on the freeway noticed I was slowing down or I could have been involved in an accident. Ford needs to step up and fix this.

- Friendswood, TX, USA

My Fusion has become erratic in low gear shifts. When trying to merge into traffic and turn onto a highway it will act as though it is in neutral and I have no power to get out in traffic. I have been almost hit on a major highway do to this mechanical failure. I took the car to a dealership for repair and they informed me that it was low on transmission fluid and they repaired a seal and reprogrammed it as Ford directed. I took the car on a trip and I was unable to merge into traffic again and it ran at over 5000rpm on the highway for long periods of time. It finally flipped a code and I returned it to the dealership. They did a complete transmission overhaul and replaced over 15 parts. This took two weeks with them having to deal with Ford warranty department. I picked up the car on 6/6/2012 and it did not even make it to my place of work, 12 miles away, without the transmission slipping again and it remaining in neutral. This car is a death trap!! I called the dealership and they came and picked it up. It is now 6/12/2012 and I still do not have a car to drive. The dealership is fighting with Ford to have the complete transmission replaced. Ford has contacted me several times and it seems as though they do not care that this car is a danger to have on the road. I want my car back in working condition. I am pleased with my dealership of choice for service as they have been very polite and helpful with me. Ford has given me nothing to drive in the meantime. People, if you have this issue with your car make sure Ford hears your complaint. This is dangerous and unacceptable.

- New Paris , IN, USA

While driving the vehicle under normal conditions at speed on an open highway the car suddenly lost all throttle control and transmission response, a 'wrench' warning light came on the vehicle gauge cluster. After coasting to a stop in the breakdown lane the car sat, idled roughly, and I turned the ignition off. After a minute or two I started the car and the symptoms (including the wrench warning light) were gone. I brought the vehicle to the dealer service desk and after analysis was told there were no events captured by the vehicle computer. I was told to drive the car and report any additional instances of the problem. After the issue resurfaced again three weeks later, I again brought the vehicle to the service team at my dealership. After again not finding events logged in the computer, they installed a temporary data recorder for me to manually engage the next time the issue appeared. I was lucky to have the problem the very next day, the recorder captured the event and reflected the problem was with the throttle body. The dealer replaced the unit. Upon researching the issue after the first instance it is clear there are hundreds of cases of this same problem documented in various forms and sites on the web indicating this is a known, systemic problem for Ford with the Fusion throttle body. The nature of the problem, effecting vehicle control, at speed, is dangerous and would seem to warrant a more proactive approach to the issue both by Ford and by the NHTSA.

- Fitchburg, MA, USA

While driving the car at 55mph I let my foot off the gas and then went to accelerate and the car lost all power. Would not recognize the gas pedal check engine light and wrench light were on. Car died in a construction zone with 3 lanes and no shoulder. Extremely dangerous. I pulled car to right lane turned car off and on car continued on. Took car to dealer. Advised no message was marked in computer. There was nothing wrong could not repeat problem. 5 days later while driving home in traffic the car once again lost all power would not recognize gas pedal, check engine and wrench light came on. I pushed car to the shoulder, turned car off and on continued 100 feet car died again 17 more times. I had car towed to dealer. Dealer replaced transmission control. Car now shifts horribly, and has a jump when you let off gas. Car has stalled numerous times. Ford needs to recall for the transmission control module. Ford needs to admit there is issues with the transmissions in the V6 Fusion. I had similar transmission issues with my Ford edge and Mercury Sable.

- North Plainfield, NJ, USA

While driving the car on a sunny day about 35 mph the car started to slow down abruptly to 5 mph. The advance track light came on and service advance track immediately message went across the message center. I immediately took the car to the dealer. Light and message were on when I dropped off the car to the dealer. Dealer stating could not repeat problem.

- North Plainfield, NJ, USA

Engine began shutting down while moving in morning rush hour. Also surges forward and runs thru multiple gears while in stop and go traffic with light, if any throttle applied. On 6-8-12 engine went into failsafe mode, 1100 RPM while traveling at 60 mph. No response from throttle, had to manipulate thru traffic to beach car upon shoulder of road. After shutting off key and restarting, vehicle seemed fine, but same situation happened twice more within minutes. Drove car to nearest Ford dealer who "cleared the old codes" and test drove, finding no further issue. Billed me under esp service agreement, and continued onto work. Leaving work to make deliveries, car initiated exactly same response as earlier (5 times), at various speeds, and again, heavy traffic. Took to dealer I bought car from, who immediately claimed it needed a new throttle body, which are on national back-order, delivery date unknown. Referred to another dealer who had open bays and a throttle body in stock, but for some reason was uninterested in even looking at the car. Offered to leave car, esp offers rental, so I could return to work, but that part has become uncovered by the extended warranty, and they still had no interest in fixing car after I agreed to pay myself. Transmission has a quirky problem of downshifting aggressively when traveling downhill, up-shifting rapidly in slow moving traffic, and now a throttle body problem which causes car to go into a no power situation while at speed.

- Union Grove, AL, USA

Gears just dropped out and car simply idled. Had to pull over into left turn lane and turn off vehicle and restart. Car worked fine again for two weeks when it happened again. It happened most recently on 06/06/12 three times in one day. Once on the way to the office, once on the way home from the office, and once on the way back from my financial advisor's office when I had my fiance in the car.

- Coral Springs, FL, USA

While attempting to accelerate, automatic transmission stalls and wrench light illuminates. At first I could turn the car off and back on, but eventually, the car stopped functioning altogether. Analysis was performed and throttle body was the cause. Has occurred with other 2010 Fusion sels. Ford unwilling to replace faulty manufactured part.

- Nashville, TN, USA

I have a 2010 Ford Fusion with a four cylinder engine. While driving to work, I started speeding up from an intersection, only to experience a complete and total loss of power, the wrench light came, the engine started misfiring (rough idle at less than 550 RPM), but all systems where still working. Pressing the gas pedal produced no results. I was able to pull off the side of the road, stop the engine, let the car sit for about 15 seconds, and then restarted it. When the engine restarted, the car started up and ran like nothing had happened. Yesterday (June 1st), the Fusion did the exact same thing, except this time I was pulling into an intersection (approximately 5 miles per hour). I had a catastrophic loss of power, the wrench light came on again, the engine was misfiring (rough idle), the rest of the systems continued working. Luckily no one was coming in my direction and I was able to pull off the road into a parking lot, stop the car, and then restart it. I took it to the dealer today and they diagnosed it as needing a new throttle body. They quoted the price and labor at $400 for the repair. I've had this car less than 1 year and it only has 49,800 miles on it. If I had been pulling onto a busy street and experienced the same loss of power, it could have been a much more dangerous situation. According to my research, this is a common problem with the 2010 Ford Fusion, and the replacement part has been "redesigned" according to the dealer where I took my car for repair.

- Lexington, KY, USA

While accelerating from a stop the engine suddenly cut out and began a rough idle. The check engine light and the wrench light came on. The engine would not rev even with the gas pedal pushed in. Coasted to a stop. Turned the ignition off and then restarted the car. The check engine light and wrench light were no longer lit. Started to accelerate away and then it happened again with the check engine light and wrench light on. I was able to idle home. Once at home I turned the ignition off and started it back up. This time the check engine light came on but not the wrench. While in park I would rev the engine and it sounded fine and could not get the engine to shut down while revving. I didn't move the car and had it towed. Fortunately it has only 32707 miles on it and covered by warranty. So, will have to wait to find out what the cause is. Based on other complaints and their follow-up it sounds like the throttle body issue.

- Baton Rouge, LA, USA

When trying to accelerate, rpms would rev to between 4000-5000 but car would not speed up. Once it finally started (after three tries), car finally jerked forward and shuddered before speeding up. After driving for about 30 minutes, I then tried to reverse the car and it jerked and grinded extremely hard. Smells like something is burning at times. Took to dealership twice already, but still having problems.

- Raymore, MO, USA

While driving my car suddenly went into shut down mode. A wrench symbol showed on panel. I was able to turn into a drive way and after turning the vehicle off and back on the wrench went off and the car ran normal. I took to the shop and nothing showed on the computer. It then happened 5 more times. Back to the dealership now says that it is bad throttle body and is not covered. After researching online it appears to be a bigger problem and Ford should recall. There are so many complaints that it is obvious that it is a defect. People are going to get killed. Ford fix this now. I have no choice but to pay to have it fixed but I shouldn't. it would be very interesting to see how many have been fixed to date just by Ford and not other companies.

- Denham Springs, LA, USA

I drive approximately 30 miles on the highway to get to work. The day this problem first occurred, I got off the highway and came to a stop sign. I checked for traffic both directions. A car was coming from the left, and I was turning right. I knew with my car's acceleration I had plenty of space to pull out safely (it has a V6 engine, automatic transmission). I hit the gas and pulled out. The car did not accelerate as expected. I barely hit 5 mph and the tachometer redlined. I took my foot off the gas pedal and tried again. Same thing - redlined. The third time I tried, the car shuddered and finally shifted to the next gear. The car behind me was far enough away to slow down safely, but in a different situation they could have easily hit me. I just rolled out in front of them because the car didn't respond when I hit the gas. Immediately after that incident, I scheduled a service appointment at a Ford dealership. The first available appointment was two weeks out. I booked the appointment and continued to (cautiously) drive my car to work. The car ran rough even at constant highway speeds. Last night I dropped my car off at the dealership for the service appointment. I took the highway to get there. When I tried to accelerate to merge onto the highway, the problem occurred again. I rolled out into traffic at about 5 mph, hitting the gas pedal and getting nothing. Again, I was lucky that there was enough room between me and the approaching traffic. This problem could have easily caused a bad accident. My car is currently at the Ford dealership. I'm waiting for them to call back with a diagnosis.

- Pittsburgh, PA, USA

Driving on the West Virginia turnpike at 65-70 mph when the RPM's jumped above 4 and lost all power to the engine. The engine was still running but had no power from the gas pedal to the engine. Pulled to the far right side of the road as I was going up hill into the truck lane and then eventually on to the berm as the trucks were now running faster than me going uphill. It was the most dangerous driving situation I have ever been through. I was able to locate a Ford dealership on the turnpike where I could leave the car for the necessary repairs. The repairs took a total of 25 days. Ford would not provide me with a loaner car as I bought the vehicle used and therefore no rental coverage even though the issue was a known issue due to faulty parts and a poor initial repair by Ford. I had to rent a vehicle in West Virginia in order to complete my drive home and had to drop the rental in columbus. $185 + gas + deposit and resulting nsf fees in my checking account for a 12 hour car rental that Ford would not cover. Upon getting my vehicle back it ran smoothly until October of the same year. I took my vehicle to a national chain oil change company who advised that they could see transaxle fluid all the way to the back of the underbody of the vehicle. I took the car to my local Ford dealership who found that the repair completed in West Virginia did not get the pan sealed properly and the fluid was leaking from the faulty seal, which they repaired but it took them 14 days to do so. Fast forward to may and another hard shift with a lurch forward and then no power from the gas pedal to the engine. Took it to the local dealership who could find no error codes and could not duplicate the issue. 5/13 - mother's day and it happens again but this time the engine light is now on and the car runs rough. Taking to dealership again tomorrow.

- Columbus, OH, USA

On 5/12/12 coming home from a softball tournament with the cruise on at around 65 mph the yellow wrench light came on. Engine was still running but could not accelerate. Coasted into a church parking lot. Put the car in park and restarted. When restarting seemed hard to start...like an alternator issue. Arrived home safely (was about 5 miles from home when incident happened). On 5/13/12 (Sunday) same issue except it happened 3 times during a 30 mile trip. The last time I had pulled over and put it into park I was worried it wouldn't start...turned and turned but slowly...again sounded like an alternator. I had issues with the cruise control a few months back and of course nothing was found to be wrong. Short story is when I hit "resume" to get it back to the speed it was while on cruise control the RPM's will run 5000-6000 for F a R longer than it should. The car will be to the desired speed and it will stay at the high RPM for 4-6 seconds instead of kicking into the next gear which obviously is hard on the engine and gas mileage. Not happy with the dealership in their investigation of matters and not happy with the car itself.

- Murphy, TX, USA

I was driving home and going up a hill when I felt the vehicle slow acceleration and then it revved back up. The transmission/throttle control light came on so I pulled over. I turned the vehicle off and waited for a few minutes. Turned the vehicle back on and when I went to accelerate it lurched. I continued driving home and since it was after 9:00 P.M. when I got home, I couldn't take it to the dealership until the next morning. On May 11, 2012 I took it to the dealership and they called to tell me that the vehicle slipped from 4th gear into 5th gear and this should never happen so they were going to have to pull the transmission and I would be without my car for 5-6 days. After research on the internet it appears that several people are having this same issue with the transmission of the 2010 Ford Fusion.

- Ozark, MO, USA

2010 Ford Fusion: While driving at 65mph on a highway with cruise control set the car lost power and stalled. Tachometer dropped to 1000 rpms and fluctuated between 500 - 1000 rpms. Wrench light (throttle / transmission) illuminated and the car coasted to a crawl at less than 5mph. The car's throttle was unresponsive and I was unable to accelerate. I became a serious rear-end hazard in a construction zone and had to pull off to the side of the road. I put the car in park, restarted it and the car ran fine. I am just barely under warranty (and just bought the car 1 week ago) so I brought it to a Ford dealer - they "checked" the car and found "nothing wrong" with their computer scan and stated that there was no error code - so there was nothing that they could do. The day after I picked the car up from the dealer the car did the same thing, twice. This time it did it after a cold start in the morning and again when I left work in the afternoon - again the wrench light came on and shut off once I restarted the car. Bringing the car in tomorrow again...we'll see what happens. What a safety risk - my wife refuses to drive the car!

- Schofield, WI, USA

While driving on the interstate, the wrench light came on and the car became unresponsive to acceleration. I had to turn on the hazards and coast to the shoulder. The car was able to be restarted and drove fine for another 30 minutes before the same thing happened again. 2 days later the same thing happened on the interstate again, requiring me to coast to the shoulder of the road! today it happened while I was only going 45 mph and happened three times in 10 miles. When I got home I immediately began researching other Ford Fusion problems and found this to be a common occurrence. We tested the chip of the car and got a code of P2112, indicating the throttle body was malfunctioning. This comes behind an electrical problem requiring a new battery after 50,000 miles, a plastic piece breaking off the sunroof and needing to be replaced at 40,000 miles, and the sunglasses spring breaking at 35,000 miles! this is the second Ford I have owned and we were thrilled with our Ford five hundred, but the Fusion seems to have more problems than it has good qualities! Ford really needs to find a fix for their throttle problem before one of us is injured or killed while we coast to safety on the interstate in a malfunctioning car!

- Columbia, SC, USA