1.9
hardly worth mentioning- Crashes / Fires:
- 0 / 0
- Injuries / Deaths:
- 0 / 0
- Average Mileage:
- 83,801 miles
About These NHTSA Complaints:
The NHTSA is the US gov't agency tasked with vehicle safety. Complaints can be spread across multiple & redundant categories, & are not organized by problem. See the Back button — blue bar at the very top of the page — to explore more.
I have owned car for almost 4 + years I was roughly at 128,000 when I purchase I gave 159, xxx miles on now. In the past 4 years tires replaced 2 times. I keep having issues with tires needing plugged in front. My brakes have been replaced 3 times rotors 2 times plus struts ball joints tie rod u name it repaired suspension system sucks. I-??m sick of having same issues repair. I have thousands of dollars front suspension then always have to fix tires stop for air replace. Ridiculous. Everything has gone wrong with the suspension system. Shocks bad ball bearings. The premium aluminum rims eroding away. I think that is what cause tire issues non stop I-??m sick of getting air!!! I can-??t afford to keep repairing the steering has became awful pulls yes I-??ve had alignments it-??s all over the place feels loose makes all kinds of banging clunking noises the wheel locked up had smoke rolling out from front driver side. Smelled terrible car shaking all over around 45 mph. I have more in the front than car is worth transmission jumps all over or jerks hard into drive or reverse I had look at and repaired once all ready Door handles in side don-??t work!! Check engine light always on the cap less fuel area is junk the ring came off. When pumping gas it doesn-??t stop it now. So gas is usually on ground running down car side Headlight are always getting loose knocking out my headlights. for only have 30,000 from buying it I have spent as much buying the car the equals the cars repairs almost. Chunks of paint in front falls off below grille brakes/steering have defaulted and I have slid across intersection in winter I could have been seriously injured and of course another tire issue today I want my money back and the repair money!!! Paid 7,000 put $ into all the time invested roughly 12,000 all together for same [XXX] issues. Car value 3,000 Wtf. Make it right FORD!!!! Yr cars are junk on certain models recalls never knew they better be getting fix for free. INFORMATION Redacted PURSUANT TO THE FREEDOM
- Spencerville, OH, USA
My car has been absolutely fine for the most part until about 4 weeks ago, while I was driving the low tire pressure light came on, so I went and aired up the tires, the low tire pressure light went off but then the service power steering light and advance tire traction appeared at this time im pulling back into my drive way, then I came out my house a few hours to leave and the stirring wheel was locked I tried to drive it and now the strring wheels goes to the right I never had this issue before let alone any warning signs.. I looked into recalls with Ford and it showed my 2011 Ford Fusion had recalls for whats going on, so I called a Lincoln Ford dealership that said bring it in they kept my car for a week and when I picked it up nothing was fixed on it and they had no paperwork to give me the show they fixed it so I returned my car the very next day because when I drove off it was still doing exactly the same thing but worse so now they've had my car for a week and they called me this morning to tell me my car has been doing the same exact thing and it is the wire harness that needs to be fixed and it's not under the recall but it is part of the power steering so I don't get
- Mesa, AZ, USA
Service power steering light illuminated, total loss is steering while I was driving.popping sound. Very dangerous. Goes in and out, sometimes works then suddenly while driving it stops working.
- Onley, VA, USA
While turning and going slow the steering makes a very bad creaking sound that is impossible to ignore. Have noticed many other people with the same problem on Fusion and nobody knows a fix. I'm not sure who will see this but if it is taken into account Ford needs to recall these as it is very common with Fusion from 2010-12.
- Lorain, OH, USA
The contact owns a 2011 Ford Fusion. The contact stated that the rack and pinion steering was replaced by the dealer sheehy Ford of marlow heights (5000 auth rd, marlow heights, md 20746 (301) 298-0793) on 11/15/19. The vehicle had been hard to steer in making turns. After the repair the tie rods also malfunctioned. The contact suspects the repair on the rack and pinion steering caused the new issue with the tie rods. The manufacturer was notified and a case was opened as well as the contact was referred to NHTSA. The failure mileage was 98,947.
- Temple Hills, MD, USA
Two issues: While driving error message maintenance power steering now came on. Automatic steering went. Twice again after the mechanic reset it. Extremely difficult to turn. Could be extremely dangerous. I took the car to the local dealer, (walker Ford, clearwater, fl) and although there is a recall it doesn't apply to my vehicle. Very expensive to fix, in the $2000 range. The other problem which is the first reason we went to the mechanic. The front end has been making noises, creaking and crunching when making turns or cold. That issue needs control arm replaced which is connected to the subframe very costly. I have seen both these issued addressed in numerous complaints online. Front suspension control arm problem of the 2012 Ford Fusion 2 failure date: 03/02/2019 this below is what happened in detail. The low tire pressure light came on inside the dash as I was driving so I drove about to get air. After I put air in the tire, started the car and immediately got a warning that power steering needed servicing. Then got another warning that advance track needed servicing. All happened at the same time and the power steering was completely gone out. Controlling rack needs replacing. 2000 the service dept said the gear inside the power steering rack has gone bad and the control arms it sits on has worn out the gear therefore needing front lower control arms costing $1500
- Clearwater, FL, USA
I pulled in my driveway, parked 2011 Ford Fusion and then shut vehicle off. I returned, started vehicle, went to start driving my vehicle out of driveway and the car started beeping and listed that the power steering did not work. I looked it up online and there was a recall for steering: Electric power assist system failure (15V340000 or 15S18). I took to dealership and will attach quote which their recommendation is exactly what Ford's recommendation was. However my car doesn't fall into the correct date for this recall, I am happy that I was not driving 75mph down insterstate 70 in wheeling, wv or driving up to West Liberty, wv where I work. Either could have resulted in a horrible accident for me, my kids and potentially other vehicles involved. The car has only 73,000 miles on it roughly and is in excellent condition.
- Saint Clairsville, OH, USA
When driving at low speeds, vehicle creaks consistently. Have been told by Ford the front control arms need to be replaced. Has been an issue since 60,000 miles. Unacceptable to be quoted over $1000 to fix all control arms on a car with that many miles. Common problem in this model. We have replaced the worst control arms as they have gone bad, but still need to repair the remainder. Vehicle now has 125, xxx miles
- Huntsville, TX, USA
The steering components for my front end frequently break and the transmission has been rough ever since I got my car in 2015
- Andover, MA, USA
My alert symbols are just coming on and my steering control has changed. When I try to drive my car now losses power.
- Saint Joseph, MO, USA
Purchased car from seven star auto pensacola Florida first problem was horn he never fixed than water pump and time belt I fixed supposed to fixed throttle body but never fixed and also he never installed horn for safety I tried to get refund but I'm in school an D I work and still pay note for a defictive car and I also hit pot hole which caused more suspension damage and dealer still doesn't know how to help
- Pensacola, FL, USA
Both front springs broken at 121,000 miles -- appears to be a common problem indicated on automotive blogs and by Ford customers. Dealer quoted $840 to fix. Blamed cleveland salty winters on problem
- North Royalton, OH, USA
When I turn or go over bumps the car makes a loud squeeking/grinding noise. This started to occur after my power steering assist was replaced a month ago. Several reviews also state this is a very expensive fix. My car only has 60K miles on it for a 2011. This is completely unacceptable!
- Des Moines, IA, USA
The vehicle has started making very loud creaking noises when going over a bump or when turning the steering wheel, typically heard more when at lower speeds. The dealer indicated it's the lower control arm is safe for now; however, was recalled on the 2013-2014 Fusion. In addition, my door handle/latch also stopped working today while stationary. The door is not latching properly. This recall also affected the 2013-2014 Fusion, but not the 2011.
- Philadelphia, PA, USA
Squeaking on the left side when going over bumps or turning the steering wheel at low speed on city street.
- Claremont, CA, USA
Front passenger side coil spring over the wheel found borken. Had to replace the coil spring. Shop suggested replacing the strut as well, and also told us that this should ba a mold problem and had happened to a lot of Ford, Chevy, and 07-09 Honda, but Ford never issued a recall. There happens to be a Chevy truck next to us with a broken coil spring.
- Newmarket, NH, USA
Began having problems with this vehicle the second month after purchase. The first incident was steering wheel locked and I could not control the direction of the car. I ended up on the left side of the road off the shoulder before I could stop it. It happened on several occasions. Car dies for no reason. I end up having it towed or restarted by charging battery. The battery always has a full charge. Also I have been shopping and get in the car to start it and it will not start. Door handles would not work from inside. Windows would not open. Had to force window down enough to open from the outside. Had front door handle assemble replaced had transfer case resealed horrible smell, new tires 3 times since it was purchased had rear drive shaft replaced, fuel pump replaced had taken it to Ford just recently for what I deemed was computer problems, of course they could not find anything wrong. I was told by my mechanic the last time I had new tires put on the car that I would need new rims soon. The rims are eroding from the inside out. I have several invoices for work that was done and a few more I can't locate at this time. I would like to send them all to you. Purchase car 12/1/12.
- Gales Ferry, CT, USA
Squeaking noise coming from front axle (mostly on driver side) while driving and turning; sounds the most when outside temperature is higher (not so loud on cool days). Took it to dealer that sold the car (today 04/25/2016) to have suspension and power steering checked. I see online there are recalls on some Ford Fusion power steering? my VIN is not listed.
- Fort Pierce, FL, USA
My vehicle started sounding like something was rubbing. So I had it inspected and was told that the lower control arms on my passenger side where both damaged and in need of replacement but that my vehicle was much to new for these parts to have worn out. It will cost me $645 to repair!
- Cordova, TN, USA
- Louisville, KY, USA