Steering gear failure caused power steering to fail, diagnostic code P07ae-09. Code above associated with recall - steering control module, steering gear replacement for certain 2011-2012 Fusion models. The issue: Mechanical failure associated with parts themselves, not with assembly of vehicle. My vehicle's steering gear is covered under a recall but because my vehicle was assembled at a different plant than other covered vehicles of the same model/year, Ford will not cover the cost of the repair. My vehicle should be included in this coverage.

- Hurst, TX, USA

I had a flat tire and took my car in to replace my 2 front tires and drove off and it and I got a power steering failure and advancetrac failure.

- Macon, GA, USA

I was driving home on 01/28/2020 when the service power steering light came on. I was driving at around 35 mph, and did run over some sand that was on the road that made the car slip somewhat, but not much. And the power steering went out. I was driving at the time, but did get home safely. The service station I went to the next morning told me that there was a recall out for the power steering issue, but it seems my car is not included. Why is that if this is a known issue with the Ford Fusion? I have not yet been able to have this repaired as I do not have $1800 to $2000 to spend on this repair at the moment.

- Cherokee Village, AR, USA

Power steering went out. Received messages on my instrument cluster telling me that my power steering needs to be serviced. I was driving about 30-40 mph. After researching the issue, it appears there was a recall issued in 2015, 15S18. However my car missed the build date by 12 days. I was told my Ford my car was built on March 12th and the recall only covered up to Feb 28th. I'm having the exact same issue that the recall states however my car isn't cover as it was built 12 days after the build date. This recall needs to be investigated and the dates extended as I'm also having this issue.

- Evansville, IN, USA

The contact owns a 2012 Ford Fusion. The contact stated that the vehicle had been placed under recall NHTSA campaign number: 15V340000 (steering). The contact took the vehicle to dewey Ford located at 3055 SE Delaware ave, ankeny, ia 50021 where he had the vehicle serviced. The contact stated that while his wife was driving at 35 mph, the power steering ceased without warning. The please service power steering light had illuminated after the failure occurred; the contact's wife was able to drive the vehicle home. The contact took the vehicle back to the same dealer where they diagnosed the vehicle with a defective power steering rack. The manufacturer had been notified and informed the contact that there were no recalls on the vehicle. The vehicle had not been repaired and remained in the possession of the dealer. The failure mileage was 132,000.

- Ankeny, IA, USA

I brought this unit at an auction, but the wheel continues to look on me.... now several lights are on including check engine.

- Dallas, TX, USA

The contact owns a 2012 Ford Fusion. The contact stated while driving at approximately 40 mph, the vehicle power steering warning light illuminated. The vehicle was parked however, while attempting to restart the vehicle the following day the power steering failure was experienced. The vehicle was taken to an independent mechanic where the contact was informed that the power steering needed to be replaced however, the failure recurred. A dealer was not contacted. The manufacturer was contacted and informed of the failure. The approximate failure mileage was 115,000.

- South Bradenton, FL, USA

Power steering assist fault

- Hixson, TN, USA

I turned on my car and got a power steering assist fault. Turning the car off and back on doesn't not clear the fault. I have no power steering in my 2012 Ford Fusion.

- Clarksville, TN, USA

The contact owns a 2012 Ford Fusion. The contact stated that while attempting to start the vehicle the steering assist warning light illuminated and the steering ceased. The dealer tri state Ford (1503 Pennsylvania ave, East liverpool, oh 43920 (330) 386-6120) was contacted and the contact was informed that the vehicle should not be driven. The contact was informed that the vehicle should be taken to an authorized dealer to be repaired. The contact was informed that the repair part was a manufacturer only part and that the cost for the repair was approximately $2,600. The manufacturer was contacted and the contact was informed that there were no recalls on the vehicle. The failure mileage was 135,000.

- Albany, GA, USA

The contact owns a 2012 Ford Fusion. The contact stated that while driving at an undisclosed speed, the steering wheel became difficult to turn. The contact stated that the service power steering and traction control warning lights were illuminated. The vehicle was taken to seth wadley Ford located at 333 N butler rd, pauls valley, ok 73075, (855)857-4746, to be diagnosed. The mechanic was unable to duplicate the failure. Upon investigation, the contact associated the failure with NHTSA campaign number: 15V340000 (steering). The vehicle was not repaired. The manufacturer was informed of the failure. The failure mileage was unknown.

- Wynnewood, OK, USA

The contact owns a 2012 Ford Fusion. The contact stated that while attempting to reverse out of a parking space, the traction control warning light and advance track message displayed on the center console. The contact stated that the steering became difficult to turn. The vehicle was not taken to an independent mechanic or a dealer to be diagnosed. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 83,300.

- Champaign, IL, USA

Vehicle loss power steering while driving. Vehicle revert to manual steering mode while driving. It was so dangerous, not able to drive safely. During my investigation I found that Ford already had recalled for similar fault for certain vins range but not for all vins ( recall notice : 15S18/NHTSA recall 15V-340). Unfortunately my VIN is included in the recall vins. This already happened three time in my car, I took my car to mechanic they found following two error code C1277 (power steering angle sensor) C1963 (stability calibration - 1&2 circuit failure) I am attaching all three invoices from all mechanic garages where you can find their findings.

- Highland Park, MI, USA

My steering wheel keeps locking up. Not able to turn or drive car safely. Steering has been repaired once from recall but still quits working. Not safe to drive.

- Clackamas, OR, USA

At slow rates of speed the steering becomes very difficult to control if I was to run over a little pot hole in the street my car would jerk violently to the left or right

- Victorville, CA, USA

The contact owns a 2012 Ford Fusion. While driving 15 mph, the steering wheel became firm without warning, which made it difficult to maneuver the vehicle. The vehicle was not diagnosed or repaired. The dealer and manufacturer were not notified of the failure. The approximate failure mileage was 79,400.

- Elyria, OH, USA

The contact owns a 2012 Ford Fusion. The contact stated that the steering wheel seized while driving. Also, the electric power steering warning indicator illuminated and "see dealer immediately" was displayed. The contact called an unknown dealer to schedule an appointment. The vehicle was not taken to a dealer or independent mechanic for diagnostic testing. The contact stated that the VIN was not included in NHTSA campaign number: 15V340000 (steering) even though the failure was identical. The manufacturer was not made aware of the failure. The failure mileage was approximately 41,000.

- Orlando, FL, USA

The contact owns a 2012 Ford Fusion. The contact stated that the steering wheel failed without warning and the check engine warning indicator illuminated. The contact drove over a curb to avoid a crash. The vehicle was taken to an unknown dealer where it was diagnosed that the power steering sensor failed. The manufacturer stated that the VIN was not included in NHTSA campaign number: 15V340000 (steering). The manufacturer provided case number: 25174216. The vehicle was not repaired. The approximate failure mileage was 79,000.

- Massillon, OH, USA

Started vehicle and went to pull away from curb and there was no power steering and then noticed steering light was on in the dash lights. Vehicle was shut off until the next day, went to assess problem and when vehicle was started the light was off and power steering was back working properly.

- Port Byron, NY, USA

The contact owns a 2012 Ford Fusion. While operating the vehicle, the steering wheel seized for approximately two minutes and the power assist fault warning indicator illuminated. Tuttle-click Ford Lincoln (43 auto center dr, suite a, irvine, ca 92618, (949) 472-5200) was contacted and stated that the VIN was not included in a recall. The vehicle was not diagnosed or repaired. The failure recurred multiple times intermittently. The contact referenced NHTSA campaign number: 15V340000(steering). The manufacturer was made aware of the failure and informed the contact that the vehicle needed to be taken back to the dealer. The failure mileage was approximately 74,400.

- San Juan Capistrano, CA, USA