The contact owns a 2017 Ford Fusion. The contact stated that while attempting to start the vehicle, the vehicle started to shake. The contact allowed the vehicle to idle for one minute before driving. The battery and the check engine warning lights illuminated. The contact stated while driving at an undisclosed speed, there was white smoke coming from the exhaust. Additionally, the contact stated that the vehicle currently failed to start. The contact used a code reader to diagnose the vehicle where an undisclosed code indicating that the failure was engine related. The vehicle was taken to the dealer where it was diagnosed that coolant had leaked into the engine and the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and the contact was advised to contact the NHTSA Hotline. The failure mileage was approximately 57,000.

- Aurora, CO, USA

The contact owns a 2017 Ford Fusion. The contact stated that while operating the vehicle, the check engine warning light had remained illuminated. The vehicle was taken to the local mechanic who diagnosed a misfire the engine cylinder number 4. The vehicle was later taken to the local dealer who diagnosed that the engine short block was faulty due to coolant intrusion and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and the contact was informed that the VIN was not included in the manufacturer's customer satisfaction campaign for the failure. The failure mileage was 86,000.

- Novi, MI, USA

The contact's daughter owned a 2017 Ford Fusion. The contact stated that the vehicle was hesitating while depressing the accelerator pedal. The check engine warning light was illuminated. An independent mechanic inspected the vehicle and discovered that the rear main seal was defective. The vehicle was taken to a dealer where the rear main seal was replaced; however, the failure persisted. The vehicle was taken back to the dealer where it was discovered that coolant from the head gasket had leaked into the engine cylinder, resulting in engine failure. The manufacturer was notified of the failure and a case was filed. The vehicle was repaired. The failure mileage was approximately 53,000.

- Waukesha, WI, USA

On August 10th 2023 while traveling at highway speed on Il Rt 80, The vehicle started shaking violently. There was heavy vibration coming from the engine, & service engine light began to flash. Car was pulled off the road immediately into a gas station. This incident was abrupt, Isolated & nothing prior indicated an issue. My daughter and her friend were in the vehicle and very fortunate to have safely pulled off a busy highway without accident or injury. The vehicle has since been inspected by a Ford Dealership & a licensed auto repair shop. It has been reported that the engine has failed due to internal engine components in the lower portion of the motor. It is not feasible to rebuild this part of the motor. It has been advised I get a new replacement engine by the dealership & shop.

- Morris, IL, USA

The contact owns a 2017 Ford Fusion. The contact stated that while driving at 75 MPH, the temperature gauge began to indicate that the vehicle was overheating. The contact was able to pull to the shoulder of the road, and after a visual inspection of the engine compartment, it was observed that the coolant overflow container was empty, yet upon removing the container cap, coolant suddenly flowed back into the container, filling it. The overheating warning light was illuminated on the instrument panel. Later, the contact stated that, after starting the vehicle, she observed smoke emanating from the engine compartment and, upon visual inspection, noticed a small fire within the engine compartment that she was able to extinguish alone. No fire or police report was filed, and the vehicle suffered insignificant damage. The vehicle was taken to an independent mechanic, who diagnosed a failure with the CPV valve. The vehicle was repaired, but the failure reoccurred. The vehicle was taken back to the independent mechanic, who replaced both the fuel injector and thermostat, but again, the failure reoccurred. After investigating the failure, the contact related it to Ford's TSB 19-2346 (Engine and Engine Cooling), but the VIN was not included. The manufacturer was notified of the failure but referred the contact to the NHTSA hotline for assistance. The failure mileage was 115,000.

- Oxford, NC, USA

The contact owns a 2017 Ford Fusion. The contact stated that while driving at various speeds, the engine misfired, causing the vehicle to jerk while depressing the accelerator pedal. The contact also stated that white colored smoke was coming from the exhaust pipe with the check engine light illuminated. The vehicle was initially taken to an independent mechanic who discovered that coolant had leaked into the engine block. The vehicle was then taken to a dealer who confirmed the failure. The manufacturer was notified of the failure, and the contact was informed that the warranty had expired. The vehicle was not repaired. The failure mileage was approximately 105,000.

- Redford Charter Township, MI, USA

The contact's partner owns a 2017 Ford Fusion. The contact stated while his partner was driving 40 MPH, the check engine warning light illuminated, and the temperature gauge started rising. The driver stated the vehicle started to vibrate and lost motive power while attempting to accelerate. The driver continued driving to the residence. The contact inspected the vehicle and noticed the engine short block needed to be replaced. The contact called the local dealer and made them aware of the failure. The vehicle was not diagnosed or repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 55,000.

- Norwalk, CA, USA

The contact owns a 2017 Ford Escape. The contact stated that while driving approximately 35-45 MPH, the check engine warning light illuminated. The vehicle was taken to the local dealer where it was diagnosed that there was internal engine failure. Additionally, antifreeze was leaking into the spark plugs and the engine was overheating. The vehicle was repaired. The manufacturer was contacted, and the contact was referred to the NHTSA Hotline. The failure mileage was approximately 101,000. The VIN was not available.

- Springboro, OH, USA

The contact owns a 2017 Ford Fusion. The contact stated that while operating the vehicle, the check engine warning light remained illuminated, with a message that the #2 cylinder was misfiring. Additionally, there was white smoke coming from the exhaust. The contact stated that the vehicle was shaking and vibrating, and the coolant level was low. The vehicle was taken to the local dealer who diagnosed that there was water and coolant in cylinder #2, causing severe damage to the engine. The contact was informed that the engine needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was 86,000.

- Bakersfield, CA, USA

The contact's daughter owns a 2017 Ford Fusion. The contact stated that after starting the vehicle, the check engine warning light was illuminated. Additionally, the contact stated that the vehicle was experiencing excessive coolant consumption. The contact used a personal OBD reader to retrieve a DTC code for cylinder #2 misfire. The vehicle was taken to an independent mechanic, where it was diagnosed that the failure was related to Ford Technical Service Bulletin Number: 22-2229. The mechanic referred the contact to the dealer for additional diagnostic tests and repairs. The vehicle was taken to the local dealer, where it was diagnosed that the Engine Long Block and its subcomponents needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 88,000.

- Reedsburg, WI, USA

The contact owns a 2017 Ford Fusion. The contact stated while having a routine oil change performed on the vehicle, the mechanic noticed that coolant was leaking into the engine, and that cylinders #2 and #3 were miss firing. The spark plugs were replaced; however, the failure reoccurred. On another occasion, while attempting to start the vehicle, the vehicle would not start, with the check engine warning light illuminated. An independent mechanic diagnosed the vehicle and stated that the timing belt was worn and that the timing belt needed to be replaced. The vehicle was not repaired. The dealer was contacted but offered no assistance. The manufacturer was contacted, and the manufacturer stated that the vehicle was out of warranty. The failure mileage was 139,000.

- Lynwood, IL, USA

The contact owns a 2017 Ford Fusion. The contact stated that the coolant level was low, and the engine was overheating. The contact stated that the check engine warning light was intermittently illuminated. The contact took the vehicle to a certified mechanic who diagnosed that the engine was misfiring. The contact was referred to the dealer. The vehicle was taken to the dealer who diagnosed that the coolant was leaking into the cylinders and that the engine needed to be replaced. The vehicle had not been repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline. The approximate failure mileage was 149,000.

- Greenwood, IN, USA

The contact-??s son owns a 2017 Ford Fusion. The contact stated that while his son was driving at an undisclosed speed, the vehicle hesitated and the engine misfired. The check engine warning light illuminated. The vehicle was taken to the dealer where it was diagnosed that coolant had leaked into cylinder #3, and the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and the contact was transferred to the NHTSA Hotline. The failure mileage was approximately 58,000.

- South Bend, IN, USA

The contact owns a 2017 Ford Fusion. The contact stated while driving approximately 40 MPH, the check engine warning light illuminated. The contact stated that the vehicle started losing motive power. There was white smoke coming from the exhaust pipe. The contact drove the vehicle to a dealer who diagnosed that coolant had leaked into the long block and determined that the engine needed to be replaced. The vehicle had not been repaired. The manufacturer had been informed of the failure. The contact researched online and related the engine failure to NHTSA Campaign Number: 17V209000 (Engine and Engine Cooling). The failure mileage was approximately 40,000.

- Lincoln Park, MI, USA

The contact's son owns a 2017 Ford Fusion. The contact stated that the vehicle would fail to start up after multiple attempts. Additionally, the vehicle stalled while driving at various speeds without warning. The contact also stated that white and blueish colored smoke was coming from tailpipe. The vehicle was towed to a dealer and a diagnostic test discovered that coolant had leaked into the engine cylinder. The manufacturer was notified of the failure. The vehicle was not repaired and remained in the possession of the dealer. The failure mileage was approximately 66,000.

- Clinton, MD, USA

The contact owns a 2017 Ford Fusion The contact stated a more than normal amount of coolant constantly had to be added to the vehicle. After a while, the vehicle began to run rough. The contact stated that while driving at various speeds, the vehicle stalled. The contact would turn off and restart the vehicle and the vehicle would operate as needed. The contact stated that the check engine warning light was illuminated. The contact spoke with a certified mechanic who stated that the failure was related to NHTSA ID Number: 10169807 (Engine and Engine Cooling). The manufacturer was made aware of the failure and opened a case. The contact was informed that the vehicle was not included in the Technical Service Bulletin. The approximate failure mileage was 107,212.

- Granby, MA, USA

The contact owns a 2017 Ford Fusion. The contact stated while driving 15-20 MPH, the vehicle jerked and stalled inadvertently. There was no warning light illuminated. The contact was unable to veer to the side of the road. The contact was able to restart the vehicle however, the failure reoccurred while driving the same day. The contact stated that the failure had been reoccurring increasingly and the vehicle would only start after several attempts. The vehicle was taken to the dealer where it was diagnosed that there was coolant intrusion into the engine cylinders and the failure was associated with Ford Customer Satisfaction Program Number: 21N12. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline. The failure mileage was approximately 129,000.

- Machesny Park, IL, USA

The contact owns a 2017 Ford Fusion. The contact stated that while accelerating at 65 MPH, the vehicle began to shake and hesitated with the check engine warning light illuminated. The contact stated that the vehicle would not accelerate above 60 MPH; the contact was able to drive the vehicle to the residence. The vehicle was then towed from the home to the dealer where a diagnostic test discovered that coolant had leaked into the cylinders. The manufacturer had been notified of the failure but offered no assistance. The vehicle was not repaired. The failure mileage was approximately 75,000.

- El Paso, TX, USA

The contact owns a 2017 Ford Fusion. The contact stated while driving approximately 70 MPH, coolant entered the engine and the engine overheated. The check engine warning light was illuminated. The vehicle lost motive power and stalled in a construction area. The contact refilled the coolant reservoir and drove to his residence. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The approximate failure mileage was 181,000.

- Lexington, KY, USA

The contact owns a 2017 Ford Fusion. The contact stated while driving approximately 35 MPH, the high engine coolant temperature warning light was illuminated. The contact drove the vehicle to an independent mechanic and was informed that the head gasket needed to be replaced. The vehicle was not repaired. The vehicle was then taken to the dealer to be diagnosed. The contact was informed of coolant intrusion into the cylinders. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer had been informed of the failure. The failure mileage was 108,849.

- Raleigh, NC, USA