10.0
really awful- Crashes / Fires:
- 0 / 0
- Injuries / Deaths:
- 1 / 0
- Average Mileage:
- 27,508 miles
About These NHTSA Complaints:
The NHTSA is the US gov't agency tasked with vehicle safety. Complaints can be spread across multiple & redundant categories, & are not organized by problem. See the Back button — blue bar at the very top of the page — to explore more.
« Read the previous 20 complaints
I was driving down the road, and a wrench symbol came on. Once i cut the car off and drive it the next day the symbol was off. I looked the symbol up online and it stated that it had to due with the powertrain. I made an appointment to the ford dealership here for diagnostic. They just called me and informed me that the vehicle has codes for misfire on start up and a coolant pump issue and that it is leaking into the engine walls. I am very displeased about this issue because I've only had the car for 2 years.
- Madison, TN, USA
Engine keeps having misfire issues. Taken to gary crossley Ford in April of 2021 and warrantied engine replacement. In March 2022 taken to throuroughbred Ford engine went bad again with antifreeze leaking into the oil, engine replaced again. Here we are in December 2023 and having same issues. And thoroughbred Ford is backed up until March of 2024 and cant fix the engine again until then. So I am paying my car payment and have no car to drive. I bought this car brand new with zero miles and have had nothing but issues with the engine.
- Kansas City, MO, USA
My car Transmission started to make a Rattling Noise while leaving a store. While on the highway, far left lane going 65mph, all of a sudden the car slowed rapidly with traffic all around me traveling 65+mph. I had to get over 3 lanes to exit the highway going 25. I was almost hit several times by vehicles going 65+. This could have caused a deadly accident. Luckily I made it to the exit without a collision. The South Belleville Ford dealership inspected the car and said the flexplate was cracked. I found out from Ford that they put out a Customer Satisfaction Program repair for the same flexplate my car is equipped with, covering the cost of repair and a rental vehicle at 100% but my vehicle, even though it was manufactured during the time specified and at the assembly plant specified with the specified transmission and flexplate, it did not qualify for the program because it has a different engine than what they had on file. They offered to cover 40% of repair since my car did have the defective flexplate. This is an extreme safety hazard as it could cause a deadly accident. It's a transmission problem, the engine is irrelevant and shouldn't matter. Ford needs to recall all vehicles equipped with the defective flexplate and not wait until it cracks because when it cracks someone could die. This is not a wait-and-see issue. This is a replace the defective part immediately before someone dies. This also puts other drivers on the road at risk of sudden death if the car in front of them has the defective flexplate and it suddenly cracks while traveling at high speeds and suddenly rapidly decelerates like mine did. The program even states that is what can happen if it cracks, so they know of this extreme safety problem. Ford plants will change what they are making for a couple of months and that is how I ended up with a different engine and my VIN not being reported by the plant as having been manufactured there at that time with that same defective flexplate.
- Belleville, IL, USA
The contact owns a 2019 Ford Fusion. The contact stated that while her son was driving at 50 MPH, the check engine warning light illuminated. The vehicle was taken to an independent mechanic where it was diagnosed that the spark plugs needed to be replaced. The vehicle was repaired but the check engine warning light remained illuminated. Additionally, the contact stated that when the accelerator pedal was depressed the vehicle began jerking. The vehicle was taken to the same independent mechanic where it was diagnosed that coolant leaked into the cylinder and the engine needed to be replaced. The vehicle was not repaired. The vehicle was then taken to a dealer where it was determined that the engine needed to be replaced. The vehicle was not repaired. The failure mileage was approximately 81,000.
- Burlingame, CA, USA
I put car into park to use the atm and then could not get it back into gear it gave a lot of different issues system fault error oil pressure errors battery error collision error and I ended up replacing the gear shift bushing which had deteriorated and broke off and that fixed most of issues now car makes loud blaring alarm sound that is not the normal car dinging it's loud and high pitched and acts like my battery is dead but won't start or shows any signs it is being jumped. Like the battery is completely dead won't take or hold charge.
- Houston, TX, USA
My car in February of 202: got stuck in park they said it was electrical issue, then months later I ended up with a coolant leak that then combusted my engine. New engine in August of 2023 fast forward to November 2023 my car is doing the same thing it stalled in the road with myself and newborn in the car, lost all speed and now it will not go in drive or reverse just like it did in February of 2023. It-??s been in the shop twice and now ongoing it-??s third time and I find this to be a severe issue because if my car is going to keep stalling while driving there is no reason to keep fixing this car. I-??m aware past fusion-??s have been recalled for something of similar problems so it makes me wonder if this should be recalled as well.
- Des Moines , IA, USA
The contact owns a 2019 Ford Fusion. The contact stated while driving approximately 45 MPH, the check engine warning light illuminated. The vehicle was taken to a dealer and was diagnosed with coolant intrusion into the engine. The contact was informed that the engine needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure. The failure mileage was 85,003.
- O'fallon, IL, USA
The contact owns a 2019 Ford Fusion. The contact stated that while driving at 65 MPH, the vehicle lost motive power while driving uphill. The contact stated that the front of the vehicle had started shaking uncontrollably. No warning light was illuminated. The vehicle had not been diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 45,411. The VIN was not available.
- Chinle, AZ, USA
Coolant intrusion into cylinder bore. Which can cause a fire. I been submitting complaints and haven-??t heard anything back in regards to my complaint. This was a known issue with ford back then.
- Maurice, LA, USA
Coolant leaked in cylinder wall
- Maurice, LA, USA
Coolant leaking into cylinder 3. Took to dealership, apparently there-??s a flaw in the engine design. Included all ford fusions apparently. How is this not a recall? When it-??s clearly Fords fault for this, not the consumers.
- New Hope, KY, USA
Coolant leaked into short block
- Maurice, LA, USA
I only have 109,000 miles and I am needing a new engine. They are telling me that the cylinder wall is cracked and something about a blockage. I cannot afford to replace it. They are telling me it-??s a known issue with ford but there-??s no recall and that-??s why they discontinued the ford fusion.
- Maurice, LA, USA
My car started running weird, it would shake when at idle. It did this for about a week before the check engine light came on. I took my car to a mechanic and they determined the head gasket was bad. I took my car to a ford dealership for confirmation of the problem. They confirmed I had a bad head gasket. My safety is put at risk because this can cause engine failure. If my engine failed in the middle of the highway that would be extremely dangerous.
- Bancroft, WI, USA
The contact owns a 2019 Ford Fusion. The contact stated while driving approximately 30-35 MPH, the check engine warning light illuminated. The contact stated that the failure recurred while driving. Additionally, the vehicle lunged forward but failed to respond upon depressing the accelerator pedal. The contact was able to pull to the side of the road. The vehicle was towed to the local Pep Boys, where the ignition coils #3 and #4 were replaced; however, the failure persisted. The vehicle was taken to an independent mechanic, where ignition coil #4 was replaced; however, the failure persisted. The independent mechanic replaced spark plugs #1, #2 and #3. The number four spark plug was stuck and was not removed. The vehicle was taken to the dealer, where it was diagnosed and determined that the cylinder head needed to be replaced. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 67,000
- Dana Point, CA, USA
Smoke coming from engine and exhaust pipe Overheating Coolant consumption issues Engine misfire and damage Total engine failure Safety was put at risk, the engine could have failed on a major highway. The problem is confirmed by Ford and did not cover the total cost of repair Car still runs terrible
- King Of Prussia, PA, USA
The contact owns a 2019 Ford Fusion. The contact stated that the vehicle was taken to the dealer for a recommended maintenance inspection; however, the contact stated that upon the technician inspecting the vehicle, the contact was informed that the engine short block needed to be replaced due to coolant intrusion into the engine. The vehicle was not repaired. The vehicle was not repaired. The manufacturer was notified of the failure and the contact was informed that the vehicle was out of warranty. The contact was informed to draft a letter for assistance. No further assistance was provided. The failure mileage was 119,000.
- Stone Mountain, GA, USA
The contact owns a 2019 Ford Fusion. The contact stated while starting the vehicle the check engine warning light illuminated. The vehicle was taken to an independent mechanic who stated that coolant was leaking into cylinder #2 and that the spark plug needed to be replaced along with the coil. The spark plugs and ignition coils were replaced but the failure reoccurred. The vehicle was taken to the independent mechanic and the codes were reset but the failure reoccurred. The vehicle was taken back to the independent mechanic who stated that coolant was leaking into the cylinder causing the spark plug to misfire. The dealer was contacted and stated that there was a Customer Satisfaction Program issued but the VIN was not included. The vehicle was not repaired. The manufacturer was contacted, and a case was filed. The contact was referred to the NHTSA Hotline. The failure mileage was 89,000.
- Henderson, TX, USA
The contact owns a 2019 Ford Fusion. The contact stated while his daughter was driving approximately 40-45 MPH, the check engine warning light illuminated, and the vehicle went into LIMP mode. The contact stated that the vehicle failed to exceed 5 MPH. The contact's daughter pulled into a parking lot. The contact stated that he used an OBD reader to determine that cylinder #2 was misfiring. The vehicle was taken to the Chevrolet dealer where it was purchased, and was diagnosed with coolant intrusion into the engine, causing cylinder #2 to misfire. The contact was informed that the engine needed to be replaced. The vehicle was taken to a Ford dealer, where the diagnostic result was confirmed. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that the vehicle was not covered under Ford Campaign Number: 21N12. The manufacturer referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 84,717.
- Independence, KY, USA
- Barksdale Afb, LA, USA