What component or system failed or malfunctioned, and is it available for inspection upon request" 2.4L Theta engine has developed a knocking sound at 155,600 miles. Oil consumption is excessive. Currently vehicle has Pennzoil Platinum High Mileage 5W20 oil. It has been approximately 5600 miles since last oil and filter change, and vehicle was 2 qts low. Knocking sound is consistent with what others have reported with the later 2.4L Theta II engine. Symptom is consistent with spun rod bearing. It is currently available for inspection, pending me selling the car. How was your safety or the safety of others put at risk? Car is a serious risk of stalling. Has previously stalled before. Has the problem been reproduced or confirmed by a dealer or independent service center? No. Selling dealership is under different ownership and has disavowed prior ownership. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? No. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear" None.

- Gastonia, NC, USA

My engine caught on fire...the fire was started near or around the fuel rail/ or injectors. I researched Kia recalls and other years and other models of Kia's were part of a similar risk. I feel that this was a huge safety risk....luckily my car engine caught fire very close to my home, and I was able to pull in my driveway and call the fire dept. I was injured in this event....but the burn was minor. I am most concerned with Kia acknowledging the huge safety risk....and the loss that I and others could experience with this safety issue. My vehicle was in great shape before this engine fire.

- Troy, MO, USA

The contact owns a 2007 Kia Rondo. The contact heard a loud grinding sound coming from the vehicle. The vehicle was taken to an independent mechanic where it was diagnosed that the exhaust needed to be replaced. The vehicle was not repaired. The grinding sound continued and the vehicle was taken to the dealer (South hills Kia, 3644 Washington rd, canonsburg, pa 15317) where it was diagnosed that the cradle and coil spring were rusted. The dealer did not inspect the vehicle to check for other failures. The manufacturer stated that the vehicle was over the 60,000 mile warranty; therefore, they would not assist. The manufacturer opened case number: 12707877. The contact mentioned that the vehicle had been at the dealer since April 26, 2018, but had not been repaired. The failure mileage was 76,000.

- Houston, PA, USA

2007 Kia Rondo. Consumer writes requesting reimbursement for vehicle repairs. Consumer sent additional correspondence. The consumer stated the vehicle experienced rusted breaklines and a leaky oil pan. The consumer requested a reimbursement. Updated 10/05/2017

- Lexington, MI, USA

The contact owns a 2007 Kia Rondo. While driving 50 mph, the vehicle stalled without warning. In addition, the vehicle accelerated on its own. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the issue. The failure mileage was 100,100.

- St Petersberg, FL, USA

The fuel pump assembly stop working, it would only work long enough to get it moving then stall. This is a hazard because it can stall in the middle of the road.

- Peoria, AZ, USA

Got notice from Kia about undercoating rusting brake line. How about the fact that I have a rusting oil pan which is leaking oil.

- Westland, MI, USA

The contact owns a 2007 Kia Rondo. The contact stated that while driving approximately 40 mph, the vehicle stalled. The vehicle was able to restart. The failure recurred on numerous occasions. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 100,000.

- Canton, TX, USA

The contact owns a 2007 Kia Rondo. While driving approximately 40 mph with the accelerator pedal depressed, the vehicle jerked abruptly and the vehicle continued to move forward at a slower speed. The contact stated that the failure recurred. The vehicle was taken to a dealer. The technician diagnosed that the wheel speed and oxygen sensors failed and needed to be replaced. The vehicle was repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 90,000.

- Oklahoma City, OK, USA

About 3 months after I purchased my Kia Rondo I noticed that every time I filled the tank there was a problem.for the last 5 years I have replaced a sensor every year to turn the check engine light of due to this problem. After putting gas in my tank all hell breaks loose. The tank begins to gargle the has the car revs high N then low until it shuts off and if I can get it on again it will rev high N low again while driving until it ahuta off in middle of road while driving. I've learned how to manage it but I don't think that when a car costs you 15 grand U should ha E to deal with what I believe to be a defect in the car.

- Holyoke, MA, USA

I was in a car accident and I rear ended an at&T utility truck.

- Anaheim, CA, USA

My 2007 Rondo has been acting up, will not start directly after getting gas. My check engine light is on. Yesterday I did not get gas, however it stalled while I was driving and would not start as it does when I get gas. I fortunately was at an intersection. If it had stalled a little farther up the road I would have been rear ended as there was a car directly behind me. I have previously replaced the purge valve solenoid as suggested, no difference. Why is the 2.7 Rondo not recalled for this as the 2.4 engine was?

- Finleyville, PA, USA

While driving down the road at the indicated speed limit of 35 miles per hour, there was a loud thump and then my car stopped. Immediately, I was terrified. I didn't know what was going on. Someone pulled over to help me and I eased my car over to the side of the road with persons manually pushing the car because it would not start back up. I called for assistance and was towed home. Upon getting the car home, I was told that the engine is dead. I was shocked. I was told that I would end up having to replace the entire engine and that could be very expensive. My problem is that I was getting regular scheduled maintenance on the vehicle to include oil changes. I have no idea how a engine just blows like that without no warning light (electrical problem) coming on or anything. I just could not believe this. I started to do some research. I found several reports that the engine died in Kia Rondo models. I contacted Kia to ask them if they had looked into this since so many reports have been made. They informed me that they do not have to do anything because the NHTSA has not told them they had to. I then asked what about safety. I also said that this can cause fatalities because had I been on the highway and my car just stopped like that, I don't know what could have happened. This issue is occurring too often in this model of vehicle. And to be honest I think Kia is aware of this because they actually stopped making this model. Something needs to be done. What am I to do about my transportation now that this engine is dead"?" Kia needs to answer for this.

- Petersburg, VA, USA

The contact owns a 2007 Kia Rondo. The contact stated that the oil pan corroded and fractured causing oil to leak. The vehicle was taken to an independent mechanic where it was diagnosed that the metal oil pan needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was 110,000. Updated 03/04/15 updated 10/8/2015

- Sterling Heights , MI, USA

The contact owns a 2007 Kia Rondo. The contact stated that the low beam headlights failed intermittently. The contact also stated that the passenger side tail light failed. In addition, the contact stated that there was an abnormal noise coming from the engine. The failures occurred on numerous occasions. The contact stated that the vehicle was repaired under NHTSA campaign number: 13V114000 (exterior lighting, service brakes, hydraulic) but the failure persisted. The manufacturer was notified of the failures. The approximate failure mileage was 70,000.

- Tacoma, WA, USA

The contact owns a 2007 Kia Rondo. While driving approximately 10 mph, the vehicle stalled without warning. The contact had to make numerous attempts to restart the vehicle. The failure occurred on several occasions. The dealer stated that the A/C belt needed to be replaced. The vehicle was not repaired and the manufacturer was notified. The approximate failure mileage was 47,029.

- Charleston, SC, USA

Two times my engine died while driving in icy whether. This occurred when the wheels were spinning, it sounded as if some system was trying to stop the spin. The first time I was driving approx. 25 miles per hour on level ground. The second time, approx. Two to four weeks later also in icy conditions on level ground, incident occurred when driving in reverse. That time I intentionally applied the gas hard to test try to get the tires to spin, and the car died within one second of leaving park. I anticipate this will happen again and hope this does not happen during rush hour when I feel there is a high probability I will get in an accident if I am unable to pull off the road.

- Chesterfield, MO, USA

The contact owns a 2007 Kia Rondo. The contact stated that while driving 40 mph, the vehicle started to make a loud banging noise. The vehicle was taken to an independent mechanic, who diagnosed that the engine failed and needed to be replaced. The manufacturer was made aware of the failure. The vehicle was not repaired. The VIN was not available. The failure and current mileage was 110,000.

- Perkiomenville, PA, USA

The contact owns a 2007 Kia Rondo. The contact stated that while driving approximately 20 mph, the temperature gauge reading increased into the red zone with a constant noise of flowing coolant. The engine was turned off. The contact inspected under the hood and noticed that the engine had overheated. After waiting two hours for the engine to cool, the vehicle was driven cautiously and taken to an authorized dealer for diagnosis where the radiator fan motor was replaced. The failure later recurred. The contact planned to take the vehicle back to the dealer. In addition, the stabilizer bar was faulty. The manufacturer was notified of the failure. The approximate failure mileage was 99,000.

- Reynoldsburg, OH, USA

I was driving on the highway when exiting the vehicle shut off. I took it to the mechanic and explained what happen. They said they checked it and nothing was wrong it was just the air compression "which they fixed" but as soon as I went to the mall the stick shift jammed and I couldn't turn off the car. An officer helped me and said take it back to the mechanic. When I brought it back he said it moves fine there's nothing wrong. My car has been parked ever since this incident. Im afraid it will shut off and we might crash. Please help me thank you.

- San Lorenzo, PR, USA