The contact owned a 2012 Kia Sorento. The contact stated that while his wife was driving at 65 MPH, an abnormal fuel odor began to emit from the vehicle without warning. His wife was then waved down by a fellow motorist that alerted her that the vehicle had caught fire. The contact stated that his wife had difficulty stopping the vehicle as depressed the brake pedal. Once the vehicle was stopped, an unknown color smoke filled the vehicle's front cabin as she and the other occupants exited the vehicle. No occupants were injured and no medical assistance was rendered at the scene. The vehicle was extinguished by the fire department and a fire report was filed. In the fire report, the investigator linked the cause of the failure to NHTSA Campaign Number: 18V907000(Fuel System, Gasoline; Engine); however, his vehicle was not included in the recall. The vehicle was towed to an independent tow yard where it was deemed a total loss. The manufacturer was notified of the failure and an investigator was sent to diagnose the cause of the failure; the contact had yet to hear back from the manufacturer. The dealer was also notified about the failure. The failure mileage was approximately 143,000.

- Rancho Cordova, CA, USA

Was driving down the highway and went accelerate and seem my RPMS reach the top, then noticed vehicle was -??off-??. Seemed to have no brakes or steering. It was dark and wintertime and my car died in the middle of the highway. Feel lucky to be alive with all the vehicles that nearly missed me.

- Mattoon, IL, USA

was driving and no warning lights came on and then the engine seized up after buying it 3 months ago. then took towed to kia vw billings mt and they now have had the car for almost two weeks and none of my rights are being met and no communication back to me wont respond to several of my calls. i will be filing a lawsuit against either auto resource in billings mt for selling me a faulty vehicle or going after kia vw of billings mt for lost wages as i drive for a living and im disabled and have been treated very very poorly.

- Billings, MT, USA

Engine started making noise. Took to Kia dealer who suddenly stated engine had to be fully replaced. Problem was confirmed by 2 Kia dealers. There were no warning signs, messages, lamps or indicators to the catastrophic nature of the engine failure needing to be fully replaced.

- Frisco, TX, USA

The contact owns a 2012 Kia Sorento. The contact stated while driving approximately 25 MPH, the vehicle lost motive power and stalled. The contact pulled over safely and restarted the vehicle. As the contact was restarting the vehicle there was a clicking noise. There was no warning light illuminated. The vehicle was towed to the local mechanic but no cause of failure was determined. The vehicle was towed back to the same mechanic who diagnosed the vehicle with a seized engine. The contact stated that the battery, check engine, and brake warning lights were illuminated. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 110,000.

- Baltimore, MD, USA

Driving and all power stopped and vehicle had to cruise on a busy route. Car going downhill was able to turn into a restaurant parking lot a few hundred yards away. Lucky to escape cars going past on on the other side in which I had no choice but to turn into. My mechanic looked over vehicle and determine engine seized. Vehicle being towed to dealership where it was purchased for their evaluation this Friday. No warning lights. Dealership is stating that there are no recalls, but we will be covered if the connecting rod is at fault. One of the recalls 17V224000 or Kia's SC147 states that this engine, which was manufactured between Aug 2010 and May 2014 (Feb 2012), may have bearing wear resulting in engine seizing. I will have to await the dealerships diagnosis to answer some of the above fully.

- Bradford, MA, USA

I take very good care of my Kia, but over the last year I have been losing oil. The dealer said that it's consumption and command problem. We have not been able to get a hold of Kia. Please help.

- Randallstown, MD, USA

We had some kind of fuel leak that caused smoke to come from the hood and the car to overheat. The check engine light did come on. We were on our way to the mechanic and the car died on us in the middle of the road. The car was taken to two different mechanics 3 different times. We had the thermostat housing replaced, the intake manifold, and the head gasket. Submitted documents to Kia showing our problem. They said they needed more proof showing there was some type of leak. I found the original papers today from the first mechanic that states "fluid leaking, smoke from under the hood, car shut down". I asked if I could submit those documents since they say exactly what Kia was looking for. I was told that those documents wouldn't make a difference in the outcome and they would not be reimbursing me anything on this matter. I have paid almost $3000 to have my car fixed and Kia will not reimburse for anything even tho I have the proof they told me that they needed. Kia has not been helpful at all through this matter. They have no intention of reimbursing me even tho my recall letter states they will if I have proof showing there was a leak and smoke coming from the engine. I received the recall letter 4-6 months after I had made the repairs.

- Lexington, NC, USA

We were traveling down the highway and without warning engine cut off. We were able to put in neutral and start back up and continue our drive. I took it to my personal mechanic and he replaced the charcoal cartridge (it was clogged), the cost was $750. 2 weeks later i was driving and while sitting at a red light, the engine cut off again. I put car in N and it started right back up. My mechanic then took the car to KIA to be evaluated and they found nothing. I drove car and 2 weeks later it did it again! slowing down for a red light ahead and engine cuts off. There is NEVER any warning to this, and it doesnt prmpt the check engine light to come on, so it is not showing any codes from the ECM. This is becoming a safety risk and needs to be solved. As this has occured 3 times in the last month.

- Snellville, GA, USA

The contact owns a 2012 Kia Sorento. The contact stated while driving approximately 45 MPH, the contact noticed that the check engine oil light illuminated. The contact heard some knocking sounds coming from the engine. The contact drove to her residence and refilled the engine oil reservoir with approximately three quarts of oil. The contact stated that all of the oil had leaked out and puddled on the driveway the following day. The contact had the vehicle towed to an independent mechanic. The failure was diagnosed and it was determined that the oil pressure switch needed to be replaced. The vehicle was repaired. The contact reported that the vehicle was still leaking oil. The manufacturer had been informed of the failure. The failure mileage was approximately 210,000.

- Sellersville, PA, USA

When I acquired the 2012 KIA Sorento, in 2018, I noticed that it was burning oil; it also has a mild-to-moderate clicking sound. I received a notification from KIA, instructing me to take the unit to the nearest Dealer for repair. Said Dealer flatly refused to repair it, claiming that it had been imported from the Continental US to PR, a US Territory. I appealed their decision to no avail. My wife is the main driver of the Sorento, and I am extremely concerned for her safety. Can a Dealer "refuse" to obey/fulfill an Official Recall from the Manufacturer? Finally, just to give you an idea of the oil-consumption problem, I have to add a quart of synthetic oil every 200 to 300 miles. Now consider the price of oil nowadays. I would truly & humbly plead for your help on this matter. Thank you.

- Guaynabo, PR, USA

The contact owns a 2012 Kia Sorento. The contact stated that while driving approximately 35 MPH, the check engine warning light illuminated. The contact stated that the engine started knocking and then the vehicle stalled. The contact was able to restart the vehicle to get the vehicle home. The contact had not taken the vehicle to the dealer. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 149,000.

- Charleston, WV, USA

The contact owns a 2012 Kia Sorento. The contact stated while driving 10 MPH in a traffic circle the engine seized with several unknown warning lights illuminated. The vehicle was turned off and restarted however, the vehicle was shaking while driving back to the residence. The contact stated that the failure persisted. The contact stated that the RPM-??s would rev without the accelerator pedal being depressed. The vehicle was not taken to be diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was approximately 97,000.

- Princeville, HI, USA

There was the smell of gasoline inside the cabin. Then the check engine light came on. Smoke began coming from the engine compartment. The fire completely engulfed the vehicle.

- Atlanta, GA, USA

The contact owns a 2012 Kia Sorento. The contact received a recall notification for NHTSA Campaign Number: 20V750000 (Engine). The vehicle was taken to the local dealer for the recall repair in January 2020. The dealer inspected the vehicle and diagnosed that no issues were found. The contact stated that while driving approximately 35-40 MPH, the vehicle decelerated to 20 MPH inadvertently. The contact depressed the accelerator pedal however, the vehicle would not exceed 40 MPH. The check engine warning light was illuminated. The contact was able to continue to drive the vehicle. The vehicle was taken to a second dealer (Ed Voyles Kia of Smyrna - Atlanta 2145 Cobb Pkwy SE, Smyrna, GA 30080) where it was diagnosed that the knock sensors malfunctioned and caused the vehicle to go on limp mode; however, the vehicle was not repaired. The contact stated that the failure reoccurred while driving. The vehicle was taken back to the first dealer who updated the Knock Sensor Detection System (KSDS) software; however, the failure persisted. The vehicle was taken back to the dealer, where it was diagnosed that the engine needed to be replaced. The dealer sent a diagnostic report to the manufacturer; however, the manufacturer declined to cover the engine replacement under NHTSA Campaign Number: 20V750000 (Engine) because the vehicle was out of warranty. A case was opened. The vehicle was not repaired. The failure mileage was approximately 112,705.

- Jacksonville, FL, USA

We were on our way home from the grocery when the oil light started coming on and off. We noticed a line of oil down the driveway, the car made a low kind of buzzing sound. Husband climbed under and looked. Massive oil leak, appeared to be coming from bottom of engine block around oil pressure sensor switch. Vehicle is a 2012 Sorento 3.5 liter with 90,000 miles. Kia said it is not on the recall list but this is the same problem with the vehicles that are on the recall list. Dealer wants nearly $1000 to fix the issue. My vehicle is parked and undriveable. We had no issues before this.

- Dayton, OH, USA

The engine shuts of going down the road. Can not be driven. Talked to mechanic, and they said to send in information as that is a common recap issue for Kia.

- Bowdon, GA, USA

The car was running hot and I took it in and the mechanic said liquid was coming out of the head gasket. Kia gave me a quote to replace the engine. We were fearful the car would just shut off while driving with our infant son and hot engine air blowing through the vents. The vehicle was inspected by Greenway Kia in Franklin, Tennessee. The check engine light came on and I took it to the Kia Dealer.

- Brentwood, TN, USA

As I was driving on the freeway, the vehicle started decelerating on its own. At that time All warning lights on the dashboard flashed including the engine light. As the vehicle decelerated, I put my foot on the brakes to slow down but the clutch jammed up as well as the steering wheel. At that point, I placed my foot on the emergency brake and maneuvered the wheel as best as I could to get into the emergency lane. There was absolutely no warning of the vehicle stalling or any known issues before this happened. Fortunately I avoided an accident that could have been fatal or injuries that could have occurred. The suv had no warning of any sort before this happened. The vehicle was towed to a Kia dealership. I spoke with a service rep there who previously worked on my recall and he stated it could have possibly been a rod-bearing failure. I feel that Kia should provide a loaner so that I could get to and from work.

- Hueytown, AL, USA

oIL IS BURNING. rEPORTED ISSUE A YEAR AGO AND WAS TOLD NO ISSUE WAS FOUND, NOW i'M HAVING TO PUT 1 QUART OF OIL IN PER 4-5 DAYS

- Carrollton, TX, USA