The contact owns a 2012 Kia Sorento. The contact stated while driving 40 mph and passing another vehicle and abnormal noise. The contact stated no warning light was illuminated. The contact was able to side of the road. The vehicle was not drivable. The contact towed the vehicle to independent mechanic and was informed the piston was needing to be replaced. The vehicle was not repaired. The contact towed the vehicle to another independent and was also informed the piston was needing to be replaced. The vehicle was not repaired. The vehicle was not diagnosed or repaired. A dealer was not contacted. Upon investigation, the contact associated the failure with NHTSA Campaign Number: 17V224000 (ENGINE AND ENGINE COOLING), however the VIN was not included. The manufacturer had not been informed of the failure. The failure mileage was approximately 165,000.

- Jamestown, TN, USA

The engine blew a piston or maybe a rod out of the bottom of the motor causing two big hole above oil pan bottom of motor will get pictures later

- Danville, AR, USA

The contact owns a 2012 Kia Sorento. The contact stated while stationary, the vehicle stalled inadvertently and was unable to be restarted. The contact stated that the check engine and oil warning lights were illuminated. The vehicle was towed to a local mechanic where it was not diagnosed. The vehicle was next towed to a local dealer and was diagnosed with needing the engine replaced. The manufacturer was not informed of the failure. The failure mileage was approximately 79,000.

- Erving, MA, USA

The contact owns a 2012 Kia Sorento. The contact stated that while driving 70 MPH, there was a knocking sound coming from the vehicle when the brake pedal was depressed. The vehicle was towed to the dealer and diagnosed with complete engine failure from the engine block. The vehicle was not repaired and remained at the dealer. The manufacturer was made aware of the failure and informed the contact that the VIN was not included in a recall. The failure mileage was approximately 170,000.

- Athens, AL, USA

This vehicle has an oil consumption problem. It has shown on separate oil consumption tests from the dealer, that the vehicle is consuming oil at an abnormal rate. The vehicle does not have any visible oil leaks. I feel unsafe driving this car because in the past, I've experienced shakiness on the freeway and loss of acceleration, which forced me to quickly exit the freeway.

- Canyon Country, CA, USA

While driving the vehicle it felt smooth and after a while a clicking sound started very faintly. I stopped at a red light and when I tried to accelerate at the green light the engine stalled and wouldn't power the vehicle. Everything worked well except the engine, it was locked. My safety and my passengers safety were put at risk because I was driving the vehicle on the street and it could've gave out while driving causing a major accident by an intersection. The issue has been address by an independent mechanic who stated a full engine is needed. The vehicle is currently on its way to a Kia dealership. There were no other lights or signed of engine failure.

- Moreno Valley, CA, USA

We bought this 2012 Kia Sorento on November 2018, never miss a oil change. But The engine light was flashing and lost power immediately when I was driving on 09/10/21, my husband and me bought it to auto shop they told us the oil was leaking caused the engine problem, and we-??ve to replace the engine. They also mentioned kia is recalling 2012 Kia Sorento because engine problem. We called Kia customer service but they said we haven-??t upgraded a software which we just received a software update notification on 09/06/21, so they couldn-??t fix this problem for free. Shall NHTSA help me figure out is it my problem or their? Thank you very much!

- Grand Forks , ND, USA

I doing oil change every 3 month. The engine light was on and lost power immediately when I was driving on the road. Brought to auto shop, they told me the engine oil was leaking pretty bad, and it will cost me $7k to put a new engine in. I-??m at a tough situation.

- Grand Forks , ND, USA

The contact owns a 2012 Kia Sorento. The contact stated that on the startup of the vehicle, the engine would begin to knock and blue smoke would emit from the muffler. The contact stated no warning lights were illuminated. The vehicle was diagnosed by the dealer with needing gaskets replaced but the vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 94,000.

- Clearfield, KY, USA

The contact owns a 2012 Kia Sorento. The contact received a recall notification for NHTSA Campaign Number: 20V750000 (Engine). The vehicle was taken to the dealer who diagnosed that no issues were found. The contact stated while driving 60 mph and changing lanes, the vehicle inadvertently stalled and lost power. There were no warning lights illuminated. The contact veered to the side of the road and was unable to restart the vehicle. The vehicle was towed to an independent mechanic who could not determine the cause of the failure. The vehicle was then towed to Sansone Kia (90-100 US-1 North, Avenel, NJ 07001) who diagnosed that the engine needed to be replaced and the failure was related to the recall. The dealer informed the contact that the part for the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the failure and a case was opened. The vehicle was repaired but consumer could still smell the gas leak. The approximate failure mileage was 77,250.

- Newark, DE, USA

The vehicle has been diagnosed with oil leaking out through the exhaust. On July 31st, 2021 I was on the highway and my car started making a loud clicking sound. It lost power and the engine light came on blinking. The safety of others and myself/passenger was in danger as it lost power on the highway and the speed limit was 75.

- Colorado Springs , CO, USA

Hi, I get my car fixed at the dealer Inver Grove Kia in West Saint Paul in Minnesota. There is s problem with my suspension. With that being said, the first problem was my sway bar and that was not fixed correctly. I am now hearing the same noise on the passenger side of SUV and they are telling me it is strut. I need to have all information and recalls sent to me. Then dealer is not looking into other problems that the 2012 Kia Sorento has right now. The dealer has put me in a bad situation and also in danger with not inquiring more about the suspension problems associated with my 2012 Kia Sorento. https://www.lutherkiamn.com/?utm_source=gmb&utm_medium=organic

- Woodbury, MN, USA

Car will shut off randomly while driving. Usually slowing down or speeding up in the 0 to 30 mph zone. Does not show any codes for KIA or my mechanic to read. Car will not restart for about 20 seconds. Car will slow down and loose all RPM's of it doesn't shut all the way off and will only run 20mph until I can get off the road and restart it.

- Georgetown, SC, USA

Engine suddenly lost power while on 125 mile road trip. Tachometer flat lined at 60 mph and speed and engine power rapidly decreased ( as if in creeper mode) and I was not able to accelerate above the 20 mph, enough to get to the shoulder. I was towed to the Kia dealership and after a day the couldn't replicate the problem as the vehicle returned to it's proper operational mode. This happened again 3 weeks later at 80mph in the center lane under cruise control with the same issues, sudden loss of power, inability to accelerate and no tachometer reading yet still running at idle. This time I pulled into a gas station and took the battery cable off for 5 minutes then replaced it. The vehicle became fully operational and I drove another 125 miles home. I bare was able to get over as I couldn't accelerate the vehicle and had to creep up the exit ramp. This being extra hazardous as it was nightfall and both times I had my 2 year old grandson with me. If I was in the left lane I would not have been able to make it across the highway and possibly would have caused a major back up putting myself, grandson and the other drivers on the road at risk of a collision...There are many blogs in line with Kia owners reporting this same problem and with no resolution if the dealerships can't replicate the problem while they have the vehicle.

- Detroit, MI, USA

Miles on vehicle is at 130,000 miles and never missed an oil change however noticed at 125,000 miles that it has really started to burn oil. Took to the Kia dealership and they told me that I could be eligible for a free engine replacement and I needed to pay for a engine oil consumption test. Paid the amount and engine failed and I figured I'd go the the next necessary step for the replacement however they then told me it didn't cover oil consumption...Took vehicle to different shop and will cost me $4,400.

- Denmark, IA, USA

Hello, My engine began to make a knocking noise and high rev when started approx. 2 weeks from today. I took it to a local mechanic, Archers automotive, Whittier, Ca., and he advised that I needed a new engine. The mechanic advised me of numerous recalls on the 2012 Kia Sorento engine and recommended I take it to the dealer. I made an appointment with Kia Cerritos and about a week later I took it to Kia in Cerritos, Ca. on 06/02/21. On 6/4/21 I was advised by Service advisor "Ryan" i needed a new engine, I advised Ryan that I am the original owner who purchased this vehicle new and I advised him there are numerous recalls and safety issues with the 2012 Sorento but I was advised my engine for some reason is not recalled. I advised him It is obvious Kia has an engine issue with their 2012 Sorento based on the recalls and the numerous complaints on the web.There were no warning lights of an engine issue. The moment I noticed an issue with how the engine was sounding I took it to a mechanic and then to Kia Cerritos. It had been inspected by Kia Cerritos by a mechanic and on a diagnostic machine. When I initially asked for the reason why the engine needed replacing, On 6/4/21, I was advised the mechanic did not list any reasons. When I asked for the service codes I was advised the mechanic misplaced the diagnostic print out and he had to put it on the machine again, which leads me to believe they initially did not test it on the machine. I was told by Ryan at 10am I would get a call back that day, no call. On 6/5/21 Ryan at Kia Cerritos advised me the engine needs replacing and the cost would be $10,000, but they could not say why because the bearing test used on 4cyl recall engines would not work for 6cyl engines but he advised the "sound" it makes is similiar to the recall engines. My vehicle is available, anytime, within a reasonable distance from zip code 90604, ?for inspection from NHTSA and anyone from Kia.I look forward to hearing from you. I have included all ppw

- Whittier, CA, USA

Since purchase of the Vehicle there has been non stop issues with the engine and cooling system. I had the engine replaced after purchase which took 2 months and now the Vechicle started to smoke again and a smell of burning rubber. I took it to the dealership to have repaired and the entire cooling system was replaced, only weeks after the same issue occurred again to find out it was now the water pump that was not replaced. Researching to resolve the car has serveral recalls for the same exact issues that have been occurring. My concern is the safety of me and my children and the unknown of being repeatedly charged for a vehicle that was sold knowing that it was not in good standing with the State for Odometer Variance.

- Visalia, CA, USA

2012 Kia Sorento, approx. 135,000 miles, driven by my daughter who is away at college. Vehicle is rapidly losing oil, but it is not leaking/dripping or smoking. At a recent regularly scheduled oil change (which was done sooner than recommended) the mechanic advised that no oil drained out. Over the next several days and 550 miles later, my daughter needed to add two quarts of oil just to get the dipstick level to "low". I have read numerous complaints from Sorento owners with the same issue, who have been told they need a new engine. Our vehicle is no longer under warranty, but that may be a moot point as I have also read that Kia is somehow not repairing the ones that are still under the original manufacturer warranty. I am concerned about the safety of my daughter driving a car that may experience sudden engine failure. For now, she is adding oil every week until we can get the car diagnosed.

- Pembroke Pines, FL, USA

Driving on the highway the suv completely shutted off, we almost died with my 1 year old daughter. I was able to start it again, within 2-3 minutes the engine seemed very weak, stalled again. Never had any issues prior. The only sign was the oil light was on, (it was never on before) we checked the oil, it was fine, 3/4 full. The engine is dead, with only 40k miles. I'm lucky to be alive.

- Duryea, PA, USA

The contact owns a 2012 Kia Sorento. The contact stated while driving at an undisclosed speed, the vehicle stalled with the check engine and oil warning lights illuminated. The vehicle was diagnosed by an independent mechanic and the contact was informed that the rod bearing was worn needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was 174,000.

- Coral, MI, USA