It is known that the 2016 Ram crew cab 4x4 has exhaust leak problems. The bolts on the exhaust manifold will break and exhaust will escape the manifold causing extra heat to flow into the engine bay, and fumes to enter the cabin of the vehicle. carbon monoxide is colorless and orderless and causes headaches, nausea, dizziness, and even death if inhaled. The exhaust manifold leaks must be fixed.

- Longview, WA, USA

We were driving our 2016 Ram in July 20, 2023 to Yakima, WA which is 200 miles away from our home. About 50 miles north of town, our check engine light came on and our power was reduced to a minimal speed. We cautiously drove to the next rest area and turned the engine off. We waited about 30 minutes, restarted the engine and continued to Yakima. We had the code checked and turned off at an Oreily's parts store. We drove it to an Independant diesel service center since the Ram dealership's schedule was 2 months out to look at it. After several hours and troubleshooting, the diesel technician determined that the Cumins Actuator and Turbo were failing. Each time they cleared the code and drove the truck, they could recreate the problem. They told us that it was the same problem that the 2015 Cumins Turbos & actuators were having. They said there is a chance that our truck was manufactured with the same parts as a 2015 Cumins. They were able to repair our truck and said that we should notify the NHTSA, Mopar and our local Ram dealer of the problem. Mopar told me there is no recall for this issue, so they cannot help. The local Ram dealer told me that since they did not do the repair, they cannot report the issue. Please help us as this was an expensive repair, not including the cost of being standed out of town for days. Our Ram only has 39,000 miles and is like new, always garaged and drove for pleasure. How can we get this investigated or reimbursed?

- Spokane Valley, WA, USA

6.7L Cummins diesel Known Grid heater bolt broke and could leave people stranded as it causes catastrophic engine failure and or damage leading up to $20 to $30K in engine repairs. Ram knows about this issue and is doing nothing about it. Mine broke and I caught it just before it destroyed my engine. the fix was a $1k kit. This bolt corrodes and and drops down into the intake in which destroys the #6 cylinder, piston, wall and valves. Ram is doing nothing to fix the problem and leaving people stranded who haul trailers and with the big repair bills.

- Orangevale, CA, USA

The grid heater bolt that is on the bottom side of the grid heater. It fails and the bolt falls off and get sucked into the engine destroying the piston and cylinder causing an over 10,000$ expense.

- Wales, MI, USA

This message is in regards to Static NHTSA Bulletin 09-005-22 / D- 22- 06 Dated March 16, 2022. The above listed warranty extension extends Ram 2500 Cummins Turbo Diesel Model year 2015 to 150,000 miles or 15 years if code U010C is indicated on MIL. My truck meets all above criteria but is a model year 2016. However, there is no changes in mechanicals between the 2015 and 2016 model year. My truck, at 114,000 miles just indicated this issue and the estimated cost of repairs is over 2,000 dollars. Considering that this has already been a widespread notable issue with this truck and engine, my hopes is to include 2016 model years in this extension. Thank you.

- Queen Creek , AZ, USA

I was driving my truck on the freeway pulling a loaded stock trailer. The truck suddenly down shifted into fourth gear and the engine RPM-??s maxed out! I almost crashed the truck because the momentum of the trailer pushed the truck sideways on the freeway. I had to avoid traffic and get to the shoulder. Truck would not shift out of fourth gear and truck shifted into 4WD low also on its own. Had truck towed to dealers ship and was told a shift solenoid went out. Because of that they now have to change the torque converter and replace the transmission from the damaged it caused. It is unknown if it damaged any of the engine components at this time or any other parts of the drivetrain. Now I-??m stuck paying for a transmission because Dodge didn-??t put a safety backup into their system to prevent this in case of a failure. I see that I am not the first person it-??s happened to by reading the power train comments for this year truck.

- Sacramento, CA, USA

Engine running rough. I drive daily on the freeway and pull a trailer, it is not safe to drive on a busy freeway or any road ( I am a self-employed contractor who now has to rent a truck). Both I took to an independent service center and authorized Crysler Dealer. Check engine light came on November 30th. P219A - Bank 1 Air-Fuel Ratio Imbalance PERMANENT. It was starting on and off. The truck was purchased from Holz Dealership in 2019 and financed for $35,967.63. Nothing was disclosed about engine issues.

- New Berlin, WI, USA

Engine Fan / Radiator Shroud. During hot weather and engine temperature, the engine fan engaged. Due to the high ambient, I believe the radiator shroud was hot and the material was soft, it became deformed under the vacuum created by the fan cause it to interfere with the engine fans path of rotation. The interference caused the fan and shroud to shred each other sending shrapnel in all directions, including into the back side of the radiator, engine compartment. Plastic debris was found on top of the valve cover, battery, radiator, exhaust manifold. This problem has been reported by numerus online forms. This failure was inspected by the dealer and I was informed it was not under warranty, but drivable and safe. Their recommendation however was to replace the fan, shroud and radiator. However, they have seen cases with far worse damage causing catastrophic failure of the radiator leaving the vehicle stranded

- Lebanon, OR, USA

The contact owns a 2016 Dodge Ram 2500. The contact stated while driving 40 MPH, the vehicle started making abnormal sounds. There were no warning lights illuminated. The contact stated he veered to the side of the road for a short while and then drove to an independent mechanic who diagnosed that the heater thread bolt had failed and damaged the engine. The dealer was made aware of the failure and informed the contact he would be responsible for the cost of the repair. The manufacturer was made aware of the failure but did not provide any assistance. The vehicle was not repaired. The approximate failure mileage was 160,000.

- Eureka, CA, USA

The contact owns a 2016 Ram 2500. The contact stated while driving 35 mph, the brake pedal was depressed but failed to respond. The contact depressed the parking brake pedal and the vehicle stopped. The warning messages "Brake Fluid Low" and "Service Electronic Braking System" appeared on the instrument panel. The check engine warning light, the traction control warning light, and the brake warning light were illuminated. The contact turned off and restarted the vehicle and the brake pedal responded while depressed. The vehicle was drivable. The vehicle was not diagnosed or repaired. The dealer and the manufacturer were not made aware of the failure. The approximate failure mileage was 106,500.

- Clarksville, TN, USA

I purchased my vehicle yesterday. Today I was driving it is stalled as I was pulling out into traffic I restarted it it drove fine another two miles. At which time is stalled again with no lights, no indications on. Sounds like some noise comes from the air box. Some kind of air noise comes from the passenger side of the engine when it happened

- Key West, FL, USA

The contact owns a 2016 Ram 2500. The contact received notification of NHTSA campaign number: 19V818000 (equipment, engine and engine cooling) and 20V036000 (power train) however, the parts to do the recall repairs were not available. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The contact called bergey's Chrysler Jeep Dodge Ram located at (408 harleysville pike, souderton, pa 18964 (215) 721-3470) but was not diagnosed or repaired. The contact did not experience a failure. The manufacturer was contacted however no further assistance was provided. VIN tool confirms parts not available.

- Skipjack, PA, USA

The contact owns a 2016 Ram 2500. While driving, the vehicle shut off and lost braking and steering ability. There were no warning indicators illuminated. The contact had to shift into park and turn the ignition to restart the vehicle while it was still rolling. The contact drove to national Dodge Chrysler Jeep Ram (2223 N marine blvd, jacksonville, nc 28546, (910) 347-3777) where a code appeared that was unrelated to the failure. The contact stated that the vehicle previously experienced electrical failures from past repairs. The dealer could not determine the cause of the failure. The manufacturer stated that nothing could be done until the vehicle was at the dealer's shop. The vehicle was taken back to the same dealer, but no failure was found. The failure mileage was 24,000.

- Jacksonville, NC, USA

"etc" warning light, electronic throttle control, keeps coming on and taking it back to the dealer Monday for the 3rd time. The throttle gets stuck and won't idle---the pedal works fine, it's an electronic problem. My wife almost ran threw the garage door. This happens while driving and idling anywhere.

- Rancho Cucamonga, CA, USA

Intermittent diesel exhaust enters vehicle when using heater. This occurs when driving, engine temperature normal, diesel exhaust will enter through heater vents. It stops if the heater is turned off and does not occur when heater is turned in a few minutes nor may it reoccur for an extended length of time. It is bad enough to cause a headache. I have to open the windows to clear the fumes. As it is intermittent I have not been able to reproduce for the Ram dealer.

- Flagstaff, AZ, USA

The contact owns a 2016 Ram 2500. While driving 55 mph, the regeneration process warning indicator illuminated. Upon inspecting the vehicle, the contact noticed extreme heat coming from the exhaust pipe. The vehicle was taken to mcsweeney Chrysler Dodge Jeep Ram (2605 dr john haynes dr, pell city, al 35125, (205) 814-7300) where the contact was informed that they were aware of the failure. At night, blue flames came out of the exhaust pipe when the regeneration process began. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was 35,775. Consumer stated it is not a failure but a design oversight. Updated 11/27/18

- Munford, AL, USA

The contact owns a 2016 Ram 2500. The contact stated that NHTSA campaign number: 17V5612000 (engine and engine cooling) exceeded a reasonable amount of time for repair. The contact received the recall notification in September of 2017. The dealer (ralph sellers Chrysler Dodge Jeep Ram, 14215 airline hwy, gonzales, la 70737) stated that the parts were unavailable for the repair. The manufacturer was not contacted. The contact had not experienced a failure. Parts distribution disconnect. * the consumer stated all repairs completed on 09/19/18.

- Gonzales, LA, USA

The contact owns a 2016 Ram 2500. The contact received notifications for NHTSA campaign numbers: 17V821000 (power train) and 17V562000 (engine and engine cooling). The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repairs. Cedar city Chrysler Dodge Jeep Ram (1010 N main St, cedar city, ut 84721, (435) 586-8290) was contacted and confirmed that the parts were not available for the recall remedy. The manufacturer was notified and was not able to confirm when the parts were to become available. The contact had not experienced a failure. Parts distribution disconnect.

- Newcastle, UT, USA

The contact owns a 2016 Ram 2500. The contact received notification of NHTSA campaign number: 17V562000 (engine and engine cooling); however, the part needed for the repair was not available. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The vehicle was taken to sunset Dodge Chrysler Jeep Ram Fiat (located at 7745 S tamiami trail, sarasota, fl 34231, (941) 922-2400), but the parts were not available for the repair. The manufacturer informed the contact that the part was not available and did not assist. The contact had not experienced a failure. Parts distribution disconnect.

- Bradenton, FL, USA

The contact owns a 2016 Ram 2500. The contact received notification of NHTSA campaign number: 17V562000 (engine and engine cooling); however, the parts to do the repair were unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. Red bluff Dodge Chrysler Jeep Ram (545 adobe rd, red bluff, ca) was contacted and confirmed that the parts were not available for the recall remedy and they only received recall parts once a month. The manufacturer was made aware of the issue and was not able to confirm when the parts were to become available. The contact had not experienced a failure. Parts distribution disconnect.

- Red Bluff, CA, USA