Abs pump failure intermittent loss of braking system and traction

- Medina, OH, USA

Problem #1- I had to replace the ABS module and HCU on this truck at about 10k miles. (this was completed under warranty). Then at 50k miles truck was diagnosed with the same problem. I had to pay out of pocket for this repair. I ordered these parts from the dealer in November 2021, and they did not get me in until August 19, 2023. I had to pay ($1152.33). This is very dangerous when it has this error it causes the service sabitrac and service abs pop up on the display nonstop with no way to clear it. It also chimes every time. it is very distracting. while these service lights are on, I had no cruise control or traction control. Problem # 2 Transmission over drive failed. I had to replace transmission and transfer case. This makes for an unsafe vehicle that could leave me stranded on the side of the road. this repair cost me ($7,500). Failed at 67,675 miles. Problem # 3 turbo actuator failed and had to replace at 68,565 miles this cost me ($1750). this is an extended warranty on the 2015 model year pickups. Should be all across the board for all trucks using the same design/parts. In total on just repairs under 70k miles I have been forced to spend ($10,402.33). This truck is not road safe at all and I should be reimbursed for all my money I had to spend. At the bare minimum i should be compensated for all my down time plus repairs.

- Ludlow, IL, USA

The anti-lock and traction control light and service light came on shortly after purchase, this happened while towing a 10,000lb camper in the N. GA mountains. this was a challenging situation with that much weight pushing the truck and the brakes weren't working properly. After getting a code reader, I found out the HCU has been listed as a service problem. You try to find the part and there is a hold on releasing the part because the manufacture is having problems with the updated part, and they don't even offer the original part because of the defect on the original part, (part # 68143491AA) The replacement part is (68143491AB). Thankfully I grew up driving vehicles without modern ABS, If my wife would have been driving, or an inexperienced driver, this could have ended in a very, very bad situation. Why isn't there a safety recall on this vehicle? Why should the consumer have to pay for a KNOWN SAFETY ISSUE. just look at the posts on the internet. Even worse, you can't get the part to fix, every dealer that has the part listed says the part will not be released until February, and not until April for the public. ( but the website says they are in stock) You call to verify that the part is on hand and they said not until spring.

- Dacula, GA, USA

This is an ongoing problem and it appears to be affecting other owners of this vehicle as well. The code is C0020-001. The ABS/Traction control light comes on - a message to service the Anti-Lock braking system comes on - and the cruise control does not work. This happens intermittently sometimes 20 times in a minute, sometimes it's 20 times a day and sometimes I can go 2 or 3 days without it coming on at all. It's very frustrating and unnerving as the cruise control just drops out while you're driving which is not safe. The ABS also does not function with this issue. This issue needs to be addressed. Additionally there is a parts shortage for this repair most obviously because the parts are in short supply with everyone needing to make this repair. There are countless other people who are having this issue besides myself. Please issue a recall. This is not safe.

- Canonsburg, PA, USA

The ABS and traction control light are coming on and off and malfunctioning with a dinging bell alert. With a message that says service antilock brakes soon. On wet roads the steering seems off and brakes lock up. Very unsafe, The Ram dealer said the parts to fix are under engineering review and not available until February 2024. My truck is a 2017 Ram 2500 with19,850 miles. I bought the truck new

- The Dalles, OR, USA

ABS and Traction Control warnings cycling on and off randomly. Warnings are off only for short periods and are on most of the time. Cruise control is not working when the warnings are on which causes a sudden unexpected drop in speed on the highway when a warning cycle occurs. Two dealers have advised that the unit is faulty in manufacture and design but no replacement parts are currently available. Unfortunately I am unable to replace the vehicle and must continue to drive it without these important safety features.

- Fuquay-Varina, NC, USA

Electronic braking system and ABS lights intermittently come on and off an throws a code c0020-01 which many dealers say should replace the HCU and ABS modules and research has shown that this if a short-term fix on a fault component. Please hold ram to task.

- Middletown, RI, USA

I have 2017 Dodge ram 2500.12/09/19 the anti lock brake system control and hcu module was replaced under warranty. Now august 2023 with 27,900 miles the same problem has occurred with the dealer recommending the ABS control module and HCU be replaced. the parts will not be avaiable until January 2024. If a Abs module failure is not serious what is. A check of the internet shows a tremendous amount of complaints of this issue. there is even a class action lawsuit in California. I have spoken with Ram Care and they dropped my case as soon as they found out the part was backordered until January. I have all the dealer documentaion if needed. Please look into this problem before crashes start occuring.

- Rice, VA, USA

My 2017 Ram 2500 Cummins pick-up truck started displaying symptoms of a bad HCU module several months ago, "Service Electronic Braking System" warning message, ABS dash light indicating loss of ABS, and Traction Control Light indicating loss of traction control, as well as kicking the vehicle out of Cruise Control when this set of condition lights are, albeit intermittently illuminated. There are times where these condition light persist for long periods of time from several hours to several days, and then times when these condition lights aren't present and will only intermittently come on and then times when these lights blink/ding on and off constantly for several minutes until it comes to rest in an always on state or an intermittent state. After having the issue confirmed by a third-party reputable mechanic shop AND a RAM Dealership Service department I was told the module is on backorder. Being that it is a safety system I don't trust the "aftermarket parts industry" to provide me with authentic manufacturer trusted equipment. Which leaves me encumbered with the stress and risk of having to operate my vehicle with unreliable ABS, Traction Control, Cruise Control. This is beyond a unique to me issue as there are plenty of well documented cases of RAM 2500-3500 series vehicle with this issue as well as a recall on the 2019 & up series of the same. So why would they not issue the recall for the other trucks with this safety issue? Condition persists at any speed regardless of road and weather conditions, no matter the duration of vehicle operation per trip.

- Tyrone, GA, USA

While driving down the road my vehicles ABS and Traction control light go on and off, most of the time the lights are stuck on. Causing the vehicle to not have ABS and traction control during the rain and snow months of the year an further more the cruise control does not work. At this point the truck is unsafe to drive in all conditions as it does not retain its safety braking systems, I will not put my family in the vehicle. Moving forward ask my local Ram dealer about the repairs and they say they can not get the parts they have been on back order.

- Broad Brook, CT, USA

First got an Service Antilock Brake System and Stability Control light. A couple days later, lost speedometer and park sense lights came on along with "Service Trailer Brakes", but I haven't had a trailer hooked up to this truck ever.

- Dallas, GA, USA

ABS, Traction control light came on. Shut down 4wd, parking assist, cruise control. Trucks not braking evenly. Feels like differential is locked

- Dayton, TX, USA

Vehicle set code C0020-01 ABS Control Module/ Hydraulic Control Unit failure. ABS system, Traction Control and cruise control does not work. Parts unavailable to fix issue leaving me with the choice or parking the vehicle or driving and u safe vehicle. This should have been a recall and Ram is doing nothing about it.

- Huntington, WV, USA

2017 RAM 2500 has known issue with Antilock Brake Unit Hydraulic Controller - This prevents brakes from operating correctly and traction control / speed control is disabled - Confirmed diagnosis with dealer - Vehicle has current Mopar Vehicle Protection (service plan) but part is unavailable to be ordered - RAM dealer stated vehicle does not pass state safety inspection. RAM Care case submitted. No accidents and 40k miles. This component failure can result in unsafe conditions while driving due to loss of control while stopping or in slippery conditions. Constant alert and lack of speed control can lead to driver fatigue.

- Bellville, TX, USA

My trucks ABS keeps cutting off, it-??s operation is intermittent. This also disables the cruise control and traction control. I have researched this on this year and it-??s a problem with many of doges trucks. The dealer has no fix for this safety issue.This is an on going issue that happens every time i drive the vehicle.

- Matthews, NC, USA

Cruise control quit working when towing my trailer with tractor loaded. Service antilock brake system and service electronic brake system messages and lights on dash showed. Would occur intermittently, then became more steady. Took to dealer today, 6/19/2023, and was told no part could be ordered to fix this. Dealer advised they do not have an answer/fix. May have by August 16. Seems a long time to wait for a brake system solution/fix.

- Versailles , KY, USA

Abs pump and control module built with defective part-??s causing pump and module failure which in turn caused break failure

- Dunn, NC, USA

I have dash lights going on and off for the ABS and traction control. This is very intermitted. On two occasions I have experienced times where I had to slam on the brakes to avoid an accident. Both times the ABS failed to work causing me to come to near collision with another vehicle. One of the times this caused me to go off into a ditch. This was with slick roads and snow covered in areas. Have also had several times the truck would steer out of control with no traction aid. I am constantly losing speed control using cruise control. It will work for a bit and then turn off when the ABS and traction control lights come on.

- Illiopolis, IL, USA

My dash will randomly start flashing the messages "service electronic braking system" and "service antilock brake system". Sometimes this happens as soon as I start the vehicle, other times it happens while driving down the road. Sometimes it seems as if a bump in the road will trigger the messages, others are random. When the messages are there, the traction control feature does not work. I do not know if the abs system will work or not as I have been lucky enough to not have to test that. Also, while the messages are present, the cruise control function will not work.

- Tyrone, GA, USA

The ABS control module and the HCU has Failed twice on this truck resulting in loss of traction control, ABS and cruise control. The unit was replaced around 42,000 miles and then failed again at roughly 60,000 miles. Ram will not replace under warranty. the failure causes the abs and traction control light on the dash to come on and off constantly. it also shuts down cruise control. I believe it also causes excessive ware on the rear tires due to the traction control system not working properly. This is a major problem and judging by online repair forums there are many other people experiencing the same issues

- Casselberry, FL, USA