This is regarding potential safety issue related to the brake system. Last week (10/1/23) I changed the rear brake pads for the first time since I got the car from the dealer. The pads are original ones installed at the Toyota plant/line. Shocked was that there was no sign of grease on right/passenger side caliper guide pins, and pins were rusted and seized on the caliper as a result. This explains why the pad thickness is still 4-5 mm. Braking was done mostly by the front bakes. If the front brakes failed, it's like driving the car without brakes. I and my family narrowly escaped collision because it needs extra distance to make complete stop compared to other normal cars. I checked the front brake pads also just for safety reasons. The pins glide freely in the caliper, but not like normal guide pin behavior. This is the manufacturer's fault and could put me and my family in danger of collision.

- Dublin, OH, USA

Road conditions were perfect - sunny, dry, nice weather. I was pulling into a parking spot and when I applied the brakes, they FROZE. I.e. the brake pedal DID NOT GO DOWN. (The mats were not an issue). Then the car suddenly accelerated and went over an embankment. I was able to stop the vehicle using the emergency brake.

- Burlington, MA, USA

Slow down to make a right turn, the car completely shut off. Put on emergency lights pulled into nearest safest parking lot, braking systems failed, finally put car in park. Pulled keys out of ignition. Took a look around nothing was physically wrong, got back into vehicle started it, with no problem. Took it through the same parking lot, through the drive-thru. Started smoking at the second window, pulled back into the parking lot, shut off vehicle. Got out of vehicle to access smoke, fire started, got back int car then an explosion. Grabbed my daughter and my things the best I could. There was about two or three more explosions afterwards, the fire department came to take out the flames; this was after other employees from the same area tried to put out the fire with fire extinguishers but it wasn-??t much help. It halfway burned into the ground, the Fireman had to use the jaws of life to get the hood off of the car to extinguish the fire.

- Las Vegas , NV, USA

Pulling into parking space the engine started to rev. Put car in reverse and car was put in hish speed reverse causing car to hit another vehicle.

- Skokie, IL, USA

2015 Rav4 with less than 8,000 miles. On I-5 freeway at about 70mph traffic slowed, I applied brakes and a rapid thumping sound came on followed by a shaking that seemed to be from front left of car. Was on a thousand mile family emergency trip. Whenever I applied brakes at freeway speed the same thing happened. My independent mechanic by phone said it might be warped disc.

- Cypress, CA, USA

Sua incident - coasting before entering garage as usual with my right foot on floor and not engaged with accelerator or brake. Upon entering the garage car began to accelerate, naturally shocking/baffling me, as I had already started braking and continued to do that to no avail as car proceeded to hit back wall of the garage where acceleration stopped, car came to rest. I never drive with two feet and am absolutely certain my foot was on the brake and brake was not responding. Also car did not accelerate with the same sound as it normally would if I pressed the gas peddle. It accelerated more like it was on cruise control...very smooth and steady. Actually I'm grateful the wall wasn't far away so it didn't accelerate further. The incident happened June 11,2020 at around 10 am. Do not know reason for sua, but will note that we had the garage door sensors repositioned on June 10. I'm noting that because where they are is about when I felt acceleration starting.

- Englewood, FL, USA

When first driving vehicle after sitting overnight, brakes squeak for the first ~5 minutes of use. When accelerating after starting car first thing after sitting overnight onto city street, car's transmission and RPM's skyrocket out of nowhere to 4,000 - 5,000when pulling onto street with 35 mph speed limit. When accelerating onto highway - usually in sport mode - car's RPM's go up like they should but transmission does not down shift properly and seems to get stuck at 3,000 - 4,000 rpms. Car only has 88,000 miles on it and transmission should not be slipping already.

- Charlotte, NC, USA

Brakes started squeaking. Service person inspected and said pads and rotors are fine; unable to determine cause. I researched internet and found there are many owners complaining about this problem. Nhsta needs to issue a recall before someone gets seriously injured from failing brakes.

- Folsom, CA, USA

The contact owns a 2015 Toyota Rav4. While driving various speeds, the brake pedal seized when it was depressed and the ABS warning indicator illuminated. The contact had to turn the vehicle off and on for it to resume normal operation. The vehicle was taken to kings Toyota (4700 fields ertel rd, cincinnati, oh 45249, (513) 683-5440) to be diagnosed, but no failure was found. The dealer updated the ECM, but the failure recurred. The manufacturer was made aware of the failure and informed the contact that he would need to take the vehicle back to the dealer for a second diagnostic test. The failure mileage was approximately 61,372.

- Waynesville, OH, USA

The contact owns a 2015 Toyota Rav4. When the brake pedal was depressed. The brake pedal traveled two inches above the floorboard. The vehicle was taken to jim coleman Toyota (10400 auto park ave, bethesda, md 20817), but was not diagnosed or repaired. The vehicle was taken back to the same dealer multiple times for the failure. The manufacturer was not notified of the failures. The approximate failure mileage was 45,000. The VIN was not provided.

- Bethesda, MD, USA

Brakes failed completely had to use emergency brakes to stop car on highway petal went all the way to floor tow car to dealership.checked ok to dealership" they said"

- Land O' Lakes, FL, USA

The contact owns a 2015 Toyota Rav4. While driving 20 mph, the key indicator illuminated, the steering wheel seized, the brake pedal was difficult to depress, and the engine stalled. The vehicle was taken to dch freehold Toyota (4268 U.S. 9 S, freehold, NJ 07728), but the cause of the failure was not determined. The vehicle was not repaired. The manufacturer was notified of the failures and opened a case. The failure mileage was approximately 73,000.

- Morganville, NJ, USA

While driving the car, the brakes started to grind around 27,500 miles. I took the vehicle to the dealer while it was still under warrant. The service agent told me that the 2015 Rav4 had a design issue where the brakes start to go bad around my current millage of about 27,900. He also said that this is a known issue and it is not covered under warranty, nor is there a recall. He told me that I need to replace the brakes at the next service. He also said that because of the design issue, he is offering a discount at $290. It seams to me that a design issue that causes your brakes to go bad around 28,000 miles should not only be covered under warranty, but also have a recall issued to resolve the problem.

- Rocklin, CA, USA

The contact owns a 2015 Toyota Rav4. While driving 30 mph, the brakes failed to work without warning. The vehicle was taken to a local dealer (Toyota of manhattan; 645 11th ave, New York, NY 10036; (866) 386-5003) where it was diagnosed that the brakes needed to be replaced. The vehicle was repaired. The failure recurred several other times after the repair. The vehicle was taken to the local dealer approximately three different times. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was 4,500...updated 07/24/17 updated 12/1/2017

- New York, NY, USA

The brake pedal was totally locked (can't press down at all) when I was driving on a city street at 9:45am on 5/6/2017. I can't slowdown my car. I switched the shift from driving to parking, turned off the car, then the car stopped.

- Los Angeles, CA, USA

As I was pulling into my parking lot, I pressed the brake to stop the vehicle. When I moved my gearshift into the park position, my car jumped the curb and drove into my exterior wall. After the collision, the car then started driving backwards at an accelerating speed. After jumping back into the parking lot, I crashed into a car parked behind me, which made the car finally stop. The airbags did not deploy during either collision. By the end, the vehicle had been totaled.

- Philadelphia, PA, USA

Vehicle did not respond to braking (possible stalling, loss of control of vehicle), resulting in a severe crash involving two parked cars and property, injury to driver, and total loss. The vehicle accelerated at a high rate of speed going down hill due to having no control over the vehicle. Because driver was unable to stop, the vehicle ran two stop signs. The crash resulted in the vehicle crashing into two parked cars, "jumping" those vehicles and running into a home. The vehicle was twice previously repaired under warranty for stalling. Occasion 1 (14K miles): Vehicle stalled at stoplight and key light was flashing. Error codes P1605 and P219A at the time. Occasion 2 (16K miles): Vehicle stalled twice while stopped, on the same day. The vehicle was shaky at the stoplight and multiple warning lights came on, code P1605 (2nd repair).

- Los Angeles, CA, USA

Power steering went out and brakes failed, during an evasive maneuver..on or 11. 2015 : which subsequently impacted a tree

- Houston, TX, USA

The contact owns a 2015 Toyota Rav4. While merging into the right lane, the vehicle independently veered left and accelerated when the brake pedal was depressed. The driver drove off the road and the vehicle rolled twice down a short incline. Both the driver and passenger air bags failed to deploy. A police report was filed. The driver and front passenger sustained bruises and scratches to their elbows. The rear passenger suffered a concussion, which required medical attention. The vehicle was destroyed and towed. The manufacturer was not notified of the failure. The failure mileage was 20,000.

- Mesa, AZ, USA

While pulling up to a gas pump the car suddenly accelerated. It went from zero to 40 miles per hour. I was in the passenger seat and my husband was driving. He pumped the brakes but car made a loud revving noise and would not stop. My husband was able to avoid hitting a truck, but the car went over a concrete mediano and only came to a stop when the emergency brake was pulled. The car was filled with airbag smoke even though the airbags did not deploy. A witness said that he could tell it was a mechanical issue because of the loud revving noise the car was making. Toyota has not been able to tell us what happened. They did not find a problem with brakes or accelerator. The car hit the median so hard that the frame has been bent. Even though we have been loyal Toyota customer for over 20 years, my hope is that they total the car so that I don't ever have to drive it again. Our Toyota case # IS1604122141. I know that other people have had similar experiences-there is no doubt in my mind that there is a serious problem with that car.

- Colorado Springs, CO, USA