Engine is overheating the car is missing real bad. Allpro mechanic evaluate the car and replace the spark plugs. Antifreeze continues to leak into the engine. Mechanic said the engine block needs to be replace.Capstone Law has a class action suit against Ford for this very issue.

- Milton , FL, USA

I'm filing a complaint regarding my 2016 Ford Edge Titanium with the 2.0L EcoBoost engine, which required two engine replacements due to a defect causing coolant intrusion into the cylinders.The engine failed due to coolant leaking into the cylinders, a problem diagnosed and confirmed by Ford technicians. Both engines are no longer in the vehicle, but documentation is available upon request. My safety and the safety of others were put at significant risk on two separate occasions. The first engine failed at 67,000 miles, leading to the engine blowing while I was driving on the highway. This nearly caused an accident as the vehicle suddenly lost power. The second engine, which was a replacement from a 2018 Ford Edge with the same 2.0L EcoBoost engine, also failed in a similar manner at 87,000 miles, again while I was driving on the highway. On this occasion, I was left stranded on the side of the highway in the desert for 7 hours in over 100-degree weather, further endangering my safety. The problem was diagnosed and confirmed by a Ford dealership on both occasions. The first failure was diagnosed as coolant leaking into cylinder 3, causing the vehicle to misfire and eventually leading to the engine blowing. The second engine was inspected by a Ford repair technician during a recall service, where the same coolant leak issue was diagnosed. Less than two months after this diagnosis, the second engine also blew while I was driving. Ford service technicians inspected and confirmed the problem both times. Repair and diagnostic reports are available. The first indication of the problem with the original engine was a check engine light so I took the vehicle to Ford. The dealership diagnosed the issue as coolant leaking into cylinder 3, causing misfires. Despite this diagnosis, the engine failed before I could arrange for the recommended long block replacement. The second engine began exhibiting the same symptoms-?"misfiring and coolant loss-?"shortly before it also failed.

- Seattle, WA, USA

coolant intrusion into the engine-??s cylinders, which caused my engine to fail and ford failed to disclose these defects when I bought it now my engine has failed and I can not afford to fix it or buy another if my extended warranty wont cover

- Bacliff, TX, USA

The coolant is leaking into the engine causing misfire, and overheating.

- Callahan, FL, USA

Code for Cylinder #2 Miss Fire. Upon inspection by pressurizing the coolant tank it was observed to have coolant leaking into cylinder #2

- East Lansing, MI, USA

Motor has known manufacturing defects. Was told by Ford dealership. Needs a motor at 118k miles

- Shelton, WA, USA

The contact owns a 2016 Ford Edge. The contact stated while his daughter was driving at an undisclosed speed, the check engine warning light illuminated. The contact diagnosed the vehicle and determined that the spark plugs had failed and needed to be replaced. The spark plugs were replaced but the failure reoccurred. The vehicle was then taken to a local dealer where it was diagnosed and determined that there was coolant intrusion in cylinders #1, #2, #3, and #4, and that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 70,000.

- North Branch, MI, USA

The contact owns a 2016 Ford Edge. The contact stated that while the vehicle was started on several occasions, there was a chugging sound coming from the vehicle and the vehicle was shaking for approximately 30 seconds. On three other occasions, while driving at various speeds, the " Engine Hot" message appeared and disappeared. Additionally, the check engine warning light illuminated sporadically. The vehicle was taken to an independent mechanic where it was diagnosed that cylinder #3 and the thermostat needed to be replaced. The vehicle was repaired but the failure persisted. The vehicle was then taken to another independent mechanic where the contact was informed that cylinder #3 needed to be replaced again. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 70,000.

- Lorain, OH, USA

Check engine came on for cylinder 1 misfire. Replaced all spark plugs and ignition coils. Check engine came on again for same problem. Was diagnosed with internal engine problem by independent mechanic. Took to Ford dealer which confirmed coolant intrusion in cylinder 1. They are saying it-??s a design defect and it needs a new engine block, but will not cover any of the cost.

- Arlington, TX, USA

The contact owns a 2016 Ford Edge. The contact stated while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to the dealer where it was diagnosed with a coolant leak and engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 69,000.

- Sioux Falls, SD, USA

Total engine failure due to coolant intrusion

- Gansevoort, NY, USA

No warning lights before or after the problem occurred. Driving about 25mph with traffic heard loud noise like something broke then sounded like plastic was dragging, the engine was a lot louder. I got it off traffic and pulled over. Nothing under the car. No warning or engine lights came on. Dealer told me it was a fly wheel on 6/26 and covered under warranty. Said it would take 2 weeks to repair (July 5). I kept calling for status on my car with no call back from the service manager. I finally had to complain (although I was afraid to since they had my car), and they called on 7/12 said it's not the fly wheel like they thought, they said I need a whole new transmission. They don't know what cause it but maybe something broke inside the transmission caused damage to it. $7600 cost to replace it. Not covered under warranty. We contacted another mechanic who says it's probably the torque something (arm?) that broke. I paid what to me is a lot of money for the car. It also needed a completely new engine at 44k miles which was covered under warranty. For the amount of money I paid for the car it's crazy I have to shell out $7600 more.

- Pleasant Hill, CA, USA

Ford recalled cars with same problem with the 2.0 engine but did not recall on edge which has the problem of coolent sepping into cylinders, engine light came

- Secane, PA, USA

I have a 2016 Ford EdgeTitanium with a 2.0 EcoBoost with 63,000 miles on it. In May of 2024 my check engine light came on. Verified coolant intrusion into cylinder 1 causing engine failure. Mileage on the car does not warrant an engine replacement. When Ford was contacted, both the original dealership and manufacturer, they took no fault in the matter. I was told there was a possibility of an engine fire if left as it was. I had to pay $9469.44 for a new engine! Many forums show this same issue happening with the same year/make/model. Ford should be held accountable for a known defect in the block that was not corrected through a recall.

- Reno, NV, USA

check engine light came on, when assessed I was told it was a cylinder 3 misfire. Car began overheating while driving down the highway. Took it to a shop who performed block test > found combustion gases in cooling system caused by blown head gasket > replaced head gasket, timing chains & sprockets. After head gasket was replaced there was white smoke & misfire at cold start up - (been this almost ever since we replaced the head gasket). Shop then tested cooling system for combustion gases > found head gasket leaking due to cracking block at gasket surface > replaced complete engine assembly.

- Berryville, AR, USA

At 83,000 miles the car exhibited a P0301 check engine light for a misfire. Several troubleshooting steps were taken including new spark plugs, swapped ignition coils and then troublehooting shifted to checking for the known coolant intrusion issue. TSB 22-2229 was followed and after pressurizing the coolant system to 21 psi and inserting an endoscope visual confirmation of coolant leaking into the cylinder from the head gasket was discovered. This is a known issue to Ford that they have not acknowledged other than a TSB which advises to replacing replace the long block. We are going this route to the quote of $8,818.15. Due to Ford's change in coolant passage design they have created an engine with known issues that they are failing to warranty.

- Seattle, WA, USA

Engine block is cracked in which it is leaking antifreeze into the cylinders had a technician to look at the engine

- Jenkins, KY, USA

Head gasket problem, so im told by mechanic that i need new gasket. The antifrezze is mixing with oil, 2016 ford edge is known to have these problems, 51000 miles on car. Called ford and they cannot do anything, out of warrenty. Case # [XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

- Mt Vernon, NY, USA

The contact owns a 2016 Ford Edge. The contact stated that after an oil change, the check engine warning light illuminated while driving 50 MPH. The vehicle was taken to an independent mechanic where a diagnostic test showed that the Evaporative Emissions System was defective and needed to be replaced. The dealer was notified of the failure and the contact was provided an estimate for a diagnostic test. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 142,000.

- Hudson, NH, USA

The contact owns a 2016 Ford Edge. The contact received notification of NHTSA Campaign Number: 22V413000 (Power Train). The contact stated that upon starting the vehicle, there was an abnormal amount of smoke coming from the tailpipe. The vehicle was taken to the dealer and diagnosed with a blown. The contact was informed that the engine needed to be replaced. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline. The vehicle was not repaired. The failure mileage was approximately 74,000. Parts distribution disconnect.

- Nashville, TN, USA