The contact owns a 2016 Ford Edge. The contact stated that upon starting the vehicle, the vehicle was shaking and was unable to accelerate properly. The contact stated that after waiting for the shaking to cease, the vehicle drove as needed. The contact stated that the check engine warning light was illuminated. The vehicle was taken to the dealer where the failure was determined to be a faulty head gasket that was leaking coolant. The dealer stated that the engine needed to be replaced. The manufacturer was notified of the failure and a case was opened. The manufacturer confirmed the report from the dealer. The vehicle was not repaired. The approximate failure mileage was 49,000.

- Wenatchee, WA, USA

Check engine light turned on after the whole car rumbled and seemed to struggle to start. Took car into dealership to get code checked out and it was a misfire. We made the next available appointment at the dealership which was over a month later, but were told to not bring in the car again unless another misfire happened before the appointment. More misfires started occuring and more frequently about 2 weeks later, since the dealership had no availability, I brought the car into my own mechanic who told us it was a coolant leak into cylinders 2 and 4 causing the misfires, it was most likely a head gasket issue. Finally brought it to the dealer appointment who went radio silent unless we called for almost a week. They intially stated that Ford would cover the costs since its a known issue with the engine in this model and year, but they didn't initially take a photo when they reproduced the coolant leak and had trouble reproducing it again. They eventually reproduced the coolant leak but back tracked that Ford would cover the costs of the known issue, since it was past the 5 year warranty. The codes were P0302, P0304, P0316, which were misfire in cylinder 2, misfire in cylinder 4 and random misfire. The cause is a known head gasket problem with the engine, and that Ford did not recommend a head gasket replacement but a brand new engine due to known issues with the 2.0L 4 cylinder engine. Our car has under 50,000 miles on it, however it is past the 5 year warranty period as stated earlier, so Ford won't help cover any repairs with their known defect in their engine. The contact stated that the actual vehicle mileage was approximately 49,375 when the incident occurred.

- Wenatchee , WA, USA

The contact owns a 2016 Ford Edge. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to an independent mechanic and the dealer on separate occasions to be diagnosed. The contact was informed that coolant was leaking in the engine block to cylinder #3 and that the engine needed to be replaced. The vehicle was not repaired and remained at the dealer. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 80,000.

- Omaha, NE, USA

Misfire in cynlinder 2 due to coolant leak and crack in engine. Resulting in new engine over 9000$ dollars and ford ignoring issue despite thousands of complaints and similar defects with this model.

- Lake City, MI, USA

Check engine light came on. Started to misfire when ignition was turned on. Some misfiring when driving. A couple days later, white smoke started coming out of the exhaust. Took car to mechanic who told me I had a crack in the engine block and coolant was leaking into the cylinder. The engine had to be replaced.

- Charlotte, NC, USA

I bought a new 2016 Ford Edge and have it serviced regularly at the dealer. My service record is exemplary and it is documented. My car has 94K miles. I have had work done by the dealer recently (new tires, new axle) and there was no advisement of an engine issue, absolutely nothing was said. About 7 days ago I got a warning light out of the blue, and took it in immediately. I was told it was a "catastrophic engine failure" due to coolant leaking into the engine because the coolant pump failed. I was told "it just happens." As I researched this on the web I discovered that there are thousands (possibly tens of thousands, the amount on the web is overwhelming) of people with the same catastrophe and outcomes that were all very similar: engine replacements cost 10K and can take months -- one fellow has been without his car for seven months. That is not an option for me. Frankly I am shocked at The Ford Motor Company and I mean that. What are they thinking"?"There is a Ford truck engine in that car and it should not be failing at 94K, especially after my record of service and especially after this problem has been known for years. I'm not kidding -- this car is 5 years old and looks 5 months old. I need resolution and I need it quickly and I am not encouraged by the reports I see. My issue is not with my dealer, it is with Ford dragging their heels on a solution. I am at my wit's end.

- Long Beach, CA, USA

On May 13, 2022, my Ford Edge was taken to the Local Ford Dealer for a spoiled coil. At 52,000 miles, the coolant had leaked into the cylinders and caused the engine block to crack. This resulted in me needing a whole new engine. Thankfully, I had taken out an extended warranty on my vehicle or it would have cost me over $7500. I was told by the dealership that this is a known problem with these Ecoboost engines. I have always taken excellent care of my ford edge and I cannot believe Ford has not been made to recall these engines. Most people don't have an extended warranty and they should not have to pay thousands of dollars for an obvious faulty engine.

- Sun Valley, CA, USA

There is a known problem with coolant leaking into the cylinder damaging the gasket. The only fix is to replace the entire engine block at a cost (in my case) of $8361. This seems unreasonable of a 6 year old car with 64,000 miles on it. This is a known problem to Ford as evidenced by the necessity of Techical Service Bulletin 19-2208 issued by Ford in June 2019. Fortunately, My engine light came on alerting me to the problem. That apparently doesn-??t always happen meaning the engine could have stopped working while I was driving. Ford dealers are still selling these vehicles used on their lots with no need to disclose this problem because no recall has been ordered. Hoping that this can be rectified to help out a significant number of drivers who-??ve had to fix their vehicles at a substantial cost and to force Ford to stop selling them used without repair

- Randolph , MA, USA

The flex plate is cracked on my Ford Edge. The crack could have caused it to break completely and I would have lost control of the vehicle. The problem has been confirmed by an independent service center. There was no warning lights or messages displayed; just a loud knocking noise coming from the engine.

- Corriganville, MD, USA

The contact owns a 2016 Ford Edge. The contact stated while attempting to start the vehicle, the vehicle failed to start properly for a few seconds. The contact stated that there was an abnormal fuel odor inside the cabin of the vehicle. The contact stated no warning light was illuminated. The contact stated she continued to experience the failure until August 10, 2022, when the check engine warning light illuminated. The contact took the vehicle to an independent mechanic who associated the failure with TSB: 14-0180 & 19-2346. The contact called the local dealer and left a voicemail. The vehicle was not diagnosed or repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 74,350.

- Reno, NV, USA

Engine blown due to coolant leaking inside the engine.

- Parma, OH, USA

At first inspection I was told it was a blown head gasket due to coolant leaking in motor. When taken apart the big block is cracked. Is going to be a entire motor replacement. Car only has 91,447 and has had regular services.

- Ferguson, NC, USA

Car has over 89000 miles and maintained regularly. I am the only owner and kept in garage. Check engine light came on which had a code of P0302, P0303, P0304. Mechanic confirmed coolant has leaked into cylinder and has caused crack with his borescope. Only fix is an entire engine replacement. I have no alternative but to get replacement car. This has cost me thousands in unplanned expenses to purchase a replacement before I am ready and the lost value on my vehicle due to this issue. This has apparently been known for years and no communications from Ford on this was ever received. I find this unacceptable for a company to allow this defect to go ignored.

- Covington, GA, USA

The contact owns a 2016 Ford Edge. The contact stated while driving approximately 30 MPH and slowing down, the engine then began to idle roughly while stopped at a traffic signal. The contact stated that the check engine warning light was illuminated. The contact had taken the vehicle to a local dealer who diagnosed that there was coolant in the cylinders. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 100,000.

- Potomac, MD, USA

Vehicle light came on and said cylinder 1 misfire. Had spark plugs changed. Had coil packs changed and neither fixed. When took to be checked out, head gasket blown.

- Ferguson, NC, USA

The contact owns a 2016 Ford Edge. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to the dealer where it was diagnosed with coolant intrusion into one of the cylinders. The dealer informed the contact that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and advised the contact to file a complaint with NHTSA. The failure mileage was 56,059.

- Okemos, MI, USA

I noticed my coolant level was roughly an inch below the minimum line on 6/25/22. I filled my coolant to the max line. My check engine light appeared 6/28/22 for cylinder 2 misfire. I replaced all 4 spark plugs and the coil for #2, and the error message was still reading after the parts were swapped, while the vehicle was off. A few days later I noticed my coolant was again an inch below the minimum line, so I refilled my coolant (refilled roughly 5 times until today, 7/21/22). It always dropped and held to an inch below the minimum line. My check engine light reappeared on 7/12/22 so I took vehicle for diagnostics 7/21/22 at Inver Grove Ford, MN 55087. Tech confirmed vehicle is still misfiring for cylinder #2 so they removed the coil and smelled coolant entering the combustion area, leading them to insert a camera and saw coolant in #2 and #3. They recommended a total new engine (assuming one with a long block to avoid this issue again in the future), for $9,150. My vehicle is 6 years old with less than 100k in miles. The dealership informed me this is an issue Ford is aware of, they have put out a Technical Service Bulletin (19-2139) but are unwilling to fix this issue for customers. The tech informed they have since redesigned the engine so this fault is less likely in newer models. I was unaware of this common issue until my check engine light came on and brought it to a dealership. This poses a great danger as with low levels of coolant -??localized overheating of the engine cylinder head may cause the cylinder head to crack, causing a pressurized oil leak that may result in a fire in the engine compartment.-?? (Recall 17S09). The current issues people are facing are incredibly similar to previous recalls. It is unsafe for consumers to unknowingly drive a vehicle in which the seller knows has a risk of fault, and has since corrected such fault in later models.

- Sauk Rapids, MN, USA

The contact owns a 2016 Ford Edge. The contact stated that the vehicle was unable to start-up as needed. The vehicle was towed to the dealer where it was diagnosed with coolant intrusion into the engine. The dealer informed the contact that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and informed the contact that the vehicle was out of warranty. The failure mileage was approximately 143,000.

- Pollocksville, NC, USA

#2 cylinder went bad, car doesn-??t want to start and when it does start it shakes until black smoke is finally gone from exhaust and it begins to idle correctly. Dealership says full engine replacement on a 2016 Edge with eco boost with only 134,000 miles on it!!

- Milford , PA, USA

The contact owns a 2016 Ford Edge. The contact stated that while the vehicle was at an independent mechanic for an oil change, the mechanic diagnosed that there was a coolant leak in cylinder #1, and the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 83,000.

- Kintnersville, PA, USA