Swing arm hinge spot weld has broken loose. Cannot roll the window down, hard to shut.

- Palomar Mt. , CA, USA

The driver and passenger only open all the way now. When the doors are opened it sounds like they are breaking or going to fall off. It is the mechanism that holds the door to the car when the doors are open.

- Atchison, KS, USA

Front driver door spot welds failed. Ability to open drivers door and window affected. Took to repair shop that told me the welds opening and closing the door all failed. No message or warning, or symptoms prior to failure.

- Mazomanie, WI, USA

Door makes a loud clanging noise when open and does not stay open

- Brandon, FL, USA

The drivers door has a loud popping cracking like the door is going to break. It won-??t shut properly. This is the 2020 escape.

- Chesapeake, VA, USA

The piece that keeps my driver side door from opening to the point of breaking has broken from the door, and in turn is preventing my driver side window from opening/closing. The cause of this problem is that the solder came loose from the inside of the door. If the wind catches my door, I risk the chance of it buckling at the hinge of the driver door. I have taken it to the dealership in my area and they have reported it to Ford, who states that they are aware of the problem and are trying to find a solution. I am being told that it is going to be a recall, but it is not ready yet? It has been this way for almost 2 months. I took it to the dealership the first time on 3/5/24. Still nothing. This is unacceptable. If anything they can put on a new door. Something needs to be done. They tried to get me to trade it in...I cannot afford that! The date below is approximate, it was around then that I noticed, but it started making a noise when I opened/closed the door for about a week before I called dealership about the problem.

- Granbury, TX, USA

Driver side door has loud popping noise and am unable to close door. Door popped open when driving

- Edmond, OK, USA

Drivers door popping won-??t close all the way window hitting something when you try to roll it down spot welds broken in door

- Warsaw, IL, USA

Left front door has a broken spot weld at the check arm attachment point in the door assembly, occurring on 04/23/24. The weld has completely separated from door component, causing the door to open too wide & barely close completely. This has also caused the sensors in the window to malfunction and the window will not open at all. Has been brought to a dealership and inspected to determine the broken weld is the cause of these problems, and that they have been widely reported by other drivers of this make and model Ford Escape. There were no prior warning lights before breakage, the left front door started making a snapping sound 1 day (04/22/24) before the door weld fully snapped and detached.

- Lancaster, SC, USA

Door making popping noise, window won't go down. sometimes won't open easily. control arm problem.

- Hogansville, GA, USA

Front passenger door is coming apart - literally the inside structure is separating from the frame of the car. The driver door is automatically locking even when key fob is in the car. When rolling up windows- the Automatic windows continue to roll up and down without touching the buttons. Engine is puttering upon start up- low idling. The engine cuts out when pressing gas upon driving.

- Arlington, TX, USA

Driver side door is literally falling off. The hinge is broken and the dealer says although it is a known issue Ford will not cover it. I cannot open the door or else will not be able to close it again. It took two men to close it once it broke and I've been using the passenger side door to enter and exit. I have 2 small children. All electronics inside of door are now non-functioning. Dealer wants $3,000 to repair. Not sure how a non-functioning door is not a safety issue. There are times when you may have to exit a vehicle in an emergency situation (like when it's on fire, in an accident, etc.) not to mention when you're driving down the highway and the door flies off.

- Houston, TX, USA

Driver side door makes loud noise when opening and closing. Warning messages: car not in drive or park when in the correct gear; door open; and battery saver on in morning. Driver side power window not working properly. Took to dealer for service on 4/15/25. Was informed there is a door issue not recall and no repairs at this time. Cost: $70 to check door. Have not received any notification from Ford about Customer Satisfaction Program 23B56.

- Trumbull, CT, USA

Door started making horrible sound and not opening/closing very good out of no where.

- Washington, OK, USA

The door hinge limiter bracket on the drivers front door has a broken weld and has becomes detached. This also interferes with the window being able to open and close.

- Philadelphia, PA, USA

There has been a cracking noise when opening my passenger front door. Heard a POP and notice three small holes on the side of door. I can barely open my door and can-??t let down the window. Called ford and of course the famous line, -??Since your car is not under warranty, we cannot fix the problem.-?? Shouldn-??t this problem be a recall? I-??ve been researching and noticed many Ford Escapes are dealing with the same issue. I feel like I-??m driving a Build-A-Car. Come on Ford you have to do better.

- Carrollton, TX, USA

Driver's door when opening would make a clunking sound. After opening it a couple times door would not shut. Finally getting it to shut, the door now will not open all the way. Also since this happening the window on that door will not roll down. Safety issue is that I'm afraid the door won't stay closed or it may fall off. Also the gas cap light is on, always been a problem even when the cap door is completely closed.

- Brighton, MI, USA

The driver-??s side front door mades a creaking/popping sound when opening, hard to open drivers door due to an issue with the welding First noticed when getting into the car where car was parked

- Kent, OH, USA

I have already put in a complaint about the broken spots welds, I am now adding to that complaint. I had the window fixed but because the door is broken I cannot roll down the window. My door is now not locking so stays open even when engaging the locks. The electrical system is giving me errors telling me that there is no key detected and so the engine won't start right away. The radio screen blacks out and doesn't work right, won't keep my settings anymore. This all has been happening since my door broke. I am sick of this car. Casa Ford says that my door is not covered by my extended warranty, but my window was, which was broken because of the broken spot welds in the door. This makes no sense since I am not able to use the window because of the door being broken.

- Las Cruces , NM, USA

My 2020 SEL Ford Escape has faulty spot welds on the drivers side door hinge. All three spot welds have broken and has caused the door to make metal scraping noise and is hard to shut. Also, I can not longer roll down my drivers side window because the hinge is blocking the window from rolling down.

- Carbondale, IL, USA