My car is what is being investigated under PE23013. The welds on my driver door have come undone.

- Columbus , OH, USA

Opened the driver's door and heard a crunching sound and the door could not be opened all the way. Along with that the rear back window would not close and the driver's window went up slowly. Went to the dealership and they say it is a known problem, but they don't have any recalls about them so out of pocket it would cost me upwards of 2000 for the window regulators and 5,000 to replace the door which is a known problem.

- Fort Johnson, LA, USA

I own a 2020 Ford Escape. While entering the vehicle through the driver's side door, the door made an abnormal popping sound while being opened. The passenger-??s side front door also made the abnormal popping sound while being opened. I have been informed by my repair shop that the doors will need to be replaced. I took to my local dealership, Kindle Ford and they informed me that the vehicle is out of warranty as the mileage is at 40,000 miles.

- Cape May Court House, NJ, USA

Heard a cracking or popping when opening or closing front driver side door. Took our 2020 Ford Escape to Authorized Ford Dealership for routine service. While the vehicle was at the dealership we were told that the front drivers door would not close shut. The technician managed to "jimmy rig" the door to get it to close. The door temporary closes but now the drivers window will not operate. Was instructed to take the vehicle to the dealership owner's body shop but due to the mileage on the vehicle it was not recovered under warranty. At the body shop we were asked if the car had been in an accident or if a strong wind had blown on the door. Neither applied. The car has not been in a single accident nor a strong wind pulled or pushed on the door. Was told that we would incur a cost of nearly $3,000, because the whole door would need to be replaced. Was told again that this was not covered by factory warranty. On the estimate from the body shop they listed "t-boned" as reason for damage. We reached out to our extended warranty and they wanted to talk to the body shop but the body shop refuses to work with the warranty company and only speak with our auto insurance. We are in the process of looking for another body shop that might reach out to the warranty company to see if there is any chance this is covered. We contacted Ford Motor Company Customer Service and was told that there is not a recall on the defect and there was nothing they could do. Research on the internet shows that this is not an isolated incident as it relates to the 2020 Ford Escape.

- Shelbyville, IN, USA

This is 1 of 3 2020 - 2021 Ford Escapes that my company owns and is affected by this known issue with NHTSA and Ford Motor Company as it relates to Ford Technical Service Bulletin (TSB) SSM 50150. The spot welds at the check arm attachment points on the driver door have failed. This has lead to a horrible noise and feeling when opening and closing our door. Sometimes the door does not shut all the way making this a safety issue. The door is now hard to open and close. The window is also inoperable as it either won't roll down at all or, if it does roll down, it will now roll back up. This issue has been inspected by 2 dealerships and they are not allowing our PremiumCARE extended Warranty to cover this. We have had 10's of Escapes with 100,000+ miles and this has never been an issue. This has occurred in this 2020 Escape and 1 other 2020 Ford Escape and 1 other 2021 Ford Escape (I will file complaints separately for them so NHTSA understands this is a massive issue Ford needs to fix ASAP and reimburse any customers who have paid out of pocket to get this fixed). NHTSA needs to issue a recall immediately.

- Chicago, IL, USA

This is 1 of 3 2020 - 2021 Ford Escapes that my company owns and is affected by this known issue with NHTSA and Ford Motor Company as it relates to Ford Technical Service Bulletin (TSB) SSM 50150. The spot welds at the check arm attachment points on the driver door have failed. This has lead to a horrible noise and feeling when opening and closing our door. Sometimes the door does not shut all the way making this a safety issue. The door is now hard to open and close. The window is also inoperable as it either won't roll down at all or, if it does roll down, it will now roll back up. This issue has been inspected by 2 dealerships and they are not allowing our PremiumCARE extended Warranty to cover this. We have had 10's of Escapes with 100,000+ miles and this has never been an issue. This has occurred in this 2021 Escape and 2 of our other 2020 Ford Escapes (I will file complaints separately for them so NHTSA understands this is a massive issue Ford needs to fix ASAP and reimburse any customers who have paid out of pocket to get this fixed). NHTSA needs to issue a recall immediately.

- Chicago, IL, USA

The weld on my driver door has completely come loose. The only repair is to replace the whole door.

- South Jordan, UT, USA

Door hinge broke and caused window motor to fail

- Galloway, NJ, USA

7/31/23 Used 2020 Ford Escape was bought at Cecil Atkission Motors, it was deemed "fully functional, no present issues." 08/02/23 Tire issues, dealership inspected and found 2 screws in driver tire/failed alignment test. Also suddenly found oil pan and left axle seal leaking. Seal leaking and replaced. Front axle leaking. 12/08/23 Took Ford Escape to Ford Dealership due to broken popping driver door. Vibration while driving 70mph, inspected and the cause of it is front suspension and uneven tires given by Cecil Atkission Motors. Found oil leak again front cover and oil pan, leak on crank shaft rear main seal. Trans and engine dye found between. Rear seal leaking. Rattle noise at cold start, coming from turbo. Misfire at 2 and 3 cylinders. Blindside spot doesn't detect cars next to car. Due to the driver door being broken and unable to open it poses a safety hazard if car caught on fire or if an accident, unable to escape. Being a 2020-year vehicle, this should not be happening early on. All issues mentioned above are hazardous to my safety and others, including children.

- Mcallen, TX, USA

My driver's side door suddenly made a loud cracking/popping noise when I opened it and then was a little difficult to close. Later when I opened my driver's side window it got stuck and wouldn't go up or down. I took it to my mechanic who said the door hinge had broken free from the body of the car. I then took it to the local Ford dealership who confirmed this is the case and also mentioned this was the second 2020 Ford Escape to be brought in that day for the exact same problem. They were unable to fix it at the dealership and said I need to go to an auto body repair shop to have a new hinge welded back on. Upon doing a little research I discovered that this is a very common problem with this year/make of vehicle.

- Valencia, CA, USA

Spot welds on the driver's side (left) door have failed, teh welds hold the door limiting arm attachment. Documented in NHTSA ID Number: 10201603 Manufacturer Communication Number: SSM 50150 Car has <30,000 miles and is a family vehicle, not high use nor commercial. Failure was recent <2 weeks after noises first appeared. All welds are noticeably failed from the outside of the door.

- Akron, OH, USA

When opening and closing the driver's door, it makes a creaking sound. It will not open completely and will not stay open. In addition, the power windows seem to be affected. I have taken it to a dealership and they report that the door hinges welding has failed.

- Farmers Branch, TX, USA

Driver side door randomly started popping, hard to close completely, and driver side window struggling to roll up and down

- Beech Grove, IN, USA

Door hinge on drivers side makes a popping sound and is hard to close Also drivers side window won-??t roll down Took the car to dealership and they are checking with Ford to see if the car is covered under the warranty

- Windham, OH, USA

The driver's side door started making a strange squeaking noise a few months after I bought the vehicle. After about 3 months the door made a serious creaking noise and started to have issues closing. I inspected the door and found a hole in the metal where the weld spot is.

- Hermitage, TN, USA

The driver's side door makes a popping sound when you open and close the door. The car was not involved in any accident and the mechanic stated it was a door hinge weld issue

- West Babylon, NY, USA

A few weeks ago, the drivers side front door of our 2020 Ford Escape began to make a popping sound upon opening and closing. The issue has now progressed to the door being nearly impossible to open, and the window will not go up and down. The issue seems to be related to what is described in the NTHSA bulletin SSM 50150.

- Newtown, PA, USA

My driver side door starting making cracking sounds when opening and closing then would not close. Got the door to close finally and took to Ford. They said it was something to do with the welds on the door. They originally told me that I would have to pay to have it fixed. Because I purchased the extended warranty I was told it would be covered under that. They told me I would need a new door and that they were on backorder. 9 months later and multiple unreturned calls and I find out they never ordered my door. My door swings open as soon as it unlatches and window doesn't go down.

- Trenton, OH, USA

The Spot Weld on the Driver side door is broke. based on information read this is an issue on this vehicle where the hinge breaks where the spot weld is suppose to hold. Has to be replaced and cost is $2400. Dealership said they have repaired a lot of these doors/Hinges. Asking to pay $2400 on an issue that Ford knows. They have a notice 50150 fro NHTSA that it is a known issue. Looking to help in reimbursing. per the site--- the spot welds' failure in the door's arm. In interviews with owners, NHTSA learned of 25 "minor injuries" and 1 report of "minor property damage." Some people have reported a popping noise when the door comes open and say that the door can be unable to latch when closed or can suddenly come open when it had been closed. According to the safety agency's investigation document, the problem is believed to be faulty spot welds in the check arm attachment points on the doors.As one example, an owner reported to NHTSA that "The driver side front door made a creaking sound, could not be opened, and the window would not go down. The internal weld to the door failed."

- North Ridgeville, OH, USA

Drivers front door started making popping noises. Called Ford dealer where car purchased and they said it just need hinges sprayed with WD40. I did and no change. Went to local mechanic and when I opened the door to show him it popped but then wouldn-??t close. He said the welded holder for metal rod broke. Took off door panel to get it to close and now I have car with no door function, door opener, window opener, and door interior panel now in my back seat. Dealer won-??t look at for 3 weeks.

- Decatur , AL, USA