10.0

really awful
Crashes / Fires:
0 / 2
Injuries / Deaths:
0 / 0
Average Mileage:
12,914 miles

About These NHTSA Complaints:

The NHTSA is the US gov't agency tasked with vehicle safety. Complaints can be spread across multiple & redundant categories, & are not organized by problem. See the Back button — blue bar at the very top of the page — to explore more.

Get notified about new defects, investigations, recalls & lawsuits for the 2020 Ford Expedition:

Unsubscribe any time. We don't sell/share your email.

Get free help with your lemon!
close ad

« Read the previous 20 complaints

problem #24

Mar 172023

Expedition

  • miles
Was on a 7hr road trip. Around 2hrs in attempted to accelerate to pass another vehicle using a passing lane which terminated back down to a single lane. Created an unsafe situation while passing other vehicles at 45-55 mph. Only 20-25k miles on our 2020 expedition. Transmission did not shift appropriately. Lost power and began roughly shifting between gears especially 6th to 7th gear. Warning lights and wrench appeared during/after this event. No engine or wrench lights on prior to this event. Appeared to get stuck In 10th gear and only accelerating to 45-55mph. Would randomly down shift and have rough shifting back up to 10th gear, especially 6-7th gear. Took the vehicle to the nearest Ford dealership. Stated it was transmission communication errors due to how the computer learns driving patterns. The Ford service center cleared the communication errors and disconnected the battery. Gear wrench disappeared and did not occur again for the rest of the trip. Two days later had similar acceleration issue and rough shifting but no warning, engine or wrench lights.

- Lantana, TX, USA

problem #23

Nov 132021

Expedition

  • 20,000 miles
The contact owns a 2020 Ford Expedition. The contact stated while driving 70 MPH, there was an abnormal sound coming from the vehicle, followed by hard shifting from the transmission. The contact stated that the -??Service Required-?? message was displayed. The contact pulled over to the side of the roadway. The vehicle was towed to the dealer to be diagnosed; however, the mechanic found no failure with the vehicle. The contact stated that the failure persisted. The vehicle was towed to the dealer again and the dealer stated that the transmission needed to be replaced, and that the manufacturer was aware of the failure. The vehicle was not repaired. The manufacturer was contacted but offered no assistance. The failure mileage was 20,000.

- Butler, PA, USA

problem #22

Mar 112023

Expedition

  • miles
I was traveling on the interstate at a rate of 75 mph. I signaled a lane change and pressed the gas pedal. I heard the engine respond and the rpm surged. The drive train went dead. There was no power at all. I checked it was in drive and it was. The car began to slow and I began trying to get off the road. Suddenly with a bit of a jerk, it drove normal.

- Great Falls, MT, USA

problem #21

Mar 102023

Expedition

  • miles
While traveling approximately 65 MPH on State Highway 35 near Austin, TX, my Expedition violently shifted out of gear when I attempted to accelerate to move into the next lane out of the way of a commercial 18 wheeler that was changing lanes. This caused me to lose power and coast until I could recover drive ability. My family and I were sitting ducks in the middle lane of a 4-5 lane stretch of highway. I was able to get off the highway and park in the nearest parking lot. I remember seeing a red notification stating something like -??No Shift-?? on the dashboard display when the issue happened. Immediately confirmed no other issues, transmission and cooling system temperatures were in normal range and no other check or warning lights came on. Also, did not see any leaks and all fluids were within normal ranges.

- San Antonio, TX, USA

problem #20

Feb 182023

Expedition

  • miles
I recently purchased this vehicle and I have had the problem from the beginning. When driving and slowing down. Usually around 5th gear or slower, it will shift hard into the lower gear with an obvious noise(thunk) coming from the rear of the vehicle. You can also slightly feel this. I have tried to duplicate the issue without using brakes to rule that out and I have done so. It is definitely not a brake issue but a transmission/power train issue. This happens to me multiple times a day on most every drive. I have looked at multiple forums to see if this is a common issue and it seems that it is. A common issue without a reliable fix. I am hoping that of multiple people claim this issue that Ford will in fact take it seriously and fix the issue

- Brandon, FL, USA

problem #19

Feb 142023

Expedition

  • miles
My transmission shifts very hard while driving. Mainly from 4th to 5th gear while going 50MPH on a decline. The car has been in the shop for it a couple times and have yet to -??replicate-?? the issue or repair it. The blind monitor system keeps saying it-??s having an issue responding to the transmission. I get notified on my app constantly, yet the dealership has told me they can-??t replicate it therefore no repairs have been made.

- White House, TN, USA

problem #18

Mar 042021

Expedition

  • miles
While driving on the interstate and accelerating the vehicle first shifts very hard then goes into complete limp mode, I have had to coast to a stop on the side of the interstate to restart the engine and pray it starts working again. Once it happens once it consistently happens daily till I have it repaired which ford is booking appointments for transmissions 3 months out. The manufacturer has been able to replicate the failure multiple times. Each time it happens the onboard screen flashes to see owners manual and the check engine light comes on. This has put my entire family at risk because it usually happens at 55+mph and going from that amount of speed to no engine/transmission power is terrifying. I have spoke with other owners and this is a consistent problem these machines re having.

- Marion, TX, USA

problem #17

Feb 042023

Expedition

  • miles
There's two different incidents oke happened at approximately 30,800 transmission made a hard clunk around 30 mph, transmission error on dash appeared but cleared as soon as I came to a stop. Transmission started working but shifting differently as in Harder shifts but not all the time. Last week on. February 4th wife stated she felt a hard shift and thought transmission dropped/broke I know ford will say can not replicate symptoms so I am reporting this incase more issues arise from ford expeditions as this can be a safety issue for family's with children or as in our case we foster and are always taking kids to where they need to

- San Diego, CA, USA

problem #16

Jan 162023

Expedition

  • miles
1) Automatic transmission; Yes 2) Transmission defect causes the vehicle to unexpectedly lose power, increasing the chance vehicles traveling behind could collide with the vehicle (powertrain occasionally does not initially respond to throttle input) 3) Yes 4) The vehicle has been inspected by a Ford dealership; unknown with regard to inspection by others (the vehicle has been serviced by a Ford dealership five times and the problem has not been corrected; early symptoms did not include unexpected loss of power; Ford refuses to replace the trans) 5) October 2021; initial symptom was harsh downshifts; symptoms as of 16 January 2023, are harsh downshifts, harsh reverse engagement when vehicle is cold, erratic upshifts (see above) and burning transmission fluid; an error message appeared while driving on 16 January (see attached)

- Wynnewood, PA, USA

problem #15

Jan 192023

Expedition

  • miles
I own the 2020 Expedition. I pressed down on the gas pedal to accelerate into traffic. While the truck should have down shifted and accelerated, instead the powertrain completely disengaged; a total loss of power. The RPM jumped way up to redline, I took my foot of the gas pedal and as the RPM came back down, the transmission slammed back into engagement. At this point, I was finally able to accelerate. This issue has put us in danger as when I am on the road and try to accelerate to my vehicle does go into gear acts if it's in neutral. Also I have been at stop light and light turns green cars are honking as my car won't move. I have had this issue for quite some time, I called for they took it in for inspection the first time and found no issue, took it in again and they said it was the Cadillac converter, they replaced it, and they reprogramed the vehicles gears and now I am expirenceing the same issues, but worst. 2020 Ford Expedition

- Holland, MI, USA

problem #14

Jan 142023

Expedition

  • miles
There seems to be an issue with the 10 speed gear shift in my 2020 Ford Expedition. We were driving on the interstate when we attempted to slow down to shift lanes, the gear shift very harshly and then would not respond to pressing the acceleration pedal. It made some very loud clunk noises and after a few minutes, it finally responded to the acceleration but it also was skipping gears and shifting really hard. Upon research, I found out that older models have an issue with the 10 speed shifter as well as others with my same make/model/year. Will bringing my vehicle in for inspection since this can be very dangerous in busy highways.

- Carriere, MS, USA

problem #13

Dec 162022

Expedition

  • miles
The transmission has now had over 5 shifting stall and power loss events while on the highway when attempting to downshift when accelerating. This loss of power causes a drastic reduction in speed and delay in actions. These events have nearly cause accidents at highway speeds. Additionally the radar sensor for the collision avoidance system went out and the car now shifts harshly in any gear with jerking and clanking. Multiple service lights are now illuminated. This first happened around 20k miles, but is has been increasing in frequency and now the car is not safe or driveable. This is the same transmission that is affecting other ford cars, like the ford 150 which has been subject to recalls. From publicly available information Ford thinks it-??s a shifter and transmission disconnect but has not been able to implement a fox.

- Round Rock, TX, USA

problem #12

Nov 072020

Expedition

  • 15,000 miles
The contact owns a 2020 Ford Expedition. The contact stated while driving at 10-20 MPH a week after purchasing the vehicle brand new, the vehicle started jerking. There was no warning light illuminated. The contact continued driving. However, the failure recurred while driving the entire day. The dealer was notified of the failure and informed the contact that the failure was normal as she had just started driving vehicle. The failure persisted. The vehicle was taken to the dealer twice where it was diagnosed that no issues were found. Additionally, the contact stated that there was steam coming through the AC vents. The contact also stated that the check engine warning light illuminated, indicating that the catalytic converter was damaged. The vehicle was taken to the dealer where it was diagnosed that the battery needed to be replaced. However, after the battery replacement, the vehicle shut off while driving and coming to a complete stop. The contact was able to restart the vehicle. However, the failure reoccurred while driving in the highway. The contact was able to restart the vehicle and veered to the side of the road. The vehicle was taken to the dealer where it was diagnosed that the vehicle was lacking unknown computer chips. Additionally, the dealer diagnosed that the transmission, the AC coil and the catalytic converter had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and opened a case. The failure mileage was unknown.

- San Antonio, TX, USA

problem #11

Jul 142022

Expedition

  • miles
Automatic transmission making abrupt and lurching gear changes (even coming out of Park) in addition to mechanical sounds. Safety has not been an issue, so far. The situation has not been inspected by dealer or any other mechanic. Vehicle still under warranty with less than 8,000 miles. No warning messages have surfaced. Never involved in crash or flooding.

- Altamonte Springs, FL, USA

problem #10

Aug 062022

Expedition

  • miles
I own the above listed 2020 Expedition. We were traveling on Interstate 287 yesterday. I was in the right lane and was stuck behind a slow moving semi truck. I put on my blinker and waited for an opening in traffic to move into the middle lane. When an opening presented itself I pressed down on the gas pedal to accelerate into traffic. While the truck should have down shifted and accelerated, instead the powertrain completely disengaged; a total loss of power. The rpm jumped way up to redline, over revving, but the truck was slowing down. I took my foot of the gas pedal and as the rpm came back down the transmission slammed back into engagement with a loud audible clunk that jolted the whole vehicle. At this point I was finally able to accelerate. While this was all happening I had just moved into the middle lane of traffic, which was bearing down on us. All the vehicles behind us wear slamming their brakes and honking their horns. I thought for sure we were going to die. Thank God it wasn't an 80,000 lbs Peterbilt bearing down on us or we would be dead, by the grace of God we're not. Upon returning home I went onto the Ford truck owners website I belonged to. I came to learn this is a known issue with Ford's 10 speed transmission that Ford has failed to address. That there are pending lawsuits and that the NHTSA is aware of the issue. One of the member suggested that I file a complaint with the NHTSA, that was my impetus for writing you today. This is a dangerous condition that Ford needs to remedy. Thank you in advance for your time and attention in this matter

- Andover, NJ, USA

problem #9

Jun 222022

Expedition

  • miles
When accellerating in 5th, or6th gear trans slips out hard and car wont accelerate for 1 to 2 seconds. It displays being in 1st while this happens before it goes back into precious gear and starts driving.

- Culloden, GA, USA

problem #8

Jun 012021

Expedition

  • 40,000 miles
The contact owns a 2020 Ford Expedition. The contact stated while driving at various speeds, the vehicle started to decelerate independently. The contact stated the error system failure warning light was illuminated. The contact also started to hear an abnormal noise. The contact stated after a few seconds the failure independently stopped and he was able to continue driving to his destination. The contact took the vehicle to the local dealer, where it was diagnosed with needing an unknown TBS to be completed. The vehicle was serviced for the bulletin but continued to experience the failure. The contact took the vehicle back to the dealer however, the mechanic was unable to duplicate the failure. The vehicle was not repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 40,000.

- Jarrettsville, MD, USA

problem #7

Jun 162022

Expedition

  • miles
Can be driving on freeway at 70 mph and all of sudden vehicle stalls or transmission begins to slip or stall. Make this grinding clinking sound.all lights on dash light up. Nearly caused a crash. Vehicle jerks and jumps back into gear and then takes off again. Will also do this at even 35 mph too. This has happened numerous times. We have taken it in to Ford and they can-??t find anything wrong with

- Spring, TX, USA

problem #6

Jun 112022

Expedition

  • miles
At 70+ MPH the automatic transmission made a loud clinking sound, lost acceleration/power for approximant 5-8 sec, and the "wrench" and other lights on the cluster board lite up with every light flashing on the interstate in a passing lane, and heavy traffic all around. This same incident occurred just 2 days later at approx 35 mph. It was erratic, disorienting and very distracting. The sudden change in behavior of the vehicle could have caused me to lose control of the vehicle at speed on a the interstate and could easily resulted in an accident causing major injury and damage. This issue has occurred approximately 8 time in the last year starting at approx 22K miles. The dealer says the car has no fault codes and they have download "updates" to the software. One time the dealer had a code of "Stuck in park". That did not resolve the issues. To date they have no explanation for why the vehicle behaved in this manner. Honestly, i am very reluctant to drive this vehicle. I am at a loss on where to go with this issue.

- Kingwood, TX, USA

problem #5

May 252022

Expedition

  • miles
At least 5 different times while driving I go to push the accelerator and the gear seems to slip and an awful sound like gears grinding is heard. I always feel like my transmission is going to fall out from under the car. It prohibits the car from moving and I have almost been hit from behind because I cannot accelerate at the time. It has happened on the freeway, in town driving, and even accelerating up my driveway. I have taken it to a Ford dealership but no answers.

- Rockwall, TX, USA

Read the next 4 complaints »