The contact owns a 2017 Ford Fusion. The contact stated while driving 50 MPH, the vehicle began to shake and vibrate. The contact pulled over, opened the hood, and noticed that the engine was vibrating violently. The check engine warning light was illuminated and blinking. The vehicle was towed to the local dealer, where it was diagnosed that the engine short block needed to be replaced. The vehicle was not repaired. The manufacturer was contacted and opened a case. The contact stated that the failure was related to Customer Satisfaction Program: 18L02. The failure mileage was approximately 82,601. The contact stated the estimated Engine shortblock replacement is $9211 including parts, and requesting into why this vehicle was not included in the recall. and labor.

- Fremont, CA, USA

The contact owns a 2017 Ford Fusion. The contact stated that when the vehicle was started, the contact noticed white smoke coming from the tailpipes. The check engine warning light was illuminated. The contact stated that the coolant reservoir had to be refilled every four days. The vehicle was taken to an independent mechanic and the spark plugs and coil packs were replaced. The coil packs were replaced twice. The failure reoccurred, and the independent mechanic agreed to replace the coil packs another time. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure and advised the contact to report the failure to the NHTSA Hotline. The failure mileage was approximately 98,275.

- Barlow, KY, USA

While driving on the interstate car began to excessively shake and check engine light flashed for almost a minute then stopped. Was approaching exit to residence location and was able to get there. Once at home, car was then sluggish to start but no check engine light was on. Attempted to drive car in a safe area to see if it would repeat or light would come on. This was on a Sunday, therefore the dealership was closed. Light did come back on solidly and took car to dealership that next day, Monday. Was told coolant intrusion into the engine. After the incident and in doing research, appears to be a known issue in this vehicle.

- Tallahassee , FL, USA

Engine had to be replaced due to a faulty design by Ford of coolant intrusion and a misfire of the cylinder

- Inverness, FL, USA

Coolant intrusion - coolant leaking into the motor because of the engine block design and the head gasket failing. Can cause fire

- La Vernia, TX, USA

The local Ford dealership has confirmed that the engine has an internal issue causing misfires in cylinder 3. It has recommended an expensive full engine replacement, approximately $10,000. Misfires shake the vehicle while driving, which may cause serious accidents and injuries.

- Miami, FL, USA

2017 Ford Fusion. The vehicle was taken to the dealer where it was diagnosed that there was an internal coolant leak to cylinder #2. The dealer stated that the engine block needed to be replaced. The check engine warning light was illuminated, turned off and a few days later came back on. Engine temperature was moderate at first and then sporadically moved between moderate and hot. Per NHTSA: Coolant Intrusion is a common problem amongst 2.0 EcoBoost Engine. Current Ford fix is replace engine block with a new design. Ford is aware of the design flaw in these cars and refuses to make things right with current owners.

- South Lyon, MI, USA

A couple of weeks ago, heater would not work and a very cold day. We stopped after a while for gas and then the heat went on. This went on every time we used the car. So we got an appt at local Ford place last week, where we bought car. Took them several days but turns out the coolant is leaking into the engine and we need a new motor to the tune of 7000 bucks. The car never warned us of any malfunctions. It only has 58,000 miles on it but because it is a 2017 it is out of warrantee. I later learned that the EcoBoost cars have a lot of problems with leaking coolant into the motor. Especially the Ford Fusion and we have a 2 L EcoBoost car.

- Big Canoe, GA, USA

Manufacturer Recall Number23S12 NHTSA Recall Number23V162 Recall on my vehicle Ford has failed to attempt remedy as of December 2023.

- Panorama City , CA, USA

Coolant Intrusion on Cylinder 1, common problem amongst 2.0 Ecoboost Engine. Current Ford fix is replace engine block with a new design. Ford is aware of the design flaw in these cars and refuses to make things right with current owners.

- Glasgow, KY, USA

The car started shaking while driving down the road and when coming to a stop. The gears were not shifting properly. I took it to a mechanic shop and they told me several different things "could" be wrong, supposedly fixed it, $700 for that. Started shaking and shift gear problems again, took it in again and spent $2800 for the supposed fix. Several days later same thing, took it back again and they said to take it to a transmission shop because they couldn't do anymore. Found out there was a recall on the torque and the different mechanic "fixed" that. Now it won't shift into several of the gears. Over $4500 spent! Transmission

- Eagle Butte, SD, USA

The car was shaking when I started it. Took it to the dealership and they told me it got the coolant intrusion into the cylinder and now they need to replace the whole engine with a short block engine. I believe it's a design defect by Ford!

- Norman, OK, USA

Engine light came on and heat and defrosters stopped working in vehicle. Took it into dealer and was told diagnostic code was for misfire in cylinder 3. They did a coolant leak test and immediately found coolant leaking into the engine. Was told this was a known issue with the 2.0L ecoboosts (TSB 22-2229 dated 6/9/22) and that I would need an entire engine block replacement. Due to being out of warranty I would be on the hook for $6,856 for the repairs. Car only had 45,000 miles on it at time of service.

- Clawson, MI, USA

Coolant leaking into engine. Engine block required entire replacement. Check engine light flashing causing me to contact Ford Dealer/Service. This was December 4, 2023.

- Hackettstown , NJ, USA

I went to my dealership because of a check engine light. After many hours of searching, I was told that a coolant leak had been found. I was informed that the head gasket was damaged and causing a leak into the engine. The cheapest repair would cost nearly $8000. The extended warranty that I purchased for the car has expired. Searching Google, I see that Ford is aware of the problem, and has known about it for some time. Ford should not be able to get away with this.

- Richmond, VA, USA

The contact owns a 2017 Ford Fusion. The contact stated that while parking the vehicle, the vehicle stalled. Upon restarting the vehicle, the vehicle failed to move forward or reverse. The system default warning light was displayed. The contact called the local dealer and was informed that the vehicle was not covered under the recall. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline. The failure mileage was approximately 77,432.

- New Bern, NC, USA

The contact owns a 2017 Ford Fusion. The contact stated while driving 55 MPH, there was an abnormal sound coming from the engine compartment, after which the vehicle inadvertently lost motive power. The contact was able to coast to the shoulder of the roadway, where the vehicle failed to restart. No warning lights were illuminated. The vehicle was towed to the dealer, who determined that coolant had leaked into the engine, resulting in engine damage. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, and a case was opened. The failure mileage was unknown.

- Bryant, AR, USA

The contact owns a 2017 Ford Fusion. The contact stated that while starting the vehicle, there was blue smoke coming from the exhaust pipe. The check engine warning light was illuminated. The vehicle was taken to an independent mechanic, who diagnosed that there was coolant intrusion into the engine and determined that the short block needed to be replaced. The vehicle was then taken to the dealer to be repaired under NHTSA Campaign Number: 23V162000 (Service Brakes, Hydraulic) however, the dealer declined to perform Customer Satisfaction Program: 21N12 (Short Block Replacement After Coolant Intrusion). The vehicle was not repaired. The manufacturer was made aware of the failure and a case was opened. The manufacturer informed the contact that Customer Satisfaction Program: 21N12 (Short Block Replacement After Coolant Intrusion) associated with the VIN had expired. The failure mileage was approximately 130,000.

- Cumming, GA, USA

My 2017 Ford Fusion has a coolant issue. Per TSB 19-2139. Ford has a known issue in the cylinder walls and had a program available until November 2022. Sadly this program ended and they still have issues. It has been verified at a third party mechanic and Ford doesn't want to assist in this issue.

- Moncks Corner, SC, USA

Hesitation, lack of power, jerking on acceleration. If felt like an ignition misfire and the engine codes suggested multiple misfires. A power balance test was performed and verified there is a misfire on cylinder 2. The spark plug from 2 was swapped with cylinder 1 and the misfire was in cylinder 1. The spark plugs were replaced November, 2023. The plugs look contaminated-seems to be with engine coolant due to a head gasket failure. The coolant reservoir was empty indicating a coolant leak. They then introduced air into cylinder 2 and the coolant rose inside the coolant reservoir. The gasket is failing between the cylinder and one or more of the water passages beside the cylinder. Ford has since updated their engine design to correct this concern so they knew of the issues. There is a current recall on the 1.5L engine however, not the 2.0L. There are multiple class action suits against Ford for this issue. A new engine is needed. This is a 2017 with 85K miles. A new engine should definitely not be required. When researching this issue, there are multiple safety concerns including engine fire. I spoke to Ford's customer service and they were no help whatsoever.

- Grabill, IN, USA