2016 Volvo XC90
TSBs (Technical Service Bulletins)
Technical Service Bulletins (TSBs) for the 2016 XC90 are official communications between Volvo & their dealerships that describe processes for troubleshooting or fixing certain common problems. All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
-
TSB #TJ3551120
Creaking noise from Steering Wheel Module (SWM) Read More »
-
TSB #TJ35511
Creaking noise from Steering Wheel Module (SWM) Read More »
-
TSB #TJ Instruction V
Steering column cover, squeaking noise Read More »
-
TSB #TJ35842.1.0-2021
This is a Technical Journal: Noise when turning steering wheel. Check rubber gromet in firewall Read More »
-
TSB #TJ32033.5.0-2020
This is a Technical Journal: Audio switches on right side of steering wheel, intermittent no function. Read More »
-
TSB #TJ32033
Audio switches on steering wheel, no function Read More »
-
TSB #TJ19245.1.10-201
VOLVO CARS SERVICE AND PARTS BUSINESS Technical Journal TITLE : Vehicle type and platform identification REF NO : ISSUING DEPARTMENT : CAR MARKET : United States and Canada TJ 19245 Technical Service PARTNER : ISSUE DATE : 3 US 7510 Volvo ... Read More »
-
TSB #TJ32198.3.0-2017
This is a Technical Journal: If creaking/ticking noise from release pin on SWM when turning the Steering wheel follow advice under Service. * Mount Velour tape (cut off a piece 10x15mm from Part nr. Read More »
-
TSB #TJ32033.1.0-2016
After using a voice command to adjust the climate, the buttons for ?Forward?, ?Back? and ?Confirm? on the audio switches on the right side of the steering wheel may not function (marked as ?1?, ?2?and ?3? in attachment). Read More »
-
TSB #TJ31353
This document is a Techncial Journal: If heavy shudder occurs directly after turning 90 degrees from a standstill, then follow advice under service. Read More »
-
TSB #CBR-2014 202402
CBR - Driveline Noise, Suspension Ride Height Too High, Suspension Will Not Exhaust - Chassis Built 2016w01 And Newer. Read More »
-
TSB #TJ31423
Blown fuse, compressor - air suspension Read More »
-
TSB #ST-248-2021-04-1
Volvo Car USA LLC and Volvo Car Canada LTD (Volvo) on behalf of Volvo Car Corporation, has voluntarily decided to extend warranty coverage on the Rear Suspension Air Compressor for certain model year 2017-2020 S90 Series, 2017-2020 V90 ... Read More »
-
TSB #P10064-2021-04-1
Volvo Car USA LLC and Volvo Car Canada LTD (Volvo) on behalf of Volvo Car Corporation, has voluntarily decided to extend warranty coverage on the Rear Suspension Air Compressor for certain model year 2017-2020 S90 Series, 2017-2020 V90 ... Read More »
-
TSB #P10064-2021-03-1
Volvo Car USA LLC and Volvo Car Canada LTD (Volvo) on behalf of Volvo Car Corporation, has voluntarily decided to extend warranty coverage on the Rear Suspension Air Compressor for certain model year 2017-2020 S90 Series, 2017-2020 V90 ... Read More »
-
TSB #P10064-2021-02-2
Volvo Car USA LLC and Volvo Car Canada LTD (Volvo) on behalf of Volvo Car Corporation, has voluntarily decided to extend warranty coverage on the Rear Suspension Air Compressor for certain model year 2017-2020 S90 Series, 2017-2020 V90 ... Read More »
-
TSB #TJ31423.18.0-202
This is a Technical Journal: Blown fuse, compressor - air suspension. Perform Total Upgrade, replace fuse and compressor according to VIDA. Read More »
-
TSB #TJ20803.20.0-201
This is a Technical Journal: In case of complaint of Noise, some "tools" have been created to help you to do a better and more precise fault tracing Read More »
-
TSB #TJ30517.6.0-2019
VOLVO CARS SERVICE AND PARTS BUSINESS Technical Journal TITLE : Rear air suspension - air spring dust cover comes loose REF NO : ISSUING DEPARTMENT : CAR MARKET : United States and Canada TJ 30517 Technical Service PARTNER : ISSUE DATE : ... Read More »
-
TSB #TJ30517.5.0-2019
VOLVO CARS SERVICE AND PARTS BUSINESS Technical Journal TITLE : Rear air suspension - air spring dust cover comes loose REF NO : ISSUING DEPARTMENT : CAR MARKET : United States and Canada TJ 30517 Technical Service PARTNER : ISSUE DATE : ... Read More »
-
TSB #TJ31423.12.0-201
This is a Technical Journal: Blown fuse, compressor - air suspension. Perform Total Upgrade, replace fuse and compressor according to VIDA. Read More »
-
TSB #TJ31423-11-0-201
This is a Technical Journal: Blown fuse, compressor - air suspension. Perform Total Upgrade, replace fuse and compressor according to VIDA. Read More »
-
TSB #TJ32978
This is a Technical Journal: *Added VST Operation No. If the vehicle is equipped with air suspension and if customer is complaining over a knock/rattle/clatter noise from the front suspension when driving on roughroads or over a road ... Read More »
-
TSB #TJ32978 2 0-2017
This is a Technical Journal: *Added VST Operation No. If the vehicle is equipped with air suspension and if customer is complaining over a knock/rattle/clatter noise from the front suspension when driving on roughroads or over a road ... Read More »
-
TSB #TJ31236.16.0-201
If the vehicle is equipped with air suspension and if customer is complaining over a knock/rattle/clatter noise from the front suspension when driving on rough roads or over a road hump, then follow the advice under Service. Read More »
-
TSB #TJ31236.16.0-201
If the vehicle is equipped with air suspension and if customer is complaining over a knock/rattle/clatter noise from the front suspension when driving on rough roads or over a road hump, then follow the advice under Service. Read More »
-
TSB #TJ31236.15.0-201
If the vehicle is equipped with air suspension and if customer is complaining over a knock/rattle/clatter noise from the front suspension when driving on rough roads or over a road hump, then follow the advice under Service. Read More »
-
TSB #TJ31236.10.0-201
If the vehicle is equipped with air suspension and if customer is complaining over a knock/rattle/clatter noise from the front suspension when driving on rough roads or over a road hump, then follow the advice under Service. Read More »
-
TSB #PB65-008
This Parts Bulletin was issued to Parts Managers, Please return stock of part number's 31406337, 31406349, 31406350 bushing kits to your servicing distribution center. Read More »
-
TSB #TJ31236.8.0
If the vehicle is equipped with air suspension and if customer is complaining over a knock/rattle/clatter noise from the front suspension when driving on rough roads or over a road hump, then follow the advice under Service. Read More »
-
TSB #TJ31236
If the vehicle is equipped with air suspension and if customer is complaining over a knock/rattle/clatter noise from the front suspension when driving on rough roads or over a road hump, then follow the advice under Service. Read More »
-
TSB #TJ31423-11-0-201
This is a Technical Journal: Blown fuse, compressor - air suspension. Perform Total Upgrade, replace fuse and compressor according to VIDA. Read More »
-
TSB #TJ31423-11-0-201
This is a Technical Journal: Blown fuse, compressor - air suspension. Perform Total Upgrade, replace fuse and compressor according to VIDA. Read More »
-
TSB #TJ31423-5-0-2018
This is a Technical Journal: Blown fuse, compressor - air suspension. Perform Total Upgrade, replace fuse and compressor according to VIDA. Read More »
-
TSB #TJ31423-5-0-2018
This is a Technical Journal: Blown fuse, compressor - air suspension. Perform Total Upgrade, replace fuse and compressor according to VIDA. Read More »
-
TSB #TJ31423-4-0-2018
This is a Technical Journal: Blown fuse, compressor - air suspension. Perform Total Upgrade, replace fuse and compressor according to VIDA. Read More »
-
TSB #TJ31423-4-0-2018
This is a Technical Journal: Blown fuse, compressor - air suspension. Perform Total Upgrade, replace fuse and compressor according to VIDA. Read More »
-
TSB #TJ32978
Front Air Suspension, knock/rattle/clatter noise Read More »
-
TSB #TJ31236.8.0
If the vehicle is equipped with air suspension and if customer is complaining over a knock/rattle/clatter noise from the front suspension when driving on rough roads or over a road hump, then follow the advice under Service. Read More »
-
TSB #TJ31236
If the vehicle is equipped with air suspension and if customer is complaining over a knock/rattle/clatter noise from the front suspension when driving on rough roads or over a road hump, then follow the advice under Service. Read More »
-
TSB #TJ30517.6.0-2019
VOLVO CARS SERVICE AND PARTS BUSINESS Technical Journal TITLE : Rear air suspension - air spring dust cover comes loose REF NO : ISSUING DEPARTMENT : CAR MARKET : United States and Canada TJ 30517 Technical Service PARTNER : ISSUE DATE : ... Read More »
-
TSB #S79852-2019-05-0
Volvo Car USA LLC and Volvo Car Canada LTD (Volvo) on behalf of Volvo Car Corporation, have decided to launch Service Action S79852 on certain model year 2016 XC90 vehicles equipped with air suspension. Read More »
-
TSB #TJ36202.2.0
Vibration/shudder while braking Read More »
-
TSB #TJ28941-4-0-2019
This is a Technical Journal: When sensitive information, like vehicle speed, brake usage, etc. (customer behavoiur information) of a car is required from Volvo Car Corporation from external sources, either of these two documents should be ... Read More »
-
TSB #TJ34246-1-0-2018
This is a Technical Journal: SPA Brake noise Read More »
-
TSB #TJ34246-1-0-2018
This is a Technical Journal: SPA Brake noise Read More »
-
TSB #TJ34246-1-0-2018
This is a Technical Journal: SPA Brake noise For the purpose of correct fault tracing of the brake noise, the attached guideline has been developed, as an overview of the brake noise and indicates possible faults/solutions. Read More »
-
TSB #TJ33239.1.0-2017
This is a Technical Journal: Brake vibrations due to lockable wheel screws Read More »
-
TSB #TJ32780
XC90 Hybrid, rear brake noise 18" Read More »
-
TSB #TJ28941.1.0-2016
This is a Technical Journal: When sensitive information, like vehicle speed, brake usage, etc. (customer behavoiur information) of a car is required from Volvo Car Corporation from external sources, either of these two documents should be ... Read More »
-
TSB #TJ31473.5.0-2016
THIS IS A TECHNICAL JOURNAL: IF THERE IS AN UNUSUAL NOISE FROM ABS SYSTEM TOGETHER DIAGNOSTIC TROUBLE CODE BCM-C002201, THEN FOLLOW ADVICE IN SERVICE. Read More »
-
TSB #TJ30934402016090
THIS IS A TECHNICAL JOURNAL: IF SQUEALING NOISE OCCURS FROM FRONT BRAKES ON CARS BUILT BEFORE CHASSIS NUMBER 040328, THEN REPLACE FRONT DISCS ACCORDING TO VIDA, THE NEW BRAKE DISCS HAVE CHANGED METAL COMPOSITION IN ORDER TO REDUCE ... Read More »
-
TSB #TJ30934
XC90 Front brake noise Read More »
-
TSB #TJ33506-2-0-2018
This is a Technical Journal: Squealing noise from rear brakes at low speed. If squealing noise occur from rear brakes 17" at low speed, follow advice under service. Read More »
-
TSB #TJ33506-2-0-2018
This is a Technical Journal: Squealing noise from rear brakes at low speed. If squealing noise occur from rear brakes 17" at low speed, follow advice under service. Read More »
-
TSB #TJ31007
Squealing noise from rear brakes at low speed Read More »
-
TSB #TJ29818
If the vehicle is equipped with indirect tire pressure monitoring sensors (I-TPMS) (VDN codes: PU02, PU03, PU04), and there is a warning message in the DIM about Low tire pressure and DTC BCM-C007768, follow advice under Service. Read More »
-
TSB #TJ30934
This is a Technical Journal: * If squealing noise occurs from front brakes on cars built before chassis number 040328, then Replace front discs according to VIDA, the new brake discs have changed metal composition in order to reduce ... Read More »
-
TSB #TJ30934
This is a Technical Journal: * If squealing noise occurs from front brakes on cars built before chassis number 040328, then Replace front discs according to VIDA, the new brake discs have changed metal composition in order to reduce ... Read More »
-
TSB #TJ30934
This is a Technical Journal: * If squealing noise occurs from front brakes on cars built before chassis number 040328, then Replace front discs according to VIDA, the new brake discs have changed metal composition in order to reduce ... Read More »
-
TSB #TJ30934
This is a Technical Journal: * If squealing noise occurs from front brakes on cars built before chassis number 040328, then Replace front discs according to VIDA, the new brake discs have changed metal composition in order to reduce ... Read More »
-
TSB #TJ32978 2 0-2017
This is a Technical Journal: *Added VST Operation No. If the vehicle is equipped with air suspension and if customer is complaining over a knock/rattle/clatter noise from the front suspension when driving on roughroads or over a road ... Read More »
-
TSB #TJ30934.9.3-2017
This is a Technical Journal: * If squealing noise occurs from front brakes on cars built before chassis number 040328, then Replace front discs according to VIDA, the new brake discs have changed metal composition in order to reduce ... Read More »
-
TSB #TJ31007.9.1-2017
This is a Technical Journal: If symptom of noise occurs from the rear brakes during braking follow advice under service. New brake pads have been implemented for service and production , 2015week34. Read More »
-
TSB #TJ31007.9.0-2017
This is a Technical Journal: If symptom of noise occurs from the rear brakes during braking follow advice under service. New brake pads have been implemented for service and production , 2015week34. Read More »
-
TSB #TJ31007.8.2-2017
This is a Technical Journal: If symptom of noise occurs from the rear brakes during braking follow advice under service. New brake pads have been implemented for service and production , 2015week34. Read More »
-
TSB #TJ30934.9.2-2017
This is a Technical Journal: * If squealing noise occurs from front brakes on cars built before chassis number 040328, then Replace front discs according to VIDA, the new brake discs have changed metal composition in order to reduce ... Read More »
-
TSB #TJ31007.8.1-2016
This is a Technical Journal: If symptom of noise occurs from the rear brakes during braking follow advice under service. New brake pads have been implemented for service and production , 2015week34. Read More »
-
TSB #TJ30934.9.1-2016
This is a Technical Journal: * If squealing noise occurs from front brakes on cars built before chassis number 040328, then Replace front discs according to VIDA, the new brake discs have changed metal composition in order to reduce ... Read More »
-
TSB #TJ31007.8.0
This is a Technical Journal: If symptom of noise occurs from the rear brakes during braking follow advice under service. New brake pads have been implemented for service and production , 2015week34. Read More »
-
TSB #TJ3100770
This document is a Technical Journal: If symptom of noise occurs from the rear brakes during braking follow advice under service. New brake pads have been implemented for service and production , 2015week34. Read More »
-
TSB #TJ31007.6.0
If symptom of noise occurs from the rear brakes during braking follow advice under service. New brake pads have been implemented for service and production , 2015week34. Read More »
-
TSB #TJ31007
If symptom of noise occurs from the rear brakes during braking follow advice under service. New brake pads have been implemented for service and production , 2015week34. Read More »
-
TSB #TJ30934.9.1-2016
This is a Technical Journal: * If squealing noise occurs from front brakes on cars built before chassis number 040328, then Replace front discs according to VIDA, the new brake discs have changed metal composition in order to reduce ... Read More »
-
TSB #TJ31007.8.0
This is a Technical Journal: If symptom of noise occurs from the rear brakes during braking follow advice under service. New brake pads have been implemented for service and production , 2015week34. Read More »
-
TSB #TJ31007.6.0
If symptom of noise occurs from the rear brakes during braking follow advice under service. New brake pads have been implemented for service and production , 2015week34. Read More »
-
TSB #TJ28941.1.0-2016
This is a Technical Journal: When sensitive information, like vehicle speed, brake usage, etc. (customer behavoiur information) of a car is required from Volvo Car Corporation from external sources, either of these two documents should be ... Read More »
-
TSB #TJ33506-2-0-2018
This is a Technical Journal: Squealing noise from rear brakes at low speed. If squealing noise occur from rear brakes 17" at low speed, follow advice under service. Read More »
-
TSB #TJ31007.8.1-2016
This is a Technical Journal: If symptom of noise occurs from the rear brakes during braking follow advice under service. New brake pads have been implemented for service and production , 2015week34. Read More »
-
TSB #TJ31423-6-0
This is a Technical Journal: Blown fuse, compressor - air suspension. Perform Total Upgrade, replace fuse and compressor according to VIDA. Read More »
-
TSB #TJ31398.4.0-2020
This is a Technical Journal: D-TPMS, Service required and DTC's Read More »
-
TSB #TJ30934.9.0
If squealing noise occurs from front brakes, then follow the instruction under Service. Read More »
-
TSB #TJ30934
This is a Technical Journal: * If squealing noise occurs from front brakes on cars built before chassis number 040328, then Replace front discs according to VIDA, the new brake discs have changed metal composition in order to reduce ... Read More »
-
TSB #TJ30934.9.0
If squealing noise occurs from front brakes, then follow the instruction under Service. Read More »
-
TSB #TJ30934.3.0
This is a Technical Journal: If squealing noise occurs from front brakes on cars built before chassis number 040328, then Replace front discs according to VIDA, the new brake discs have changed metal composition in order to reduce ... Read More »
-
TSB #TJ30934
This is a Technical Journal: * If squealing noise occurs from front brakes on cars built before chassis number 040328, then Replace front discs according to VIDA, the new brake discs have changed metal composition in order to reduce ... Read More »
-
TSB #TJ30934.3.0
This is a Technical Journal: If squealing noise occurs from front brakes on cars built before chassis number 040328, then Replace front discs according to VIDA, the new brake discs have changed metal composition in order to reduce ... Read More »
-
TSB #TJ31007.8.0
This is a Technical Journal: If symptom of noise occurs from the rear brakes during braking follow advice under service. New brake pads have been implemented for service and production , 2015week34. Read More »
-
TSB #TJ31007.6.0
If symptom of noise occurs from the rear brakes during braking follow advice under service. New brake pads have been implemented for service and production , 2015week34. Read More »
-
TSB #34647.6.1
This is a Technical Journal: DIM message about parking brake. Download the available total upgrade software. Read More »
-
TSB #TJ32525A
DIM message ?Parking brake service required? Read More »
-
TSB #TJ3252551
DIM message ?Parking brake service required? Read More »
-
TSB #TJ34647.4.0-2019
This is a Technical Journal: DIM message about parking brake. Perform software upgrade. Read More »
-
TSB #TJ3155840
If the rear Parking Assistance System (PAS) is not working and there is a message in DIM about ?Parking Assistance System service required? displayed in DIM, then it is possible that there is water ingress into rear park assist sensors ... Read More »
-
TSB #TJ31319
Fresh air hose loose from air filter housing Read More »
-
TSB #S39816-2017-04-2
Volvo has identified that due to a software deviation in the Vehicle Dynamics Domain Master (VDDM) Primary Boot Loader (PBL), the vehicle may not start after it has been parked and the parking brake lamp will be lit in the instrument panel. Read More »
-
TSB #S39816-2017-04-2
This is a Quality Bulletin. Volvo Car USA LLC and Volvo Car of Canada Ltd (Volvo) on behalf of Volvo Car Corporation, has decided to launch Service Action S39816 on certain model year 2016 - 2017 XC90 and 2017 S90, V90CC and V90 vehicles. Read More »
-
TSB #TJ31558.2.0-2016
If the rear Parking Assistance System (PAS) is not working and there is a message in DIM about ?Parking Assistance System service required? displayed in DIM, then it is possible that there is water ingress into rear park assist sensors ... Read More »
-
TSB #TJ29122.3.0-2016
This is a Technical Journal: The front park assist sensor bracket may come loose from the lower grill. The clamping force on the bracket in the lower grill may be too low. Read More »
-
TSB #TJ29122.2.0
This is a Technical Journal: The front park assist sensor bracket may come loose from the lower grill. The clamping force on the bracket in the lower grill may be too low. Read More »
-
TSB #TJ33442.12.0-202
This is a technical Journal:If the vehicle has a click sound from the left engine pad, follow the advice under "Service". Make sure that the sound is coming from the engine pad, NOT from the drive shaft. Read More »
-
TSB #TJ33442.10.0-202
This is a technical Journal:If the vehicle has a click sound from the left engine pad, follow the advice under "Service". Make sure that the sound is coming from the engine pad, NOT from the drive shaft. Read More »
-
TSB #SMB39-015-2020-0
This is a Service Manager Bulletin: Prior Approval for VCM Replacement Read More »
-
TSB #TJ34787.2.1-2020
This is a Technical Journal: Ping noise from exhaust when cooling down Read More »
-
TSB #TJ34740.1.3-2020
This is a Technical Journal: 4 Cylinder VEP engine: Castrol Edge Professional V 0W-20 Synthetic oil. Read More »
-
TSB #TJ34648.1.4-2020
This is a Technical Journal: In case of complaint of Noise, some "tools" have been created to help you to do a better and more precise fault tracing Read More »
-
TSB #TJ3478720-2019-0
This is a Technical Journal: Ping noise from exhaust when cooling down Read More »
-
TSB #TJ21965-5-0-2019
This is a Technical Journal: Oil in cooling system. New cleaning method developed. Read More »
-
TSB #TJ34206.1.0-2018
This is a Technical Journal: Damaged throttle body due to showroom device. To protect the throttle housing when using Volvo Car Showmode kit in the specified cars, always remove the connector from the throttle housing (see picture 34206. Read More »
-
TSB #TJ33442
This is a technical Journal:If the vehicle has a click sound from the left engine pad, follow the advice under "Service". Make sure that the sound is coming from the engine pad, NOT from the drive shaft. Read More »
-
TSB #TJ20803-17-0-201
This is a Technical Journal: In case of complaint of Noise, some "tools" have been created to help you to do a better and more precise fault tracing Read More »
-
TSB #PB28-S29842
Volvo Car USA LLC on behalf of Volvo Car Corporation, has decided to launch Service Action S29842 on certain model year 2015 ? 2016 XC60, S60, V60, S80, XC70 & 2016 XC90 vehicles. Read More »
-
TSB #TJ29131 7 0-2017
This is a Technical Journal: Customer may experience a low oil level warning in DIM and /or oil leakage from the engine. Read More »
-
TSB #TJ30268.5.0-2017
VOLVO CARS SERVICE AND PARTS BUSINESS Technical Journal TITLE : Drive - E Thermostat DTCs stored in Engine Control Module ( ECM ) Read More »
-
TSB #TJ29131.6.0-2017
This is a Technical Journal: Customer may experience a low oil level warning in DIM and /or oil leakage from the engine. Read More »
-
TSB #TJ29131.5.0-2017
This is a Technical Journal: Customer may experience a low oil level warning in DIM and /or oil leakage from the engine. Read More »
-
TSB #TJ30268
VOLVO CARS SERVICE AND PARTS BUSINESS TECHNICAL JOURNAL TITLE: DRIVE - E THERMOSTAT DTCS STORED IN ENGINE CONTROL MODULE ( ECM ) REF NO: ISSUING DEPARTMENT : CAR MARKET : UNITED STATES AND CANADA TJ 30268 TECHNICAL SERVICE PARTNER: ISSUE ... Read More »
-
TSB #TJ29131
THIS IS A TECHNICAL JOURNAL: CUSTOMER MAY EXPERIENCE A LOW OIL LEVEL WARNING IN DIM AND /OR OIL LEAKAGE FROM THE ENGINE. Read More »
-
TSB #TJ20803
THIS IS A TECHNICAL JOURNAL: IN CASE OF COMPLAINT OF NOISE, SOME "TOOLS" HAVE BEEN CREATED TO HELP YOU TO DO A BETTER AND MORE PRECISE FAULT TRACING Read More »
-
TSB #TJ29131.3.0
This is a Technical Journal: Customer may experience a low oil level warning in DIM and /or oil leakage from the engine. Read More »
-
TSB #SMB22-206
All new Volvo engines leave the factory filled with Castrol EDGE Professional as an integral part of their delivery of high performance. Read More »
-
TSB #TJ3140020160421
THIS IS A TECHNICAL JOURNAL : FOR A NO CRANK, NO START CONDITION WHERE THE OBC (ON BOARD CHARGER) IS NOT RESPONDING IN VIDA (OBC_NOT_RESPONDING.JPG), AND THERE ARE NO RELATED DTCS, FOLLOW PROCEDURE UNDER SERVICE. Read More »
-
TSB #TJ3121620160421
THIS IS A TECHNICAL JOURNAL : IF AN ENGINE STILL HAS A HIGH LEVEL OF OIL CONSUMPTION DESPITE FOLLOWING TJ30087, FOLLOW THE ACTIONS DESCRIBED UNDER SERVICE. Read More »
-
TSB #TJ3131920160412
THIS IS A TECHNICAL JOURNAL : STRUCTURE WEEK CHANGED UNDER VEHICLE TYPE Read More »
-
TSB #TJ3112020160412
THIS IS A TECHNICAL JOURNAL : * VSTG OP NO. ADDED. * TEXT ADDED UNDER SERVICE. ?VSTG OP NO. SEE ATTACHMENT? * ENGINE VARIANT ADDED ECM=ENGINE CONTROL MODULE VIDA= VEHICLE INFORMATION AND DIAGNOSTICS FOR AFTERSALES VSTG= VOLVO STANDARD ... Read More »
-
TSB #SMB0032120160411
THIS IS A SERVICE MANAGER BULLETIN : TO FURTHER ENHANCE THE CUSTOMER?S VOLVO OWNERSHIP EXPERIENCE, VOLVO CAR USA, LLC ANNOUNCES THE MY 2013 ? MY2016 VOLVO COMPLIMENTARY FACTORY SCHEDULED MAINTENANCE PROGRAM USA. Read More »
-
TSB #SMB0034920160411
THIS IS A SERVICE MANAGER BULLETIN : TO FURTHER ENHANCE THE VOLVO OWNERSHIP EXPERIENCE, VOLVO CAR CANADA LIMITED OFFERED FACTORY SCHEDULED MAINTENANCE (FSM) ON CERTAIN MY14, 15 AND 16 VEHICLES. Read More »
-
TSB #SMB0034020160411
THIS IS A SERVICE MANAGER BULLETIN : TO FURTHER ENHANCE THE VOLVO?S OWNERSHIP EXPERIENCE, VOLVO CAR CANADA LIMITED IS OFFERING THE VOLVO PREPAID MAINTENANCE (VPM) PROGRAM. Read More »
-
TSB #SMB0032120160408
THIS IS A SERVICE MANAGER BULLETIN : TO FURTHER ENHANCE THE CUSTOMER?S VOLVO OWNERSHIP EXPERIENCE, VOLVO CAR USA, LLC ANNOUNCES THE MY 2013 ? MY2016 VOLVO COMPLIMENTARY FACTORY SCHEDULED MAINTENANCE PROGRAM USA. Read More »
-
TSB #CBR-2201
Engine Control Module (EMS) Software (MSW) Information a?? August 2022; Improvement List (Change Log) - US21+OBD22 (13L VGT, TC) And US17+OBD22 (11L) Emissions Read More »
-
TSB #KC-105
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P05EB, Diagnostic And Repair Information - US14+OBD15 And US14+OBD16 (Commonly Model Years 2016 And 2017) Read More »
-
TSB #SJ1000167-2020-0
This is a Service Journal: Coolant Filling Equipment Tool Read More »
-
TSB #TJ32958.5.0-2019
This is a Technical Journal: A whining or rattling sound may appear when revving up the engine. ( see attached sample files ). Read More »
-
TSB #TJ21965.7.0-2019
This is a Technical Journal: Oil in cooling system. New cleaning method developed. Read More »
-
TSB #TJ3478720-2019-0
This is a Technical Journal: Ping noise from exhaust when cooling down Read More »
-
TSB #TJ21965-5-0-2019
This is a Technical Journal: Oil in cooling system. New cleaning method developed. Read More »
-
TSB #SMB00321
To further enhance the customer?s Volvo ownership experience, Volvo Car USA, LLC offers the MY 2013 and later Volvo Complimentary Factory Scheduled Maintenance Program. Read More »
-
TSB #S29846
Volvo Car USA LLC and Volvo Car Canada LTD (Volvo) on behalf of Volvo Car Corporation, has decided to launch Service Campaign S29846 on certain model year 2016 XC90 vehicles. Read More »
-
TSB #TJ33442
This is a technical Journal:If the vehicle has a click sound from the left engine pad, follow the advice under "Service". Make sure that the sound is coming from the engine pad, NOT from the drive shaft. Read More »
-
TSB #R29936
Volvo Car USA LLC and Volvo Car Canada LTD (Volvo) on behalf of Volvo Car Group has decided to launch Recall R29936 on model year 2016 XC90 vehicles. Read More »
-
TSB #S29846
This is a Quality Bulletin. Volvo Car USA LLC and Volvo Car Canada LTD (Volvo) on behalf of Volvo Car Corporation, has decided to launch Service Campaign S29846 on certain model year 2016 XC90 vehicles. Read More »
-
TSB #PB26-S29846
Volvo has identified that engine coolant may leak due to an insufficient quick connector in the coolant expansion tank bleeder hose. Read More »
-
TSB #S29846
This is a Quality Bulletin. Volvo Car USA LLC and Volvo Car Canada LTD (Volvo) on behalf of Volvo Car Corporation, has decided to launch Service Campaign S29846 on certain model year 2016 XC90 vehicles. Read More »
-
TSB #PB26S29846
Volvo has identified that engine coolant may leak due to an insufficient quick connector in the coolant expansion tank bleeder hose. Read More »
-
TSB #TJ33442d
Left engine pad click sound Read More »
-
TSB #TJ33442c
Left engine pad click sound Read More »
-
TSB #TJ20803
This is a Technical Journal: In case of complaint of Noise, some "tools" have been created to help you to do a better and more precise fault tracing Read More »
-
TSB #TJ32903
T8 DTC BECM?P0CE100 Coolant Control Valve ?A? Stuck On. Read More »
-
TSB #TJ32216
Drive-E: Low oil level message in Driver Information Module (DIM) Read More »
-
TSB #TJ31319.3.0-2017
VOLVO CAR SERVICE AND PARTS BUSINESS Technical Journal TITLE : Fresh air hose loose from air filter housingPermanent Text DESCRIPTION : Note ! If using a printed copy of this Technical Journal , first check for the latest online version . Read More »
-
TSB #TJ30925502016092
THIS IS A TECHNICAL JOURNAL: CUSTOMER MAY EXPERIENCE UNEXPECTED CLIMATE REGULATION DURING DRIVING, CLIMATE SYSTEM MIGHT SUDDENLY STARTS TO BLOW HOT/COLD AIR. CCM SW NOW IMPLEMENTED 2016W38 IN PRODUCTION AND FOR SERVICE. Read More »
-
TSB #TJ3097120160419
THIS IS A TECHNICAL JOURNAL : WHEN ANY REPAIR IS MADE ON ENGINE COOLING SYSTEM, MAKE SURE THAT THE VOLVO SPECIAL TOOL P/N 9512957 COOLANT FILLING EQUIPMENT IS USED, IN ORDER TO PREVENT FUTURE OVER TEMPERATURE DAMAGE ON ENGINE. Read More »
-
TSB #TJ29131 7 0-2017
This is a Technical Journal: Customer may experience a low oil level warning in DIM and /or oil leakage from the engine. Read More »
-
TSB #SMB00321
Volvo Complimentary Factory schedualed maintenance Read More »
-
TSB #KC-105
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P05EB, Diagnostic And Repair Information - US14+OBD15 And US14+OBD16 (Commonly Model Years 2016 And 2017) Read More »
-
TSB #TJ31955
Recall R89707: Air conditioner drain hose Read More »
-
TSB #TJ21965-5-0-2019
This is a Technical Journal: Oil in cooling system. New cleaning method developed. Read More »
-
TSB #PB87-024-2016-12
Parts Bulletin TITLE: Parts Return: 31469071 Hose Read More »
-
TSB #TJ31955
Recall R89707: Air conditioner drain hose Read More »
-
TSB #SMB00027
Emission Warranty Update. Read More »
-
TSB #TJ31319
Fresh air hose loose from air filter housing Read More »
-
TSB #TJ32978 2 0-2017
This is a Technical Journal: *Added VST Operation No. If the vehicle is equipped with air suspension and if customer is complaining over a knock/rattle/clatter noise from the front suspension when driving on roughroads or over a road ... Read More »
-
TSB #TJ32887
Fuel door lid not possible to open Read More »
-
TSB #TJ25153.7.2-2017
This is a Technical Journal: Washer system layout for identifying leakage points REF NO : ISSUING DEPARTMENT : CAR MARKET : United States and Canada TJ 25153 Technical Service PARTNER : ISSUE DATE : STATUS DATE : 3 US 7510 Volvo Car USA ... Read More »
-
TSB #PB87-025-2017-02
Please return stock of part numbers 31390488, 31390489, 31455693, 31455694 Draining hose to you servicing distribution center. Read More »
-
TSB #TJ34215a
Hard to fill fuel due to frozen filler pipe Read More »
-
TSB #TJ32887
Fuel door lid not possible to open Read More »
-
TSB #TJ33794
This is a Technical Journal: Replacement of (LPS)Low Pressure Sensor and fuel line P5. If the car is equipped with a Cooper LPS P/N 31478293/31405791, replace it with a new Sensata sensor P/N 31432653 that is included in a kit P/N ... Read More »
-
TSB #PB23-P29929-2019
Volvo Car USA LLC and Volvo Car Canada LTD (Volvo) on behalf of Volvo Car Corporation, has voluntarily decided to extend warranty coverage on certain model year 2015 ? 2016 S60, V60, XC60, S80, XC90, XC70 models. Read More »
-
TSB #P29929-2019-05-2
Volvo Car USA LLC and Volvo Car Canada LTD (Volvo) on behalf of Volvo Car Corporation, has voluntarily decided to extend warranty coverage on certain model year 2015 ? 2016 S60, V60, XC60, S80, XC90, XC70 models. Read More »
-
TSB #TJ32209.1.0-2016
This is a Technical Journal: Improved low fuel indication A more detailed low fuel indication can be added in the DIM (Driver Information Module). Read More »
-
TSB #SMB00321
Volvo Complimentary Factory schedualed maintenance Read More »
-
TSB #TJ33794
This is a Technical Journal: Replacement of (LPS)Low Pressure Sensor and fuel line P5. If the car is equipped with a Cooper LPS P/N 31478293/31405791, replace it with a new Sensata sensor P/N 31432653 that is included in a kit P/N ... Read More »
-
TSB #TJ31754.1.0
This is a Technical Journal: If the customer experiences that the fuel gauge in the DIM is indicating zero but the distance to empty is still indicating some kilometers (miles), It is unlikely that the distance to empty indication is a ... Read More »
-
TSB #S39803
VOLVO CAR SERVICE AND PARTS BUSINESS QUALITY BULLETIN TITLE : SERVICE CAMPAIGN S39803 : INVERTER GENERATOR MODULE ( IGM ) MODEL YEAR 2016 - 2017 XC90 T8 GROUP:CAT / NO:ISSUING DEPARTMENT : CAR MARKET : WARRANTY UNITED STATES AND CANADA 32 ... Read More »
-
TSB #TJ31949
THIS IS A TECHNICAL JOURNAL: IF THE INVERTER GENERATOR MODULE (IGM) IS EXPOSED TO HIGH TEMPERATURES AND VIBRATION, A DIAGNOSTIC TROUBLE CODE (DTC) MAY BE SET INDICATING AN INTERNAL ISOLATION FAULT THAT WILL RENDER THE IGM INOPERABLE. Read More »
-
TSB #S3980320160926
THIS IS A QUALITY BULLETIN: IF THE INVERTER GENERATOR MODULE (IGM) IS EXPOSED TO HIGH TEMPERATURES AND VIBRATION, A DIAGNOSTIC TROUBLE CODE (DTC) MAY BE SET INDICATING AN INTERNAL ISOLATION FAULT THAT WILL RENDER THE IGM INOPERABLE. Read More »
-
TSB #PB32S39803201609
THIS IS A PARTS BULLETIN: IF THE INVERTER GENERATOR MODULE (IGM) IS EXPOSED TO HIGH TEMPERATURES AND VIBRATION, A DIAGNOSTIC TROUBLE CODE (DTC) MAY BE SET INDICATING AN INTERNAL ISOLATION FAULT THAT WILL RENDER THE IGM INOPERABLE. Read More »
-
TSB #36814.1.0
This is a Technical Journal: Transmission Shifts From D or R to P Immediately After Starting. This symptom can occur if the driver changes the position of the gear shifter from P to D or R very quickly after starting the engine and the ... Read More »
-
TSB #TJ3666530
ERAD (Electric Rear Axle Drive) Bearing Noise Read More »
-
TSB #TJ3666510
Bearing Noise. Read More »
-
TSB #TJ33442.11.0-202
This is a technical Journal:If the vehicle has a click sound from the left engine pad, follow the advice under "Service". Make sure that the sound is coming from the engine pad, NOT from the drive shaft. Read More »
-
TSB #TJ20803.21.0-202
This is a Technical Journal: In case of complaint of Noise, some "tools" have been created to help you to do a better and more precise fault tracing Read More »
-
TSB #TJ32469-3-0-2018
This is a Technical Journal: Gear shift lever inoperable Read More »
-
TSB #TJ32469.1.0
This is a Technical Journal: Gear shift lever inoperable Read More »
-
TSB #TJ29131
THIS IS A TECHNICAL JOURNAL: CUSTOMER MAY EXPERIENCE A LOW OIL LEVEL WARNING IN DIM AND /OR OIL LEAKAGE FROM THE ENGINE. Read More »
-
TSB #TJ32469
This is a Technical Journal: Gear shift lever inoperable Read More »
-
TSB #TJ32469.1.0
This is a Technical Journal: Gear shift lever inoperable Read More »
-
TSB #TJ32469-3-0-2018
This is a Technical Journal: Gear shift lever inoperable Read More »
-
TSB #TJ31247
XC90 T8 DTC IEM-P0A1B47 Read More »
-
TSB #PB46-S49792-2016
This is a parts bulletin. Volvo Car USA LLC and Volvo Car of Canada Ltd (Volvo) on behalf of Volvo Car Corporation, has decided to launch Service Campaign S49792 on certain model year 2016 XC90 vehicles. Read More »
-
TSB #TJ32118.1.1-2016
This is a Technical Journal: Service Campaign S49792 Volvo has identified that certain vehicles may have been manufactured with axle shaft boots that are out of specification. Read More »
-
TSB #S49792-2016-11-1
This is a Quality Bulletin. Volvo Car USA LLC and Volvo Car of Canada Ltd (Volvo) on behalf of Volvo Car Corporation, has decided to launch Service Campaign S49792 on certain model year 2016 XC90 vehicles. Read More »
-
TSB #TJ31247
XC90 T8 DTC IEM-P0A1B47 Read More »
-
TSB #TJ31353
XC90 T8 shudder from rear axle (ERAD). Read More »
-
TSB #34295.7.1
This is a Technical Journal: High Voltage Battery repairs. Always repair the battery according to the methods in VIDA. Read More »
-
TSB #36845.1.2
This is a Technical Journal: SPA/CMA - 12V Battery Testing / Maintenance Guide. After capturing a NEW VIDA readout, conduct the steps in VIDA. Read More »
-
TSB #35924.1.4
This is a Technical Journal: VIDA Main battery diagnostic - Prompted to charge battery a second time. Use had held tester. Read More »
-
TSB #36376.4.0
This is a Technical Journal: SR PHEV Cell Module Replacement. Updated BECM software was released Read More »
-
TSB #26745.13.14
This is a Technical Journal: 12V Battery Testing Method Read More »
-
TSB #TJ3637610
high-voltage battery cell module in a PHEV. Read More »
-
TSB #TJ3551120
Creaking noise from Steering Wheel Module (SWM) Read More »
-
TSB #TJ3641530
Electrical rear axis drive Read More »
-
TSB #TJ35511
Creaking noise from Steering Wheel Module (SWM) Read More »
-
TSB #TJ36455
Volvo Cars App Android, no climate setting button Read More »
-
TSB #TJ30382
Programming of User defined Service Interval, new XC90 MY2016 Read More »
-
TSB #TJ35902
Connectivity services activation - PSIM issues Read More »
-
TSB #KC-145
Part information for AMT input shaft repair kits and the shim kit that is required for repair. Read More »
-
TSB #Service Manager
3G Network Sunset Read More »
-
TSB #Service Manager
Shipping and Handling of Volvo Lithium-ion 48V Mild Hybrid Battery to Global Battery Solutions (GBS) Read More »
-
TSB #SMB00-015-2021-0
This is a Service Manager Bulletin : Volvo Electric Vehicle Technical De-Energization Permit to Work Form Read More »
-
TSB #P10064-2021-04-1
Volvo Car USA LLC and Volvo Car Canada LTD (Volvo) on behalf of Volvo Car Corporation, has voluntarily decided to extend warranty coverage on the Rear Suspension Air Compressor for certain model year 2017-2020 S90 Series, 2017-2020 V90 ... Read More »
-
TSB #TJ31423.18.1-202
This is a Technical Journal: Blown fuse, compressor - air suspension. Perform Total Upgrade, replace fuse and compressor according to VIDA. Read More »
-
TSB #TJ34241.2.3-2021
This is a Technical Journal: 12V battery message and DTC CEM-B129F96 Read More »
-
TSB #TJ33031.5.0-2021
This is a Technical Journal: If remote control key is not detected by the car and shows message in DIM "Car key not found" or if functions such as lock/unlock are not working, please follow advice for detecting ... Read More »
-
TSB #TJ35662.1.0-2020
This is a Technical Journal: Headlamp condensation - broken guide pin. Replace broken guide pin Read More »
-
TSB #TJ34241.2.1-2020
This is a Technical Journal: 12V battery message and DTC CEM-B129F96 Read More »
-
TSB #TJ31946.1.2-2019
This is a Technical Journal: Swapping control modules from vehicle to vehicle for diagnostics should be avoided. Read More »
-
TSB #TJ31946.1.1-2019
This is a Technical Journal: Swapping control modules from vehicle to vehicle for diagnostics should be avoided. Read More »
-
TSB #TJ26745.13.1-201
Effective immediately, all 12V batteries may be tested using the hand held battery tester 9513030 (BT3300). The VIDA test is still available but no longer required. Read More »
-
TSB #SMB00-006-2019-1
Software Installation Policy changes. Read More »
-
TSB #TJ31543.9.0-2019
This is a Technical Journal: This Journal is a guide for performing Software Downloads. Service: *See guide updated Oct. 12, 2016 for relevant P5/SPA Software Download information: P5_SPA_SW_Guide. Read More »
-
TSB #TJ34222 1 4 2019
Model year 2016 XC90s were built with a single USB port which is not capable of supporting Android Auto functionality. Read More »
-
TSB #TJ34206 2 0-2019
This is a Technical Journal: Damaged throttle body due to showroom device. To protect the throttle housing when using Volvo Car Showmode kit in the specified cars, always remove the connector from the throttle housing (see picture 34206. Read More »
-
TSB #TJ3482012-2019-0
This is a Technical Journal: Updates to the customer's software, May 2019 Read More »
-
TSB #TJ3424120-2019-0
This is a Technical Journal: 12V battery message and DTC CEM-B129F96 Read More »
-
TSB #PB23-P29929-2019
Volvo Car USA LLC and Volvo Car Canada LTD (Volvo) on behalf of Volvo Car Corporation, has voluntarily decided to extend warranty coverage on certain model year 2015 ? 2016 S60, V60, XC60, S80, XC90, XC70 models. Read More »
-
TSB #P29929-2019-05-2
Volvo Car USA LLC and Volvo Car Canada LTD (Volvo) on behalf of Volvo Car Corporation, has voluntarily decided to extend warranty coverage on certain model year 2015 ? 2016 S60, V60, XC60, S80, XC90, XC70 models. Read More »
-
TSB #SMB30-001-2019-0
This is a Service Managers Bulletin: Volvo Cars is constantly developing the in-car systems and the services offered to customers, so that their cars give them the best experience possible . Read More »
-
TSB #SPJ3475710-2019-
This is a Service Product Journal: Unable to set SPA/CMA vehicle into programming mode - P2P Read More »
-
TSB #TJ3386430-2019-0
This is a Technical Journal: It may happen that after a software download, the TPMS light is flashing and DTC VDDM-U24004A, "ECU Software. System internal failures" is set. Read More »
-
TSB #SPJ3475310-2019-
This is a Service Product Journal: Not possible to left click ECU's in the network image for non-spa cars Read More »
-
TSB #TJ3478111-2019-0
This is a Technical Journal: Changing DIM trip computer value Read More »
-
TSB #TJ3416511-2019-0
This is a Technical Journal: No VIDA communication with vehicle Read More »
-
TSB #TJ26745.13.1-201
Effective immediately, all 12V batteries may be tested using the hand held battery tester 9513030 (BT3300). The VIDA test is still available but no longer required. Read More »
-
TSB #TJ33854.3.0-2019
This is Technical Journal: Intermittent low performance + triple ECM DTC. Do not replace any parts for these cases. Read More »
-
TSB #TJ33931b
SPA Hybrid Irregular electrical distance to empty after Software upgrade Read More »
-
TSB #TJ31423.12.0-201
This is a Technical Journal: Blown fuse, compressor - air suspension. Perform Total Upgrade, replace fuse and compressor according to VIDA. Read More »
-
TSB #TJ31514.2.0-2019
this a Technical Journal: ASDM = Active Safety Domain Master To prevent unnecessary replacements of ASDM and as a troubleshooting aid for the Intellisafe system, please follow the advice in Technical ... Read More »
-
TSB #TJ33165.4.0-2019
This is a Technical Journal: Ghost DTC set, VCM-B15F855, CEM-B158151 Read More »
-
TSB #TJ31423-11-0-201
This is a Technical Journal: Blown fuse, compressor - air suspension. Perform Total Upgrade, replace fuse and compressor according to VIDA. Read More »
-
TSB #TJ31423-11-0-201
This is a Technical Journal: Blown fuse, compressor - air suspension. Perform Total Upgrade, replace fuse and compressor according to VIDA. Read More »
-
TSB #TJ34206.1.0-2018
This is a Technical Journal: Damaged throttle body due to showroom device. To protect the throttle housing when using Volvo Car Showmode kit in the specified cars, always remove the connector from the throttle housing (see picture 34206. Read More »
-
TSB #TJ31216
Drive-E: Low oil level message in Driver Information Module (DIM) Read More »
-
TSB #TJ33931c
SPA Hybrid Irregular electrical distance to empty after Software upgrade Read More »
-
TSB #TJ31423 6 0-2018
This is a Technical Journal: Blown fuse, compressor - air suspension. Perform Total Upgrade, replace fuse and compressor according to VIDA. Read More »
-
TSB #TJ31423-6-0
This is a Technical Journal: Blown fuse, compressor - air suspension. Perform Total Upgrade, replace fuse and compressor according to VIDA. Read More »
-
TSB #TJ33389 2 0-2018
This is a Technical Journal: If the preconditioning timer function in the Volvo on call app does not work, but setting the calendar function in the car and direct start of the climate settings from the app does work, please follow the ... Read More »
-
TSB #TJ3155840
If the rear Parking Assistance System (PAS) is not working and there is a message in DIM about ?Parking Assistance System service required? displayed in DIM, then it is possible that there is water ingress into rear park assist sensors ... Read More »
-
TSB #SMB00-006-2018-0
Software Installation Policy changes. Read More »
-
TSB #SMB00-006C-2018-
Software Installation Policy changes - Canada Read More »
-
TSB #TJ31423-5-0-2018
This is a Technical Journal: Blown fuse, compressor - air suspension. Perform Total Upgrade, replace fuse and compressor according to VIDA. Read More »
-
TSB #TJ20803-17-0-201
This is a Technical Journal: In case of complaint of Noise, some "tools" have been created to help you to do a better and more precise fault tracing Read More »
-
TSB #TJ31423-5-0-2018
This is a Technical Journal: Blown fuse, compressor - air suspension. Perform Total Upgrade, replace fuse and compressor according to VIDA. Read More »
-
TSB #TJ33633-1-2-2018
This is a Technical Journal: No Internet Connection With Car Modem/"SIM Card Not Inserted" message. In order to restore the connectivity functions, the "Roaming" function must be activated in the vehicle menus. Read More »
-
TSB #SMB00-006C-2018-
Software Installation Policy changes - Canada Read More »
-
TSB #SMB00-006-2018-0
Software Installation Policy changes. Read More »
-
TSB #TJ33285-3-0-2018
This is a Technical Journal: DTC IHU-B156C8F sets incorrectly. For the cars in the header this DTC can be ignored as it doesn't affect any of the functions in the car. Read More »
-
TSB #TJ31423-4-0-2018
This is a Technical Journal: Blown fuse, compressor - air suspension. Perform Total Upgrade, replace fuse and compressor according to VIDA. Read More »
-
TSB #TJ31423-4-0-2018
This is a Technical Journal: Blown fuse, compressor - air suspension. Perform Total Upgrade, replace fuse and compressor according to VIDA. Read More »
-
TSB #TJ31543-4-5-2018
This is a Technical Journal: This Journal is a guide for performing Software Downloads. Service: *See guide updated Oct. 12, 2016 for relevant P5/SPA Software Download information: P5_SPA_SW_Guide. Read More »
-
TSB #SMB00-006-2018-0
Software Installation Policy changes. Read More »
-
TSB #SMB00-006C-2018-
Software Installation Policy changes - Canada Read More »
-
TSB #SPJ33554-1-0-201
This is a Service Product Journal: Software Purchase Failed - General error occured - VDS / SPA / CMA cars. Download software fix Read More »
-
TSB #TJ32747.1.2-2017
DIM = Driver's Information Module On May 8th, 2017 new DIM software was released that contained a graphic system check of the vehicle's Intellisafe systems. Read More »
-
TSB #TJ30499
This is a Technical Journal: This TJ is released to highlight the importance of not storing the remote control key close to objects that may shield radio communication between the remote control key and the car or could cause interference ... Read More »
-
TSB #PB28-S29842
Volvo Car USA LLC on behalf of Volvo Car Corporation, has decided to launch Service Action S29842 on certain model year 2015 ? 2016 XC60, S60, V60, S80, XC70 & 2016 XC90 vehicles. Read More »
-
TSB #PB28-S29842-1
Volvo Car USA LLC on behalf of Volvo Car Corporation, has decided to launch Service Action S29842 on certain model year 2015 ? 2016 XC60, S60, V60, S80, XC70 & 2016 XC90 vehicles. Read More »
-
TSB #ST-111A
MIDTRONICS PSC-550S and PSC-700 VEHICLE POWER SUPPLY information Read More »
-
TSB #PB28-S29842
Volvo Car USA LLC on behalf of Volvo Car Corporation, has decided to launch Service Action S29842 on certain model year 2015 ? 2016 XC60, S60, V60, S80, XC70 & 2016 XC90 vehicles. Read More »
-
TSB #SPJ33143
This is a Service Product Journal: Windows 7: Unable to open Wiring diagrams Windows 10: VIDA will crash when trying to open wiring diagram Final Solution: The only solution that we are aware of is to uninstall Adobe SVG viewer. Read More »
-
TSB #SPJ33143
This is a Service Product Journal: Windows 7: Unable to open Wiring diagrams Windows 10: VIDA will crash when trying to open wiring diagram Final Solution: The only solution that we are aware of is to uninstall Adobe SVG viewer. Read More »
-
TSB #ST-211-2017-10-0
VOLVO CARS SERVICE AND PARTS BUSINESS Special Tools Bulletin TITLE : Newsletter 64 : Mandatory Tools NO : DATE : CAR MARKET : United States and 211 YEAR MONTH DAY Page 1 of 13 Canada 2015 05 04 All tools have been classified as required , ... Read More »
-
TSB #PB28-001-2017-10
Please return stock of part number 31380014 spark plug kit to your servicing distribution center. Read More »
-
TSB #ST-211-2017-10-0
VOLVO CARS SERVICE AND PARTS BUSINESS Special Tools Bulletin TITLE : Newsletter 64 : Mandatory Tools NO : DATE : CAR MARKET : United States and 211 YEAR MONTH DAY Page 1 of 13 Canada 2015 05 04 All tools have been classified as required , ... Read More »
-
TSB #TJ31295 1 8-2017
the infotainment system in the vehicle restarts or reboots repeatedly while driving. When this happens the CCD and the center area of the DIM will go blank for a few moments and then start back up as if the vehicle has just been started up. Read More »
-
TSB #TJ32958 1 1-2017
This is a Technical Journal: A whining or rattling sound may appear when revving up the engine. ( see attached sample files ). Read More »
-
TSB #TJ33057
This is a Technical Journal: Configuration Test Software Read More »
-
TSB #TJ32995 1 1-2017
This is a Technical Journal: Adapter cable needed at WAM for IHU Replacement Read More »
-
TSB #TJ32185
Voice recognition database upgrades Read More »
-
TSB #TJ32338
Driving/Poor performance/lacks power Read More »
-
TSB #TJ32903
T8 DTC BECM?P0CE100 Coolant Control Valve ?A? Stuck On. Read More »
-
TSB #TJ31698
Difficulty to add/program remote key, Read More »
-
TSB #TJ32216
Drive-E: Low oil level message in Driver Information Module (DIM) Read More »
-
TSB #TJ32812
Remote Battery Monitoring in VOC APP Read More »
-
TSB #TJ31862
Workaround to improve software download success Read More »
-
TSB #TJ3134720-2017-0
This is a Technical Journal: Message in DIM "Windscreen Sensor Blocked" ASDM= Active Safety Domain Master *If the customer experiences the warning message "Windscreen sensor blocked. See manual. Read More »
-
TSB #TJ3129516-2017-0
the infotainment system in the vehicle restarts or reboots repeatedly while driving. When this happens the CCD and the center area of the DIM will go blank for a few moments and then start back up as if the vehicle has just been started up. Read More »
-
TSB #TJ32714.1.2-2017
This is a Technical Journal: Sensus Infotainment Interface Changes, May 2017. Download software. Read More »
-
TSB #SMB00-006-2017-0
Software Installation Policy changes. Read More »
-
TSB #SMB39-014-2017-0
This is a Service Manager Bulletin: It is in support of Technical Journal 32714 Sensus Infotainment Interface Changes, May 2017 Read More »
-
TSB #TJ32591.1.2-2017
Descripition of Goodwill Policy and Guidelines. Read More »
-
TSB #PB29-S39820-2017
Volvo Car USA LLC and Volvo Car of Canada Ltd (Volvo) on behalf of Volvo Car Corporation, has decided to launch Service Action S39820 on certain model year 2016 ? 2017 XC90 T8 Hybrid vehicles. Read More »
-
TSB #TJ32591.1.1-2017
This is a Technical Journal: SERVICE ACTION S39816: VDDM PBL Upgrade. The corrective action is to perform a VDDM PBL software upgrade Read More »
-
TSB #SPJ32587.2.0-201
This is a Service Product Journal: VIDA will not support Windows 8.1 after June 30th 2017 Read More »
-
TSB #PB36-066-2017-04
Please return stock of parts numbers 31674102, 31674103, 31674104, 31674106, Turn Signal Switch, Wiper Washer Switch to your servicing distribution center. Read More »
-
TSB #TJ30268.6.0-2017
VOLVO CARS SERVICE AND PARTS BUSINESS Technical Journal TITLE : Drive - E Thermostat DTCs stored in Engine Control Module ( ECM ) Read More »
-
TSB #TJ31319.3.0-2017
VOLVO CAR SERVICE AND PARTS BUSINESS Technical Journal TITLE : Fresh air hose loose from air filter housingPermanent Text DESCRIPTION : Note ! If using a printed copy of this Technical Journal , first check for the latest online version . Read More »
-
TSB #TJ30268.5.0-2017
VOLVO CARS SERVICE AND PARTS BUSINESS Technical Journal TITLE : Drive - E Thermostat DTCs stored in Engine Control Module ( ECM ) Read More »
-
TSB #ST-111A-2017-02-
MIDTRONICS PSC-550S and PSC-700 VEHICLE POWER SUPPLY information Read More »
-
TSB #TJ31543.4.3-2017
This is a Technical Journal: This Journal is a guide for performing Software Downloads. Service: *See guide updated Oct. 12, 2016 for relevant P5/SPA Software Download information: P5_SPA_SW_Guide. Read More »
-
TSB #TJ20402.3.4-2017
Technical Journal TITLE : The Error Frame Finder (EFF) can be an aid in fault tracing intermittent CAN network problems by providing a visible indication of error frames that are being transmitted on the network when the fault becomes ... Read More »
-
TSB #TJ31295.1.4-2017
the infotainment system in the vehicle restarts or reboots repeatedly while driving. When this happens the CCD and the center area of the DIM will go blank for a few moments and then start back up as if the vehicle has just been started up. Read More »
-
TSB #PB36-064-2017-02
Please return stock of 31414981, 31419659, 31419661, 31419662, 31419664, 31489105 Remote Control and Shell's to your servicing distribution center. Read More »
-
TSB #ST-211-2017-01-2
VOLVO CARS SERVICE AND PARTS BUSINESS Special Tools Bulletin TITLE : Newsletter 64 : Mandatory Tools NO : DATE : CAR MARKET : United States and 211 YEAR MONTH DAY Page 1 of 13 Canada 2015 05 04 All tools have been classified as required , ... Read More »
-
TSB #PB36-062-2017-01
Please return stock of part numbers 31419911, 31419918 Remote Control and 31439211, 31439212 Shell to your servicing distribution center. Read More »
-
TSB #TJ30794.1.0-2017
This is a Technical Journal: New Remote Controls and Shells for XC90/S90 The remote control shell fastening concept has been changed to solve issues with the shells coming loose. Read More »
-
TSB #SPJ32225.1.0-201
Service Product Journal TITLE: Message shown while trying to add software part number manually in VIDA Read More »
-
TSB #PB87-R89707-2016
This is a Parts Bulletin: Condensation water, transferred through the air conditioning drain hose, may leak into the passenger compartment due to incorrect installation during vehicle assembly. Read More »
-
TSB #TJ31558.2.0-2016
If the rear Parking Assistance System (PAS) is not working and there is a message in DIM about ?Parking Assistance System service required? displayed in DIM, then it is possible that there is water ingress into rear park assist sensors ... Read More »
-
TSB #TJ30662.1.4-2016
This is a Technical Journal: XC90 Software Upgrades Available REF NO : ISSUING DEPARTMENT : CAR MARKET : United States and Canada TJ 30662 Technical Service PARTNER : ISSUE DATE : STATUS DATE : 3 US 7510 Volvo Cars North America 2015 - 10 ... Read More »
-
TSB #TJ32204.1.1-2016
This is a Technical Journal: P-SIM = Personal Subscriber Identity Module When using the in-car modem and P-SIM connection, the following symptoms may appear: 1 - In car apps such as TuneIn and Pandora connect to the service but say ... Read More »
-
TSB #TJ31863.3.0-2016
This is a Technical Journal: * New VCM software release date CCD = Center Console Display DIM = Driver Information Module VCM = Vehicle Connectivity Master After upgrading an XC90 with the previous Total Upgrade software package, the ... Read More »
-
TSB #TJ31798.2.0-2016
Inverter Generator Module "DTC IGM- P0DFC00, Generator Position Sensor Not learned" may be noticed at a VIDA readout. No reported customer symptoms. Ignore the DTC, work is ongoing to find the root cause. Read More »
-
TSB #TJ32010.2.0-2016
Technical Journal TITLE: Lock switch in rear door panel sticks Read More »
-
TSB #PB87-R89707-2016
Update: NEW GROMMET AND PLUG PART NUMBERS REPLACE EXISTING DRAIN HOSES Volvo Car USA LLC and Volvo Car Canada LTD (Volvo) on behalf of Volvo Car Group has decided to launch Recall R89707 on model year 2016 & 2017 XC90 & S90 vehicles. Read More »
-
TSB #TJ32010.1.0-2016
It may be possible for the rear door lock switch to get stuck in the speaker grille. This can lead to a drained battery. Applies only for cars with Premium or High Performance stereo. Read More »
-
TSB #TJ26753
THIS IS A TECHNICAL JOURNAL: IT HAS BEEN NOTICED ON REQUESTED MATERIALS THAT PAS SENSORS ARE ANALYZED WITHOUT FINDING ANY FAULT ON THE PARTS. Read More »
-
TSB #TJ29131.3.0
This is a Technical Journal: Customer may experience a low oil level warning in DIM and /or oil leakage from the engine. Read More »
-
TSB #TJ31810.1.0
This document is a Technical Journal: Service Campaign A39773 on model year 2016 XC90 vehicles equipped with the Premium Sound System. Read More »
-
TSB #PB39-A39773
This document is a Parts Bulletin: Service Campaign A39773 on model year 2016 XC90 vehicles equipped with the Premium Sound System. Read More »
-
TSB #A39773
This document is a Quality Bulletin: Service Campaign A39773 on model year 2016 XC90 vehicles equipped with the Premium Sound System. Read More »
-
TSB #R89702
This software prevents the auto-close function from activating when the sunroof switch is pushed upward while the glass is in an open position. Follow the below Technician Instructions for Recall R89702, Panoramic Sun Roof Switch SW. Read More »
-
TSB #SMB00-352
To ensure a smooth download check that the battery State Of Charge (SoC) value is at least 70%. This value can be read out with VIDA under Central Electronic Module (CEM) parameters. Read More »
-
TSB #TJ31569
This software prevents the auto-close function from activating when the sunroof switch is pushed upward while the glass is in an open position. Follow the below Technician Instructions for Recall R89702, Panoramic Sun Roof Switch SW. Read More »
-
TSB #TJ31569A
This software prevents the auto-close function from activating when the sunroof switch is pushed upward while the glass is in an open position. Follow the below Technician Instructions for Recall R89702, Panoramic Sun Roof Switch SW. Read More »
-
TSB #TJ31569
This software prevents the auto-close function from activating when the sunroof switch is pushed upward while the glass is in an open position. Follow the below Technician Instructions for Recall R89702, Panoramic Sun Roof Switch SW. Read More »
-
TSB #TJ31295
This docuement is a Technical Journal: The infotainment system in the vehicle re-starts or reboots repeatedly while driving. Read More »
-
TSB #TJ31569
This document is a Technical Journal: This software prevents the auto-close function from activating when the sunroof switch is pushed upward while the glass is in an open position. Read More »
-
TSB #TJ3140020160421
THIS IS A TECHNICAL JOURNAL : FOR A NO CRANK, NO START CONDITION WHERE THE OBC (ON BOARD CHARGER) IS NOT RESPONDING IN VIDA (OBC_NOT_RESPONDING.JPG), AND THERE ARE NO RELATED DTCS, FOLLOW PROCEDURE UNDER SERVICE. Read More »
-
TSB #TJ3099120160419
THIS IS A TECHNICAL JOURNAL : BEGINNING NOVEMBER 23RD 2015, THE XC90 COURTESY UPGRADE (QBC-10006) MUST BE PERFORMED ON ALL VEHICLES PRIOR TO STRUCTURE WEEK 2015W46 BEFORE DOWNLOADING ANY OTHER SOFTWARE, INCLUDING PRE DELIVERY SERVICE ... Read More »
-
TSB #TJ3112020160412
THIS IS A TECHNICAL JOURNAL : * VSTG OP NO. ADDED. * TEXT ADDED UNDER SERVICE. ?VSTG OP NO. SEE ATTACHMENT? * ENGINE VARIANT ADDED ECM=ENGINE CONTROL MODULE VIDA= VEHICLE INFORMATION AND DIAGNOSTICS FOR AFTERSALES VSTG= VOLVO STANDARD ... Read More »
-
TSB #SPJ3141020160408
THIS IS A SERVICE PRODUCT JOURNAL : WHEN PERFORMING SOFTWARE DOWNLOADS TO A VEHICLE THERE MIGHT BE AN UNHANDLED SCRIPT EXCEPTION OR ERROR MESSAGE. WE DON?T HAVE THE FULL SCOPE ON WHICH SOFTWARES ARE AFFECTED BY THIS. Read More »
-
TSB #TJ 31398
2016 XC90 D-TPMS, Service required and DTC?s Warning lights and chimes/Tire pressure monitoring, Service required warning TPMS troubleshooting CSC = LI Tyre x1 replace (only use if removing tyre to inspect TPMS sensor brand) Sensor ... Read More »
-
TSB #TJ33617.2.1-2021
This is a Technical Journal: Front seat heater, function control. If not working check the heating grid wiring. Read More »
-
TSB #TJ34295
PHEV High Voltage Battery Repairs Read More »
-
TSB #ST-248-2021-04-1
Volvo Car USA LLC and Volvo Car Canada LTD (Volvo) on behalf of Volvo Car Corporation, has voluntarily decided to extend warranty coverage on the Rear Suspension Air Compressor for certain model year 2017-2020 S90 Series, 2017-2020 V90 ... Read More »
-
TSB #TJ34241.2.2-2020
This is a Technical Journal: 12V battery message and DTC CEM-B129F96 Read More »
-
TSB #Service Manager
Battery Charger/maintainer requirement Read More »
-
TSB #TJ26745.13.3-201
Effective immediately, all 12V batteries may be tested using the hand held battery tester 9513030 (BT3300). The VIDA test is still available but no longer required. Read More »
-
TSB #TJ34241.1.2-2018
This is a Technical Journal: 12V battery message and DTC CEM-B129F96 Read More »
-
TSB #PB31-004-2018-08
This is a Parts Bulletin: 12 Volt support batteries, part number 30659531 must be maintained 9 months from the month of manufacture and every 9 months thereafter. Read More »
-
TSB #PB31-004-2018-08
This is a Parts Bulletin: 12 Volt support batteries, part number 30659531 must be maintained 9 months from the month of manufacture and every 9 months thereafter. Read More »
-
TSB #TJ32162.1.0-2016
This is a Technical Journal: Low battery State of Charge due to FMDM disturbance. When viewing the Quiescient Current Statistics in VIDA, vehicles with a regular FMDM disturbance will often show a number of counts in the 400-800mA range. Read More »
-
TSB #TJ31220.1.4-2016
Low Battery message displayed in the DIM (Driver Information Module). Read More »
-
TSB #TJ26745.7.2
This document is a Technical Journal: Effective immediately, all 12V batteries may be tested using the hand held battery tester 9513030 (BT3300). The VIDA test is still available but no longer required. Read More »
-
TSB #TJ3170810
This document is a Technical Journal: Battery Control Switch module BCSM. Component failure. Internal fault": This DTC is most likely set due to that at one or more occasions the main battery terminal(s) has been disconnected/reconnected ... Read More »
-
TSB #TJ31220
Low Battery message displayed in the DIM (Driver Information Module). Read More »
-
TSB #TJ30588
If Alarm Service Required message is shown in the DIM and DTC CEM-U132A96 is present, follow advice under Service. Perform Total Upgrade XC90 (Software Product 31483292). Read More »
-
TSB #SPJ3070120160419
THIS IS A SERVICE PRODUCT JOURNAL : THE PREVIOUSLY REPORTED ISSUE WITH VIDA 2015 AND BATTERY TESTING HAS BEEN RESOLVED. VIDA 2015 BATTERY TESTING IS THE ONLY APPROVED METHOD FOR PRODUCING BATTERY TEST CODES. Read More »
-
TSB #TJ31798.2.0-2016
Inverter Generator Module "DTC IGM- P0DFC00, Generator Position Sensor Not learned" may be noticed at a VIDA readout. No reported customer symptoms. Ignore the DTC, work is ongoing to find the root cause. Read More »
-
TSB #TJ31949
THIS IS A TECHNICAL JOURNAL: IF THE INVERTER GENERATOR MODULE (IGM) IS EXPOSED TO HIGH TEMPERATURES AND VIBRATION, A DIAGNOSTIC TROUBLE CODE (DTC) MAY BE SET INDICATING AN INTERNAL ISOLATION FAULT THAT WILL RENDER THE IGM INOPERABLE. Read More »
-
TSB #TJ31949102016092
THIS IS A TECHNICAL JOURNAL: IF THE INVERTER GENERATOR MODULE (IGM) IS EXPOSED TO HIGH TEMPERATURES AND VIBRATION, A DIAGNOSTIC TROUBLE CODE (DTC) MAY BE SET INDICATING AN INTERNAL ISOLATION FAULT THAT WILL RENDER THE IGM INOPERABLE. Read More »
-
TSB #S3980320160926
THIS IS A QUALITY BULLETIN: IF THE INVERTER GENERATOR MODULE (IGM) IS EXPOSED TO HIGH TEMPERATURES AND VIBRATION, A DIAGNOSTIC TROUBLE CODE (DTC) MAY BE SET INDICATING AN INTERNAL ISOLATION FAULT THAT WILL RENDER THE IGM INOPERABLE. Read More »
-
TSB #PB32S39803201609
THIS IS A PARTS BULLETIN: IF THE INVERTER GENERATOR MODULE (IGM) IS EXPOSED TO HIGH TEMPERATURES AND VIBRATION, A DIAGNOSTIC TROUBLE CODE (DTC) MAY BE SET INDICATING AN INTERNAL ISOLATION FAULT THAT WILL RENDER THE IGM INOPERABLE. Read More »
-
TSB #SPJ31352.1.0
Alternative solution when VIDA is unavailable or the Electronic Wiring Diagrams function in VIDA is unstable. Access by using the applicable URL. Read More »
-
TSB #TJ31423-11-0-201
This is a Technical Journal: Blown fuse, compressor - air suspension. Perform Total Upgrade, replace fuse and compressor according to VIDA. Read More »
-
TSB #TJ31423-11-0-201
This is a Technical Journal: Blown fuse, compressor - air suspension. Perform Total Upgrade, replace fuse and compressor according to VIDA. Read More »
-
TSB #TJ32033.1.0-2016
After using a voice command to adjust the climate, the buttons for ?Forward?, ?Back? and ?Confirm? on the audio switches on the right side of the steering wheel may not function (marked as ?1?, ?2?and ?3? in attachment). Read More »
-
TSB #TJ30499
This is a Technical Journal: This TJ is released to highlight the importance of not storing the remote control key close to objects that may shield radio communication between the remote control key and the car or could cause interference ... Read More »
-
TSB #TJ29012.6.0-2020
VOLVO CARS SERVICE AND PARTS BUSINESS Technical Journal TITLE : Leather dashboard , leather comes loose REF NO : ISSUING DEPARTMENT : CAR MARKET : United States and Canada TJ 29012 Technical Service PARTNER : ISSUE DATE : 3 US 7510 Volvo ... Read More »
-
TSB #TJ31216
Drive-E: Low oil level message in Driver Information Module (DIM) Read More »
-
TSB #TJ31754.1.0
This is a Technical Journal: If the customer experiences that the fuel gauge in the DIM is indicating zero but the distance to empty is still indicating some kilometers (miles), It is unlikely that the distance to empty indication is a ... Read More »
-
TSB #TJ30588
If Alarm Service Required message is shown in the DIM and DTC CEM-U132A96 is present, follow advice under Service. Perform Total Upgrade XC90 (Software Product 31483292). Read More »
-
TSB #TJ31295
This docuement is a Technical Journal: The infotainment system in the vehicle re-starts or reboots repeatedly while driving. Read More »
-
TSB #TJ31247
This document is a Technical Journal: If the ?Hybrid System Failure? message is shown in DIM ,with DTC IEM-P0A1B47 or IEM-P0A1B62, follow procedure under SERVICE. Read More »
-
TSB #TJ3667810
Recovering control modules stuck in ?not responding? Read More »
-
TSB #KC-99
Volvo Chassis 2008 And Up LED Headlight Conversion Programming Procedure Read More »
-
TSB #TJ 34647 6 0
Perform a software upgrade in accordance with TJ 31543. Read More »
-
TSB #TJ34803.2.0-2020
This is a Technical Journal: Title II-TPMS calibration after SW upgrade In the new SW, released May 2019, the picture in the Centre Display for I-TPMS is showing a "spinning wheel", while calibration is ongoing. Read More »
-
TSB #TJ35037.1.2-2020
This is a Technical Journal: Infotainment System Reboots Repeatedly after Software Download Read More »
-
TSB #SMB00-006-2020-0
This is a Service Manager Bulletin: Service 2.0 Software & Total Upgrade Reminder Read More »
-
TSB #SMB00-006-2020-0
This is a Service Manager Bulletin: Service 2.0 Software & Total Upgrade Reminder Read More »
-
TSB #TJ34647.4.0-2019
This is a Technical Journal: DIM message about parking brake. Perform software upgrade. Read More »
-
TSB #TJ35340.1.0-2019
This is a Technical Journal: "Ghost" DTCs set: SODL-U210052 and SODR-U210052 Read More »
-
TSB #SMB00 006 2019-0
Software Installation Policy changes. Read More »
-
TSB #TJ33931
software update available Read More »
-
TSB #SPJ34864 2 0-201
This is a Service Product Journal: Information Notice. We process the personal data that you provide in connection with the creation of your VIDA account. Read More »
-
TSB #SMB30-001-2019-0
This is a Service Managers Bulletin: Volvo Cars is constantly developing the in-car systems and the services offered to customers, so that their cars give them the best experience possible . Read More »
-
TSB #TJ33931b
SPA Hybrid Irregular electrical distance to empty after Software upgrade Read More »
-
TSB #TJ34141.1.0-2018
This is a Technical Journal: Performing a Total Upgrade, Service 2.0 or PDS Upgrade after the 2018 week 40 software release, will reset the sound settings back to default settings on the MY 2016 - 2018 vehicles listed above. Read More »
-
TSB #TJ33931c
SPA Hybrid Irregular electrical distance to empty after Software upgrade Read More »
-
TSB #TJ30816-2-0-2018
This is a Technical Journal: Unwanted call(s) come in through VOC system. If the above symptom(s) should occur, please perform a Total Upgrade Read More »
-
TSB #TJ30816-2-0-2018
This is a Technical Journal: Unwanted call(s) come in through VOC system. If the above symptom(s) should occur, please perform a Total Upgrade Read More »
-
TSB #TJ34013-1-2-2018
This is a Technical Journal: Vehicle Key Not Found Read More »
-
TSB #TJ34013-1-2-2018
This is a Technical Journal: Vehicle Key Not Found Read More »
-
TSB #TJ31543 4 6-2018
This is a Technical Journal: This Journal is a guide for performing Software Downloads. Service: *See guide updated Oct. 12, 2016 for relevant P5/SPA Software Download information: P5_SPA_SW_Guide. Read More »
-
TSB #TJ31543-4-6
This is a Technical Journal: This Journal is a guide for performing Software Downloads. Service: *See guide updated Oct. 12, 2016 for relevant P5/SPA Software Download information: P5_SPA_SW_Guide. Read More »
-
TSB #TJ33389-2-0
This is a Technical Journal: If the preconditioning timer function in the Volvo on call app does not work, but setting the calendar function in the car and direct start of the climate settings from the app does work, please follow the ... Read More »
-
TSB #SMB00-006-2018-0
Software Installation Policy changes. Read More »
-
TSB #SMB00-006C-2018-
Software Installation Policy changes - Canada Read More »
-
TSB #TJ33633-1-2-2018
This is a Technical Journal: No Internet Connection With Car Modem/"SIM Card Not Inserted" message. In order to restore the connectivity functions, the "Roaming" function must be activated in the vehicle menus. Read More »
-
TSB #SMB00-006C-2018-
Software Installation Policy changes - Canada Read More »
-
TSB #SMB00-006-2018-0
Software Installation Policy changes. Read More »
-
TSB #SMB00-006C-2018-
Software Installation Policy changes - Canada Read More »
-
TSB #SMB00-006C-2018-
Software Installation Policy changes - Canada Read More »
-
TSB #TJ33285-3-0-2018
This is a Technical Journal: DTC IHU-B156C8F sets incorrectly. For the cars in the header this DTC can be ignored as it doesn't affect any of the functions in the car. Read More »
-
TSB #TJ31543-4-5-2018
This is a Technical Journal: This Journal is a guide for performing Software Downloads. Service: *See guide updated Oct. 12, 2016 for relevant P5/SPA Software Download information: P5_SPA_SW_Guide. Read More »
-
TSB #SPJ33554-1-0-201
This is a Service Product Journal: Software Purchase Failed - General error occured - VDS / SPA / CMA cars. Download software fix Read More »
-
TSB #SPJ33143
This is a Service Product Journal: Windows 7: Unable to open Wiring diagrams Windows 10: VIDA will crash when trying to open wiring diagram Final Solution: The only solution that we are aware of is to uninstall Adobe SVG viewer. Read More »
-
TSB #TJ3085820-2017-0
VOLVO CARS SERVICE AND PARTS BUSINESS Technical Journal TITLE : DIM message ? BLIS system service required ? and DTC SOD U023292 REF NO : ISSUING DEPARTMENT : CAR MARKET : United States and Canada TJ 30858 Technical Service PARTNER : ... Read More »
-
TSB #TJ3129516-2017-0
the infotainment system in the vehicle restarts or reboots repeatedly while driving. When this happens the CCD and the center area of the DIM will go blank for a few moments and then start back up as if the vehicle has just been started up. Read More »
-
TSB #TJ32747.1.1
DIM = Driver's Information Module On May 8th, 2017 new DIM software was released that contained a graphic system check of the vehicle's Intellisafe systems. Read More »
-
TSB #TJ31543.4.4
This is a Technical Journal: This Journal is a guide for performing Software Downloads. Service: *See guide updated Oct. 12, 2016 for relevant P5/SPA Software Download information: P5_SPA_SW_Guide. Read More »
-
TSB #TJ31295.1.3-2017
the infotainment system in the vehicle restarts or reboots repeatedly while driving. When this happens the CCD and the center area of the DIM will go blank for a few moments and then start back up as if the vehicle has just been started up. Read More »
-
TSB #TJ32139.1.0-2017
This is a Technical Journal: Climate system, high fan speed noise. Customer may experience a high fan speed noise regardless of the fan speed selection. This may be due to accidentally touching the 2nd row display. Read More »
-
TSB #TJ32209.1.0-2016
This is a Technical Journal: Improved low fuel indication A more detailed low fuel indication can be added in the DIM (Driver Information Module). Read More »
-
TSB #TJ32162.1.0-2016
This is a Technical Journal: Low battery State of Charge due to FMDM disturbance. When viewing the Quiescient Current Statistics in VIDA, vehicles with a regular FMDM disturbance will often show a number of counts in the 400-800mA range. Read More »
-
TSB #TJ31938.2.0-2016
This is a Technical Journal: If the vehicle is turned off and restarted again within 1-10 minutes, the P-SIM may not be working. ?No connection to service? will then be shown in the Download Center. Read More »
-
TSB #TJ31220.1.4-2016
Low Battery message displayed in the DIM (Driver Information Module). Read More »
-
TSB #TJ31543
THIS IS A TECHNICAL JOURNAL: THIS JOURNAL IS A GUIDE FOR PERFORMING SOFTWARE DOWNLOADS. SERVICE: *SEE GUIDE UPDATED OCT. 12, 2016 FOR RELEVANT P5/SPA SOFTWARE DOWNLOAD INFORMATION: P5_SPA_SW_GUIDE. Read More »
-
TSB #TJ31999
THIS IS A TECHNICAL JOURNAL:IF IT IS NOT POSSIBLE TO SWITCH OFF THE RSI FUNCTION BY DEACTIVATING THE FUNCTION THRU RSI BUTTON AND/OR SPEED SIGN ASSIST BUTTON (MARKET DEPENDENT), AFTER VEHICLE IS UPGRADED TO NEW SOFTWARE , FOLLOW ATTACHED ... Read More »
-
TSB #SMB36-001
THIS IS A SERVICE MANAGER BULLETIN: DUE TO LONG SOFTWARE DOWNLOAD TIMES AND ADDITIONAL WORK CONNECTED TO THIS, THE FOLLOWING VST TIMES WILL BE TEMPORARILY INCREASED FOR SPA PLATFORM VEHICLES ONLY. Read More »
-
TSB #TJ2027820160906
THIS IS A TECHNICAL JOURNAL: IT IS PROVIDED AS A GUIDE FOR PERFORMING SOFTWARE DOWNLOADS. FOLLOW INSTRUCTIONS PROVIDED FOR PROPER SOFTWARE DOWNLOADS BY YEAR AND MODEL. Read More »
-
TSB #TJ31754.1.0
This is a Technical Journal: If the customer experiences that the fuel gauge in the DIM is indicating zero but the distance to empty is still indicating some kilometers (miles), It is unlikely that the distance to empty indication is a ... Read More »
-
TSB #TJ2753672
This document is a Technical Journal: Information about valid Software partnumbers to order and download Software for "PDS" Pre-Delivery Service Read More »
-
TSB #TJ31360.1.1
This TJ is only valid for SPA cars equipped with a CD player (also referred to as ODP or Optical Disc Player). Read More »
-
TSB #SPJ31628.7.0
VIDA users are not able to check Operations & Packages An error message will be shown saying "Database error. Please contact System Administrator" Read More »
-
TSB #SPJ31721.1.0
Below error message may be shown in VIDA when selecting the Software tab in VIDA. With this message, it will not be possible to purchase Software Products. "124 - Client ID is not registered" Read More »
-
TSB #SPJ31722.1.1
A new feature will be available in VIDA version 16.4 where by users will be automatically informed when their passwords are about to expire. The pop-up window example, in the attachment, will be shown 14 days prior to the expiraton date. Read More »
-
TSB #SPJ31352.1.0
Alternative solution when VIDA is unavailable or the Electronic Wiring Diagrams function in VIDA is unstable. Access by using the applicable URL. Read More »
-
TSB #TJ27536
Information about valid Software partnumbers to order and download Software for "PDS" Pre-Delivery Service Read More »
-
TSB #TJ30588
If Alarm Service Required message is shown in the DIM and DTC CEM-U132A96 is present, follow advice under Service. Perform Total Upgrade XC90 (Software Product 31483292). Read More »
-
TSB #TJ31569
This document is a Technical Journal: This software prevents the auto-close function from activating when the sunroof switch is pushed upward while the glass is in an open position. Read More »
-
TSB #SPJ3141020160408
THIS IS A SERVICE PRODUCT JOURNAL : WHEN PERFORMING SOFTWARE DOWNLOADS TO A VEHICLE THERE MIGHT BE AN UNHANDLED SCRIPT EXCEPTION OR ERROR MESSAGE. WE DON?T HAVE THE FULL SCOPE ON WHICH SOFTWARES ARE AFFECTED BY THIS. Read More »
-
TSB #SPJ31410
Unhandled script error in VIDA XC90(16-) Read More »
-
TSB #36376.4.0
This is a Technical Journal: SR PHEV Cell Module Replacement. Updated BECM software was released Read More »
-
TSB #35924.1.4
This is a Technical Journal: VIDA Main battery diagnostic - Prompted to charge battery a second time. Use had held tester. Read More »
-
TSB #TJ3566220
Headlamp condensation. Read More »
-
TSB #KC-99
Volvo Chassis 2008 And Up LED Headlight Conversion Programming Procedure Read More »
-
TSB #TJ31558.10.0-202
If the rear Parking Assistance System (PAS) is not working and there is a message in DIM about ?Parking Assistance System service required? displayed in DIM, then it is possible that there is water ingress into rear park assist sensors ... Read More »
-
TSB #TJ29818
If the vehicle is equipped with indirect tire pressure monitoring sensors (I-TPMS) (VDN codes: PU02, PU03, PU04), and there is a warning message in the DIM about Low tire pressure and DTC BCM-C007768, follow advice under Service. Read More »
-
TSB #TJ31295 1 8-2017
the infotainment system in the vehicle restarts or reboots repeatedly while driving. When this happens the CCD and the center area of the DIM will go blank for a few moments and then start back up as if the vehicle has just been started up. Read More »
-
TSB #TJ32791
XC90 lower battery range in DIM after SW update Read More »
-
TSB #TJ3658411
Left front LED flickers after turning car off Read More »
-
TSB #KC-99
Volvo Chassis 2008 And Up LED Headlight Conversion Programming Procedure Read More »
-
TSB #TJ35662.1.0-2020
This is a Technical Journal: Headlamp condensation - broken guide pin. Replace broken guide pin Read More »
-
TSB #QB:D39594
SUMMARY TO BE PROVIDED ON A FUTURE DATE. Read More »
-
TSB #TJ33183.7.0-2021
This is a Technical Journal: If a vehicle with panorama roof shows symptom of a rattling noise when opening, follow the description under Service. Read More »
-
TSB #TJ33183.6.0-2021
This is a Technical Journal: If a vehicle with panorama roof shows symptom of a rattling noise when opening, follow the description under Service. Read More »
-
TSB #TJ35507.5.0-2021
This is a Technical Journal: Outer rear view mirror glass incorrect position after reversing Read More »
-
TSB #TJ35507.4.0-2021
This is a Technical Journal: Outer rear view mirror glass incorrect position after reversing Read More »
-
TSB #TJ33183.5.0-2021
This is a Technical Journal: If a vehicle with panorama roof shows symptom of a rattling noise when opening, follow the description under Service. Read More »
-
TSB #TJ33183.4.0-2021
This is a Technical Journal: If a vehicle with panorama roof shows symptom of a rattling noise when opening, follow the description under Service. Read More »
-
TSB #TJ35583.1.1-2020
This is a Technical Journal: Panoramic sunroof, roller blind hanging loose Read More »
-
TSB #TJ33183.3.0-2020
This is a Technical Journal: If a vehicle with panorama roof shows symptom of a rattling noise when opening, follow the description under Service. Read More »
-
TSB #SMB00-444-2020-0
This is a Service Manager Bulletin: Windshield Cleaning Operation Service Interval Change. Will only be performed at 20k Read More »
-
TSB #PB36-066-2017-04
Please return stock of parts numbers 31674102, 31674103, 31674104, 31674106, Turn Signal Switch, Wiper Washer Switch to your servicing distribution center. Read More »
-
TSB #TJ30908.4.0-2017
This is a Technical Journal: If the vehicle shows a constant BLIS warning light without any objects in the blind spot, then this could be caused by a HW problem in the Side Object Detection radar (SODL/SODR). Read More »
-
TSB #TJ32366.1.1-2017
This is a Technical Journal: Title Windshield Wiper or Turn Signal messages A customer message may be displayed for Windshield Wiper or Turn Signal service even though the wipers and turn signals are working properly. Read More »
-
TSB #TJ 31272
XC90 Sunroof Cassette Rear Leak Sun/moon/convertible roof/Water leakage DESCRIPTION: If customer complaints of water leakage, and the diagnose shows that it is coming from the rear sunroof cassette, please follow advice under SERVICE. Read More »
-
TSB #SMB00-425-2017-0
Wiper blade replacements due to wear or a quantifiable manufacturing defect are covered under the Adjustment Coverage period for 12 months or 12,000 miles/20,000 kilometers, whichever occurs first. Read More »
-
TSB #SMB00-444-2020-0
This is a Service Manager Bulletin: Windshield Cleaning Operation Service Interval Change. Will only be performed at 20k Read More »
-
TSB #SMB84 001 2019-0
This is a Service Manager Bulletin: Windshield replacement products. Read More »
-
TSB #TJ34445.1.1-2019
This is a Technical Journal: Loss of rear door locks / window functions Read More »
-
TSB #TJ30762.2.0
This document is a Technical Journal: A rattling noise may occur while closing the front door with the window in down position. Only vehicles with non-laminated glass can be affected. Read More »
-
TSB #TJ36548
OHC replaced too often due to CEM U134187,download software prior replacement Read More »
-
TSB #TJ30621.1.1-2020
VOLVO CARS SERVICE AND PARTS BUSINESS Technical Journal TITLE : Sunroof shade hanging down REF NO : ISSUING DEPARTMENT : CAR MARKET : United States and Canada TJ 30621 Technical Service PARTNER : ISSUE DATE : 3 US 7510 Volvo Cars North ... Read More »
-
TSB #TJ35583.1.0-2020
This is a Technical Journal: Panoramic sunroof, roller blind hanging loose Read More »
-
TSB #R89702
VOLVO CAR SERVICE AND PARTS BUSINESS QUALITY BULLETIN TITLE : RECALL R89702 : PANORAMIC SUNROOF SWITCH SOFTWARE MODEL YEAR 2016 XC90 GROUP : CAT / NO : ISSUING DEPARTMENT : CAR MARKET : WARRANTY UNITED STATES AND CANADA 30 R89702 ... Read More »
-
TSB #R89702
This software prevents the auto-close function from activating when the sunroof switch is pushed upward while the glass is in an open position. Follow the below Technician Instructions for Recall R89702, Panoramic Sun Roof Switch SW. Read More »
-
TSB #TJ31569
This software prevents the auto-close function from activating when the sunroof switch is pushed upward while the glass is in an open position. Follow the below Technician Instructions for Recall R89702, Panoramic Sun Roof Switch SW. Read More »
-
TSB #TJ31569
This software prevents the auto-close function from activating when the sunroof switch is pushed upward while the glass is in an open position. Follow the below Technician Instructions for Recall R89702, Panoramic Sun Roof Switch SW. Read More »
-
TSB #TJ3127220160418
THIS IS A TECHNICAL JOURNAL : IF CUSTOMER COMPLAINTS OF WATER LEAKAGE, AND THE DIAGNOSE SHOWS THAT IT IS COMING FROM THE REAR SUNROOF CASSETTE, PLEASE FOLLOW ADVICE UNDER SERVICE. Read More »
-
TSB #TJ31272
XC90 Sunroof Cassette rear leak Read More »
-
TSB #TJ 31272
XC90 Sunroof Cassette Rear Leak Sun/moon/convertible roof/Water leakage DESCRIPTION: If customer complaints of water leakage, and the diagnose shows that it is coming from the rear sunroof cassette, please follow advice under SERVICE. Read More »
-
TSB #TJ33183.5.0-2021
This is a Technical Journal: If a vehicle with panorama roof shows symptom of a rattling noise when opening, follow the description under Service. Read More »
-
TSB #TJ35507.2.0-2020
This is a Technical Journal: Outer rear view mirror glass incorrect position after reversing Read More »
-
TSB #TJ31286.1.0
This is a Technical Journal: If a customer experience an incorrect ambient temperature reading in DIM or reduced A/C performance due to a defective ambient temp sensor, and the symptom is confirmed, replace the ambient temperature sensor ... Read More »
-
TSB #TJ25153.7.1-2016
This is a Technical Journal: Washer system layout for identifying leakage points REF NO : ISSUING DEPARTMENT : CAR MARKET : United States and Canada TJ 25153 Technical Service PARTNER : ISSUE DATE : STATUS DATE : 3 US 7510 Volvo Car USA ... Read More »
-
TSB #TJ25153.7.1-2016
This is a Technical Journal: Washer system layout for identifying leakage points REF NO : ISSUING DEPARTMENT : CAR MARKET : United States and Canada TJ 25153 Technical Service PARTNER : ISSUE DATE : STATUS DATE : 3 US 7510 Volvo Car USA ... Read More »
-
TSB #SMB87-001
Climate system heating performance. Read More »
-
TSB #TJ34551.1.1-2019
This is a Technical Journal: Rear Window Defrost will not Stay Activated. Total Upgrade should be used if there are any upgrades available. - Perform an IHU Reload Read More »
-
TSB #TJ32267.1.0-2017
This is a Technical Journal: Climate system, unusual noise from dashboard area. replace the heater core according to the attached instruction. Read More »
-
TSB #SMB00-325-2017-1
Service Manager Bulletin TITLE : Service Action Notification Re - Mails GROUP : NO : ISSUING DEPARTMENT : CAR MARKET : Product Safety & Compliance United States and Canada 00 325 REFERENCE BULLETINS : DATE : SMB00 - 323 and SMB00 - 323A ... Read More »
-
TSB #ST-211-2017-01-2
VOLVO CARS SERVICE AND PARTS BUSINESS Special Tools Bulletin TITLE : Newsletter 64 : Mandatory Tools NO : DATE : CAR MARKET : United States and 211 YEAR MONTH DAY Page 1 of 13 Canada 2015 05 04 All tools have been classified as required , ... Read More »
-
TSB #PB87-R89707-2016
This is a Parts Bulletin: Condensation water, transferred through the air conditioning drain hose, may leak into the passenger compartment due to incorrect installation during vehicle assembly. Read More »
-
TSB #TJ31120
Check Engine light is on, ECM-P017100 Read More »
-
TSB #SMB00-325-2017-1
Service Manager Bulletin TITLE : Service Action Notification Re - Mails GROUP : NO : ISSUING DEPARTMENT : CAR MARKET : Product Safety & Compliance United States and Canada 00 325 REFERENCE BULLETINS : DATE : SMB00 - 323 and SMB00 - 323A ... Read More »
-
TSB #TJ32985.5.0-2020
This is a Technical Journal: Seat belt front, may not retract fully Read More »
-
TSB #SMB88-001A-2018-
This bulletin is a service manager bulletin. Seat Belt Extender. Read More »
-
TSB #SMB88-001A-2018-
This bulletin is a service manager bulletin. Seat Belt Extender. Read More »
-
TSB #SMB88-001A-2018-
This bulletin is a service manager bulletin. Seat Belt Extender. Read More »
-
TSB #SMB88-001A
This bulletin is a service manager bulletin. Seat Belt Extender. Read More »
-
TSB #PB88-R89708-2016
Volvo Car USA LLC and Volvo Car Canada LTD (Volvo) on behalf of Volvo Car Group has decided to launch Recall R89708 on certain model year 2016 - 2017 XC90, S90, XC60, V60CC, V60, S60, S60CC, S60 Inscription vehicles. Read More »
-
TSB #TJ32985.4.0-2020
This is a Technical Journal: Seat belt front, may not retract fully Read More »
-
TSB #TJ33616-1-1-2018
This is a Technical Journal: If the front seat belt catch makes noise when moving against the seat upholstery, follow instruction under Service. Add adhesive tape. Read More »
-
TSB #TJ33616-1-1-2018
This is a Technical Journal: If the front seat belt catch makes noise when moving against the seat upholstery, follow instruction under Service. Add adhesive tape. Read More »
-
TSB #TJ33616-1-1-2018
This is a Technical Journal: If the front seat belt catch makes noise when moving against the seat upholstery, follow instruction under Service. Add adhesive tape. Read More »
-
TSB #SMB00-325-2017-1
Service Manager Bulletin TITLE : Service Action Notification Re - Mails GROUP : NO : ISSUING DEPARTMENT : CAR MARKET : Product Safety & Compliance United States and Canada 00 325 REFERENCE BULLETINS : DATE : SMB00 - 323 and SMB00 - 323A ... Read More »
-
TSB #TJ35459.1.1
Tailgate Operation. Read More »
-
TSB #TJ33183.4.0-2021
This is a Technical Journal: If a vehicle with panorama roof shows symptom of a rattling noise when opening, follow the description under Service. Read More »
-
TSB #SPJ34549 2 0-201
This is a Service Product Journal: Template Bumperskin Towbar Hitch, a template needs to be used to make the cut. Read More »
-
TSB #TJ34502.1.0-2019
This is a Technical Journal: Tailgate opening by foot movement detection Read More »
-
TSB #TJ33389 2 0-2018
This is a Technical Journal: If the preconditioning timer function in the Volvo on call app does not work, but setting the calendar function in the car and direct start of the climate settings from the app does work, please follow the ... Read More »
-
TSB #TJ19245114
VOLVO CARS SERVICE AND PARTS BUSINESS Technical Journal TITLE : Vehicle type and platform identification REF NO : ISSUING DEPARTMENT : CAR MARKET : United States and Canada TJ 19245 Technical Service PARTNER : ISSUE DATE : 3 US 7510 Volvo ... Read More »
-
TSB #TJ31542.7.0-2017
This is a Technical Journal: Water may accumulate on the rear door sill. Water may come out of the lower edge of the rear doors when opening the rear doors. remove weather strip and add sealing tape Read More »
-
TSB #TJ29012.5.0-2017
VOLVO CARS SERVICE AND PARTS BUSINESS Technical Journal TITLE : Leather dashboard , leather comes loose REF NO : ISSUING DEPARTMENT : CAR MARKET : United States and Canada TJ 29012 Technical Service PARTNER : ISSUE DATE : 3 US 7510 Volvo ... Read More »
-
TSB #TJ31542.1.3-2017
This is a Technical Journal: Water may accumulate on the rear door sill. Water may come out of the lower edge of the rear doors when opening the rear doors. remove weather strip and add sealing tape Read More »
-
TSB #TJ20402.3.4-2017
Technical Journal TITLE : The Error Frame Finder (EFF) can be an aid in fault tracing intermittent CAN network problems by providing a visible indication of error frames that are being transmitted on the network when the fault becomes ... Read More »
-
TSB #TJ31542.1.2-2017
This is a Technical Journal: Water may accumulate on the rear door sill. Water may come out of the lower edge of the rear doors when opening the rear doors. remove weather strip and add sealing tape Read More »
-
TSB #TJ32183.1.3-2017
This is a Technical Journal: Service Action S89807 Volvo Car USA LLC and Volvo Car of Canada Ltd (Volvo) on behalf of Volvo Car Corporation, has decided to launch Service Campaign S89807 on certain model year 2016 ? 2017 XC90 and S90 ... Read More »
-
TSB #S89807-2017-02-0
This is a quality bulletin. Volvo Car USA LLC and Volvo Car of Canada Ltd (Volvo) on behalf of Volvo Car Corporation, has decided to launch Service Campaign S89807 on certain model year 2016 ? 2017 XC90 and S90 vehicles. Read More »
-
TSB #TJ31218.1.2-2017
This is a Technical Journal: A new front license plate frame was introduced on MY16 XC90 2015w45. The H frame P/N (part number) 31391625 is no longer needed.Install front license plate using four (4) Wurth screws P/N 02151012. Read More »
-
TSB #TJ32183.1.2-2017
This is a Technical Journal: Service Action S89807 Volvo Car USA LLC and Volvo Car of Canada Ltd (Volvo) on behalf of Volvo Car Corporation, has decided to launch Service Campaign S89807 on certain model year 2016 ? 2017 XC90 and S90 ... Read More »
-
TSB #TJ31542.1.1-2017
This is a Technical Journal: Water may accumulate on the rear door sill. Water may come out of the lower edge of the rear doors when opening the rear doors. remove weather strip and add sealing tape Read More »
-
TSB #TJ32183.1.1-2016
Technical Journal TITLE: Service Action S89807: Exterior door handle tape Read More »
-
TSB #PB82-005-2018-03
Please return stock of part numbers 39849933, 39849999 fender flare to your servicing distribution center. Read More »
-
TSB #TJ32040.1.0-2016
This is a Technical Journal: Title Dash absorber insulation, Damp or bad smell Water seepage from sealing to Climate unit in plenum area. Read More »
-
TSB #TJ3203740
Front door decor panel, noise. Read More »
-
TSB #TJ34445.1.1-2019
This is a Technical Journal: Loss of rear door locks / window functions Read More »
-
TSB #TJ34262-1-0-2018
This is a Technical Journal: Wind noise, front and/or rear door area Read More »
-
TSB #TJ34262-1-0-2018
This is a Technical Journal: Wind noise, front and/or rear door area Read More »
-
TSB #TJ34262-1-0-2018
This is a Technical Journal: Wind noise, front and/or rear door area Read More »
-
TSB #TJ32381
Rattling noise when closing front door. Read More »
-
TSB #TJ32728 1 1-2017
This is a Technical Journal: Water may accumulate on the front door sill it may come out of the lower edge of the front doors when opening. Remove weather strip add tape and install new weather strip. Read More »
-
TSB #TJ32728
Front side door, water intrusion Read More »
-
TSB #TJ32500.1.0-2017
This is a Technical Journal: Inner door handle, clicking noise. Apply grease P/N 31437986 Read More »
-
TSB #TJ32183.1.1-2016
Technical Journal TITLE: Service Action S89807: Exterior door handle tape Read More »
-
TSB #TJ30762.2.0
This document is a Technical Journal: A rattling noise may occur while closing the front door with the window in down position. Only vehicles with non-laminated glass can be affected. Read More »
-
TSB #TJ31611
If a front door deco panel is replaced, it may be hard to mount the new one on the door panel. If the steel clips on the new deco panel are black, remove the steel clip It will sit tight with the remaining clips. Read More »
-
TSB #TJ31542
Water may accumulate on the rear door sill. Water may come out of the lower edge of the rear doors when opening the rear doors. Read More »
-
TSB #TJ 31036
Door handle, does not fully retract. Doors/Exterior door handle problems If the side door handle does not fully retract follow advice under ?Service?. Read More »
-
TSB #TJ34262-1-0-2018
This is a Technical Journal: Wind noise, front and/or rear door area Read More »
-
TSB #S89807-2016-12-2
This is a quality bulletin. Volvo Car USA LLC and Volvo Car of Canada Ltd (Volvo) on behalf of Volvo Car Corporation, has decided to launch Service Campaign S89807 on certain model year 2016 ? 2017 XC90 and S90 vehicles. Read More »
-
TSB #PB83-S89807-2016
Volvo has identified the painted surface under the exterior door handles may become scratched by the handles. The corrective action is add tape under all four (4) exterior door handles per TJ 32183. Read More »
-
TSB #TJ31036
Door handle, does not fully retract Read More »
-
TSB #TJ35459.1.1
Tailgate Operation. Read More »
-
TSB #TJ34502.1.0-2019
This is a Technical Journal: Tailgate opening by foot movement detection Read More »
-
TSB #TJ30808
POT not operating when using tailgate handle Read More »
-
TSB #TJ33284
This is a Technical Journal: Floor hatch compartment, hard to open or handle too loose. Follow repair instruction. Read More »
-
TSB #TJ30662.1.4-2016
This is a Technical Journal: XC90 Software Upgrades Available REF NO : ISSUING DEPARTMENT : CAR MARKET : United States and Canada TJ 30662 Technical Service PARTNER : ISSUE DATE : STATUS DATE : 3 US 7510 Volvo Cars North America 2015 - 10 ... Read More »
-
TSB #TJ32010.1.0-2016
It may be possible for the rear door lock switch to get stuck in the speaker grille. This can lead to a drained battery. Applies only for cars with Premium or High Performance stereo. Read More »
-
TSB #SMB00-325-2017-1
Service Manager Bulletin TITLE : Service Action Notification Re - Mails GROUP : NO : ISSUING DEPARTMENT : CAR MARKET : Product Safety & Compliance United States and Canada 00 325 REFERENCE BULLETINS : DATE : SMB00 - 323 and SMB00 - 323A ... Read More »
-
TSB #TJ28941-4-0-2019
This is a Technical Journal: When sensitive information, like vehicle speed, brake usage, etc. (customer behavoiur information) of a car is required from Volvo Car Corporation from external sources, either of these two documents should be ... Read More »
-
TSB #TJ33867.1.3-2021
This is a Technical Journal: we find with automobiles. Radial force variation ( RFV ) is a condition where excessive run out will create the same symptom as an unbalanced tire. Read More »
-
TSB #TJ3480310-2019-0
This is a Technical Journal: Title II-TPMS calibration after SW upgrade In the new SW, released May 2019, the picture in the Centre Display for I-TPMS is showing a "spinning wheel", while calibration is ongoing. Read More »
-
TSB #TJ3386430-2019-0
This is a Technical Journal: It may happen that after a software download, the TPMS light is flashing and DTC VDDM-U24004A, "ECU Software. System internal failures" is set. Read More »
-
TSB #ST-227-2018-08-1
Road Force wheel balancing is the proper tool for diagnosing and repairing such issues and all of our retailers need to be prepared for these issues. Read More »
-
TSB #TJ33867-1-1-2018
This is a Technical Journal: we find with automobiles. Radial force variation ( RFV ) is a condition where excessive run out will create the same symptom as an unbalanced tire. Read More »
-
TSB #TJ33867-1-1-2018
This is a Technical Journal: we find with automobiles. Radial force variation ( RFV ) is a condition where excessive run out will create the same symptom as an unbalanced tire. Read More »
-
TSB #TJ32161.1
This is a Technical Journal: Vibrations due to wheels and tire uniformity / force variation. Before carrying out this TJ, always start with TJ 20803 to sort out if the problem is related to driveline or wheels. Read More »
-
TSB #TJ32161.4.0-2017
This is a Technical Journal: Vibrations due to wheels and tire uniformity / force variation. Before carrying out this TJ, always start with TJ 20803 to sort out if the problem is related to driveline or wheels. Read More »
-
TSB #TJ32161 3 0-2017
This is a Technical Journal: Vibrations due to wheels and tire uniformity / force variation. Before carrying out this TJ, always start with TJ 20803 to sort out if the problem is related to driveline or wheels. Read More »
-
TSB #TJ32161.1.0-2017
This is a Technical Journal: Vibrations due to wheels and tire uniformity / force variation. Before carrying out this TJ, always start with TJ 20803 to sort out if the problem is related to driveline or wheels. Read More »
-
TSB #TJ31398.5.0-2021
This is a Technical Journal: D-TPMS, Service required and DTC's Read More »
-
TSB #TJ34803.2.0-2020
This is a Technical Journal: Title II-TPMS calibration after SW upgrade In the new SW, released May 2019, the picture in the Centre Display for I-TPMS is showing a "spinning wheel", while calibration is ongoing. Read More »
-
TSB #TJ29818 9 0-2019
This is a Technical Journal: If the vehicle is equipped with indirect tire pressure monitoring sensors (I-TPMS) (VDN codes: PU02, PU03, PU04), and there is a warning message in the DIM about Low tire pressure and DTC BCM-C007768, follow ... Read More »
-
TSB #TJ3480310-2019-0
This is a Technical Journal: Title II-TPMS calibration after SW upgrade In the new SW, released May 2019, the picture in the Centre Display for I-TPMS is showing a "spinning wheel", while calibration is ongoing. Read More »
-
TSB #TJ3386430-2019-0
This is a Technical Journal: It may happen that after a software download, the TPMS light is flashing and DTC VDDM-U24004A, "ECU Software. System internal failures" is set. Read More »
-
TSB #TJ29818
This is a Technical Journal: If the vehicle is equipped with indirect tire pressure monitoring sensors (I-TPMS) (VDN codes: PU02, PU03, PU04), and there is a warning message in the DIM about Low tire pressure and DTC BCM-C007768, follow ... Read More »
-
TSB #TJ29818
This is a Technical Journal: If the vehicle is equipped with indirect tire pressure monitoring sensors (I-TPMS) (VDN codes: PU02, PU03, PU04), and there is a warning message in the DIM about Low tire pressure and DTC BCM-C007768, follow ... Read More »
-
TSB #TJ29818
This is a Technical Journal: If the vehicle is equipped with indirect tire pressure monitoring sensors (I-TPMS) (VDN codes: PU02, PU03, PU04), and there is a warning message in the DIM about Low tire pressure and DTC BCM-C007768, follow ... Read More »
-
TSB #TJ29818
This is a Technical Journal: If the vehicle is equipped with indirect tire pressure monitoring sensors (I-TPMS) (VDN codes: PU02, PU03, PU04), and there is a warning message in the DIM about Low tire pressure and DTC BCM-C007768, follow ... Read More »
-
TSB #ST19420160422
THIS IS A SPECIAL TOOL : SUITABLE FOR ALL VEHICLE MODELS EQUIPPED WITH TPMS (TIRE PRESSURE MONITOR SYSTEM). THE TOOL AUTOMATICALLY TESTS SCHRAEDER AND CONTINENTAL TPMS SENSOR. Read More »
-
TSB #TJ 31408
2016 XC90 D-TPMS, Low tire pressure warning Tires/Slow leaks 21 Warning lights and chimes/Tire pressure monitoring, Low tire pressure warning If the vehicle is equipped with direct tire pressure monitoring sensors (D-TPMS) and there is ... Read More »
-
TSB #TJ31408
2016 XC90 D-TPMS, Low tire pressure warning. Read More »
-
TSB #TJ 31398
2016 XC90 D-TPMS, Service required and DTC?s Warning lights and chimes/Tire pressure monitoring, Service required warning TPMS troubleshooting CSC = LI Tyre x1 replace (only use if removing tyre to inspect TPMS sensor brand) Sensor ... Read More »
-
TSB #TJ31398
2016 XC90 D-TPMS, service required and DTC's. Read More »
-
TSB #TJ33867.1.3-2021
This is a Technical Journal: we find with automobiles. Radial force variation ( RFV ) is a condition where excessive run out will create the same symptom as an unbalanced tire. Read More »
-
TSB #PB77-006-2019-05
Winter Wheel Applications including rim sizes, steel wheel parts numbers and wheel cover part numbers Read More »
-
TSB #PB77-006-2019-02
Winter Wheel Applications including rim sizes, steel wheel parts numbers and wheel cover part numbers Read More »
-
TSB #PB77-006-2019-02
Winter Wheel Applications including rim sizes, steel wheel parts numbers and wheel cover part numbers Read More »
-
TSB #ST-227-2018-08-1
Road Force wheel balancing is the proper tool for diagnosing and repairing such issues and all of our retailers need to be prepared for these issues. Read More »
-
TSB #ST-227-2018-08-1
Road Force wheel balancing is the proper tool for diagnosing and repairing such issues and all of our retailers need to be prepared for these issues. Read More »
-
TSB #TJ32161.6
This is a Technical Journal: Vibrations due to wheels and tire uniformity/force variation. Before carrying out this TJ, always start with TJ 20803 to sort out if the problem is related to driveline or wheels. Read More »
-
TSB #TJ32161.1
This is a Technical Journal: Vibrations due to wheels and tire uniformity / force variation. Before carrying out this TJ, always start with TJ 20803 to sort out if the problem is related to driveline or wheels. Read More »
-
TSB #PB77-017-2018-03
This is a Parts Bulletin: Wheel Cross Reference, used to assist in identifying the correct spare replacement wheel, by stamping, name and size. Read More »
-
TSB #PB77-017-2018-03
This is a Parts Bulletin: Wheel Cross Reference, used to assist in identifying the correct spare replacement wheel, by stamping, name and size. Read More »
-
TSB #TJ32161 3 0-2017
This is a Technical Journal: Vibrations due to wheels and tire uniformity / force variation. Before carrying out this TJ, always start with TJ 20803 to sort out if the problem is related to driveline or wheels. Read More »
-
TSB #TJ32161 3 0-2017
This is a Technical Journal: Vibrations due to wheels and tire uniformity / force variation. Before carrying out this TJ, always start with TJ 20803 to sort out if the problem is related to driveline or wheels. Read More »
-
TSB #PB77-017-2017-06
This is a Parts Bulletin: Wheel Cross Reference, used to assist in identifying the correct spare replacement wheel, by stamping, name and size. Read More »
-
TSB #PB77-017.1
This is a Parts Bulletin: Wheel Cross Reference, used to assist in identifying the correct spare replacement wheel, by stamping, name and size. Read More »
-
TSB #PB77-006
Winter Wheel Applications including rim sizes, steel wheel parts numbers and wheel cover part numbers Read More »
-
TSB #PB77-017
This is a Parts Bulletin: Wheel Cross Reference, used to assist in identifying the correct spare replacement wheel, by stamping, name and size. Read More »
-
TSB #PB36-065-2017-03
Please return stock of part number 31674105 Lever Hub to your servicing distribution center. Read More »
-
TSB #TJ32161.2.0-2017
This is a Technical Journal: Vibrations due to wheels and tire uniformity / force variation. Before carrying out this TJ, always start with TJ 20803 to sort out if the problem is related to driveline or wheels. Read More »
-
TSB #TJ32163.1.0-2017
This is a Technical Journal:Climate system, protective wheel caps falling off. Replace with new caps on wheel screws Read More »
-
TSB #TJ32161.2.0-2017
This is a Technical Journal: Vibrations due to wheels and tire uniformity / force variation. Before carrying out this TJ, always start with TJ 20803 to sort out if the problem is related to driveline or wheels. Read More »
-
TSB #TJ32161.1.0-2017
This is a Technical Journal: Vibrations due to wheels and tire uniformity / force variation. Before carrying out this TJ, always start with TJ 20803 to sort out if the problem is related to driveline or wheels. Read More »
-
TSB #TJ31292.1.1-2017
This is a Technical Journal: 1.Remove oil pump from AOC (Active On demand Coupling)and inspect the strainer. (See att.) 2.Clean strainer with lint-free cloth, do not use any cleaning liquids (this can contaminate the oil) 3. Read More »
-
TSB #PB77-006-2017-01
Winter Wheel Applications including rim sizes, steel wheel parts numbers and wheel cover part numbers Read More »
-
TSB #PB77-017-2016-12
This is a Parts Bulletin: Wheel Cross Reference, used to assist in identifying the correct spare replacement wheel, by stamping, name and size. Read More »
-
TSB #PB77-017-2016-12
This is a Parts Bulletin: Wheel Cross Reference, used to assist in identifying the correct spare replacement wheel, by stamping, name and size. Read More »
-
TSB #PB77-017-2016-12
This is a Parts Bulletin: Wheel Cross Reference, used to assist in identifying the correct spare replacement wheel, by stamping, name and size. Read More »
-
TSB #TJ33617.2.0-2020
This is a Technical Journal: Front seat heater, function control. If not working check the heating grid wiring. Read More »
-
TSB #TJ32025.5.0-2019
This is a Technical Journal: Seat hard to push back, second row seat (7 seater) Func Group 8531 In some cars one or more of the following may appear: - Outer seat in second row is hard to move back after entrance to third row. Read More »
-
TSB #TJ33617
This is a Technical Journal: Front seat heater, function control. If not working check the heating grid wiring. Read More »
-
TSB #TJ32508 3 0-2017
This is a Technical Journal: Front seat backrest, too much play. The locking retainer/washer must not be tight against the seat frame. It must have a play of 1,0mm +/-0,5mm. Read More »
-
TSB #TJ32025
This is a Technical Journal: Seat hard to push back, second row seat (7 seater) Func Group 8531 In some cars one or more of the following may appear: - Outer seat in second row is hard to move back after entrance to third row. Read More »
-
TSB #TJ30962 2 0-2017
VOLVO CARS SERVICE AND PARTS BUSINESS Technical Journal TITLE : Front seat back uneven , lumbar support loose REF NO : ISSUING DEPARTMENT : CAR MARKET : United States and Canada TJ 30962 Technical Service PARTNER : ISSUE DATE : STATUS ... Read More »
-
TSB #TJ32025
Seat hard to push back, second row seat (7 seater) Read More »
-
TSB #TJ3250821-2017-0
This is a Technical Journal: Front seat backrest, too much play. The locking retainer/washer must not be tight against the seat frame. It must have a play of 1,0mm +/-0,5mm. Read More »
-
TSB #TJ30599.3.2-2017
When driving on rough roads, a creaking/squeaking noise can be heard from the second row seats. Add felt tape on the top half of the striker pins, according to attached files. * Use new tape, (Service kit) p/n 31447976. Read More »
-
TSB #TJ32005.1.1-2016
This is a Technical Journal: Leather seats, improvements on wrinkles and wear. Always replace both together, seat cushion upholstery and seat cushion foam . Read More »
-
TSB #TJ32508 3 0-2017
This is a Technical Journal: Front seat backrest, too much play. The locking retainer/washer must not be tight against the seat frame. It must have a play of 1,0mm +/-0,5mm. Read More »
-
TSB #TJ33617.2.1-2021
This is a Technical Journal: Front seat heater, function control. If not working check the heating grid wiring. Read More »
-
TSB #TJ33617.2.0-2020
This is a Technical Journal: Front seat heater, function control. If not working check the heating grid wiring. Read More »
-
TSB #TJ33617
This is a Technical Journal: Front seat heater, function control. If not working check the heating grid wiring. Read More »
-
TSB #TJ30961.4.0-2016
This is a Technical Journal: The front passenger seat heater may not start or turns itself off after a few minutes of driving. A new IHU (Integrated Head Unit) software with changed functionality has been introduced in week 46, 2016. Read More »
-
TSB #TJ32508 3 0-2017
This is a Technical Journal: Front seat backrest, too much play. The locking retainer/washer must not be tight against the seat frame. It must have a play of 1,0mm +/-0,5mm. Read More »
-
TSB #TJ30599.6.0
When driving on rough roads, a creaking/squeaking noise can be heard from the second row seats. Add felt tape on the top half of the striker pins, according to attached files. * Use new tape, (Service kit) p/n 31447976. Read More »
-
TSB #TJ30599.3.1-2016
When driving on rough roads, a creaking/squeaking noise can be heard from the second row seats. Add felt tape on the top half of the striker pins, according to attached files. * Use new tape, (Service kit) p/n 31447976. Read More »
-
TSB #TJ32025.1.0-2016
Seat hard to push back, second row seat (7 seater) Read More »
-
TSB #TJ31913102016092
THIS IS A TECHNICAL JOURNAL: CUSTOMER MAY EXPERIENCE A NOISE IN SECOND ROW SEAT WHILE DRIVING. THIS APPLIES ONLY FOR 7-SEATED CARS. SERVICE: REMOVE ALL 6 END CAPS AS DESCRIBED IN ATTACHED PICTURE. Read More »
-
TSB #TJ30599
When driving on rough roads, a creaking/squeaking noise can be heard from the second row seats. Add felt tape on the top half of the striker pins, according to attached files. * Use new tape, (Service kit) p/n 31447976. Read More »
-
TSB #P10064-2021-03-1
Volvo Car USA LLC and Volvo Car Canada LTD (Volvo) on behalf of Volvo Car Corporation, has voluntarily decided to extend warranty coverage on the Rear Suspension Air Compressor for certain model year 2017-2020 S90 Series, 2017-2020 V90 ... Read More »
-
TSB #TJ32978 2 0-2017
This is a Technical Journal: *Added VST Operation No. If the vehicle is equipped with air suspension and if customer is complaining over a knock/rattle/clatter noise from the front suspension when driving on roughroads or over a road ... Read More »
-
TSB #TJ32958 1 1-2017
This is a Technical Journal: A whining or rattling sound may appear when revving up the engine. ( see attached sample files ). Read More »
-
TSB #C00009
COMPLIMENTARY UPGRADE C00009 DESCRIPTION. Read More »
-
TSB #TJ3155880-2019-0
If the rear Parking Assistance System (PAS) is not working and there is a message in DIM about ?Parking Assistance System service required? displayed in DIM, then it is possible that there is water ingress into rear park assist sensors ... Read More »
-
TSB #TJ30908302016092
THIS IS A TECHNICAL JOURNAL: IF THE VEHICLE SHOWS A CONSTANT BLIS WARNING LIGHT WITHOUT ANY OBJECTS IN THE BLIND SPOT, THEN THIS COULD BE CAUSED BY A HW PROBLEM IN THE SIDE OBJECT DETECTION RADAR (SODL/SODR). Read More »
-
TSB #TJ31558
If the rear Parking Assistance System (PAS) is not working and there is a message in DIM about ?Parking Assistance System service required? displayed in DIM, then it is possible that there is wateringress into rear park assist sensors and ... Read More »
-
TSB #TJ3155880-2019-0
If the rear Parking Assistance System (PAS) is not working and there is a message in DIM about ?Parking Assistance System service required? displayed in DIM, then it is possible that there is water ingress into rear park assist sensors ... Read More »
-
TSB #TJ29818
If the vehicle is equipped with indirect tire pressure monitoring sensors (I-TPMS) (VDN codes: PU02, PU03, PU04), and there is a warning message in the DIM about Low tire pressure and DTC BCM-C007768, follow advice under Service. Read More »
-
TSB #TJ30908.4.0-2017
This is a Technical Journal: If the vehicle shows a constant BLIS warning light without any objects in the blind spot, then this could be caused by a HW problem in the Side Object Detection radar (SODL/SODR). Read More »
-
TSB #TJ31558
If the rear Parking Assistance System (PAS) is not working and there is a message in DIM about ?Parking Assistance System service required? displayed in DIM, then it is possible that there is wateringress into rear park assist sensors and ... Read More »
-
TSB #PB36-061-2016-12
Parts Bulletin TITLE: Parts Return: 31419709 Sensor Read More »
-
TSB #TJ33183.7.0-2021
This is a Technical Journal: If a vehicle with panorama roof shows symptom of a rattling noise when opening, follow the description under Service. Read More »
-
TSB #TJ33183.6.0-2021
This is a Technical Journal: If a vehicle with panorama roof shows symptom of a rattling noise when opening, follow the description under Service. Read More »
-
TSB #TJ31007
Squealing noise from rear brakes at low speed Read More »
-
TSB #TJ32978 2 0-2017
This is a Technical Journal: *Added VST Operation No. If the vehicle is equipped with air suspension and if customer is complaining over a knock/rattle/clatter noise from the front suspension when driving on roughroads or over a road ... Read More »
-
TSB #TJ32958 1 1-2017
This is a Technical Journal: A whining or rattling sound may appear when revving up the engine. ( see attached sample files ). Read More »
-
TSB #TJ30908.4.0-2017
This is a Technical Journal: If the vehicle shows a constant BLIS warning light without any objects in the blind spot, then this could be caused by a HW problem in the Side Object Detection radar (SODL/SODR). Read More »
-
TSB #TJ30934.9.1-2016
This is a Technical Journal: * If squealing noise occurs from front brakes on cars built before chassis number 040328, then Replace front discs according to VIDA, the new brake discs have changed metal composition in order to reduce ... Read More »
-
TSB #TJ31007
If symptom of noise occurs from the rear brakes during braking follow advice under service. New brake pads have been implemented for service and production , 2015week34. Read More »
-
TSB #TJ35902.1.1-2021
This is a Technical Journal: Connectivity services activation - PSIM issues Read More »
-
TSB #PB36-061-2016-12
Parts Bulletin TITLE: Parts Return: 31419709 Sensor Read More »
-
TSB #C10006
XC90 Courtesy upgrade C10006 Read More »
-
TSB #P10186
EXTENDED WARRANTY. Read More »
-
TSB #P10186
Extended Warranty P10186: VEP4 Oil Consumption Replace Read More »
-
TSB #P10207
Extended Warranty P10207: VEP4 Oil Consumption Test Read More »
-
TSB #35912.5.0
This is a Technical Journal: AC evaporator repair, additional parts needed. Add resister in line jumper cable. Read More »
-
TSB #TJ19245
Vehicle type and platform identification Read More »
-
TSB #TJ36455
Volvo Cars App Android, no climate setting button Read More »
-
TSB #TJ30382
Programming of User defined Service Interval, new XC90 MY2016 Read More »
-
TSB #TJ35902
Connectivity services activation - PSIM issues Read More »
-
TSB #356EN01
VIDA QR Scanner Mobile App Read More »
-
TSB #Service Manager
Shipping and Handling of Volvo Lithium-ion 48V Mild Hybrid Battery to Global Battery Solutions (GBS) Read More »
-
TSB #ST-248-2021-04-1
Volvo Car USA LLC and Volvo Car Canada LTD (Volvo) on behalf of Volvo Car Corporation, has voluntarily decided to extend warranty coverage on the Rear Suspension Air Compressor for certain model year 2017-2020 S90 Series, 2017-2020 V90 ... Read More »
-
TSB #P10064-2021-04-1
Volvo Car USA LLC and Volvo Car Canada LTD (Volvo) on behalf of Volvo Car Corporation, has voluntarily decided to extend warranty coverage on the Rear Suspension Air Compressor for certain model year 2017-2020 S90 Series, 2017-2020 V90 ... Read More »
-
TSB #TJ35912.1.0-2021
This is a Technical Journal: AC evaporator repair, additional parts needed Read More »
-
TSB #SMB00-288-2021-0
Volvo?s Warranty Department tracks Retailer warranty spending by utilizing the Warranty Retailer Counseling Process (WRCP). The WRCP is used to gauge individual retailer performance on objective measures over time. Read More »
-
TSB #TJ33183.5.0-2021
This is a Technical Journal: If a vehicle with panorama roof shows symptom of a rattling noise when opening, follow the description under Service. Read More »
-
TSB #TJ33183.4.0-2021
This is a Technical Journal: If a vehicle with panorama roof shows symptom of a rattling noise when opening, follow the description under Service. Read More »
-
TSB #TJ33617.2.1-2021
This is a Technical Journal: Front seat heater, function control. If not working check the heating grid wiring. Read More »
-
TSB #TJ33031.5.0-2021
This is a Technical Journal: If remote control key is not detected by the car and shows message in DIM "Car key not found" or if functions such as lock/unlock are not working, please follow advice for detecting ... Read More »
-
TSB #TJ32985.5.0-2020
This is a Technical Journal: Seat belt front, may not retract fully Read More »
-
TSB #SMB00-015-2020-1
This is a Service Manager Bulletin : Volvo Electric Vehicle Technical De-Energization Permit to Work Form Read More »
-
TSB #TJ34803.2.0-2020
This is a Technical Journal: Title II-TPMS calibration after SW upgrade In the new SW, released May 2019, the picture in the Centre Display for I-TPMS is showing a "spinning wheel", while calibration is ongoing. Read More »
-
TSB #TJ35662.1.0-2020
This is a Technical Journal: Headlamp condensation - broken guide pin. Replace broken guide pin Read More »
-
TSB #ST-001-2020-09-1
Mandatory Tool List bulletin: Volvo mandatory Special Tools are necessary for technicians to properly diagnose and repair Volvo cars. Read More »
-
TSB #TJ34241.2.1-2020
This is a Technical Journal: 12V battery message and DTC CEM-B129F96 Read More »
-
TSB #SMB39-015-2020-0
This is a Service Manager Bulletin: Prior Approval for VCM Replacement Read More »
-
TSB #TJ20803.21.1-202
This is a Technical Journal: In case of complaint of Noise, some "tools" have been created to help you to do a better and more precise fault tracing Read More »
-
TSB #SMB00-321-2020-0
Volvo Complimentary Factory Scheduled Maintenance 'FSM330' MY2013 and later. Factory Scheduled Maintenance up to the first 3 years or 36,000 miles (whichever comes first) as recommended in the Volvo Warranty and Maintenance Information ... Read More »
-
TSB #SJ1000167-2020-0
This is a Service Journal: Coolant Filling Equipment Tool Read More »
-
TSB #ST-001-2020-01-2
Mandatory Tool List bulletin: Volvo mandatory Special Tools are necessary for technicians to properly diagnose and repair Volvo cars. Read More »
-
TSB #TJ34948.2.0-2020
This is a Technical Journal: IHU, screech noise from sound system when ending phone call. Read More »
-
TSB #ST-236-2020-01-2
Jason Guidi Manager - Warranty , Regulatory & Compliance November 23 , 2015 To : All U.S . and Canadian Volvo Retailers Subject : XC90 Courtesy Upgrade C10006 Volvo Cars of North America , LLC . Read More »
-
TSB #C10006-2020-01-2
Jason Guidi Manager - Warranty , Regulatory & Compliance November 23 , 2015 To : All U.S . and Canadian Volvo Retailers Subject : XC90 Courtesy Upgrade C10006 Volvo Cars of North America , LLC . Read More »
-
TSB #TJ32033.5.0-2020
This is a Technical Journal: Audio switches on right side of steering wheel, intermittent no function. Read More »
-
TSB #TJ20803.21.0-202
This is a Technical Journal: In case of complaint of Noise, some "tools" have been created to help you to do a better and more precise fault tracing Read More »
-
TSB #TJ35058.1.3-2019
This is a Technical Journal: Sensus/Sensus Connect Navigation Base Map Versions Read More »
-
TSB #TJ35340.1.0-2019
This is a Technical Journal: "Ghost" DTCs set: SODL-U210052 and SODR-U210052 Read More »
-
TSB #TJ33211.7.1-2019
This is a Technical Journal: The voice control system on the above referenced models is continuously being improved. Read More »
-
TSB #TJ35058.1.2-2019
This is a Technical Journal: Sensus/Sensus Connect Navigation Base Map Versions Read More »
-
TSB #SMB00-438-2019-1
This is a Service Manager Bulletin: Technician Skillset Requirments Read More »
-
TSB #TJ33211.7.0-2019
This is a Technical Journal: The voice control system on the above referenced models is continuously being improved. Read More »
-
TSB #ST-001-2019-10-1
Mandatory Tool List bulletin: Volvo mandatory Special Tools are necessary for technicians to properly diagnose and repair Volvo cars. Read More »
-
TSB #TJ35058.1.1-2019
This is a Technical Journal: Sensus/Sensus Connect Navigation Base Map Versions Read More »
-
TSB #TJ34222 1 4 2019
Model year 2016 XC90s were built with a single USB port which is not capable of supporting Android Auto functionality. Read More »
-
TSB #TJ32469 5 0 2019
This is a Technical Journal: Gear shift lever inoperable Read More »
-
TSB #TJ34650 1 0-2019
This is a Technical Journal: SPA Condensation water drops in around pedals area Read More »
-
TSB #TJ32040212019-05
This is a Technical Journal: Title Dash absorber insulation, Damp or bad smell Water seepage from sealing to Climate unit in plenum area. Read More »
-
TSB #SPJ3475710-2019-
This is a Service Product Journal: Unable to set SPA/CMA vehicle into programming mode - P2P Read More »
-
TSB #SPJ3479010-2019-
This is a Service Product Journal: VIDA VOC Access Functionality and Instruction Read More »
-
TSB #SPJ3478010-2019-
This is a Service Product Journal: VIDA VOC Access and Functionality Read More »
-
TSB #S79852-2019-05-0
Volvo Car USA LLC and Volvo Car Canada LTD (Volvo) on behalf of Volvo Car Corporation, have decided to launch Service Action S79852 on certain model year 2016 XC90 vehicles equipped with air suspension. Read More »
-
TSB #TJ3416511-2019-0
This is a Technical Journal: No VIDA communication with vehicle Read More »
-
TSB #TJ3321123-2019-0
This is a Technical Journal: The voice control system on the above referenced models is continuously being improved. Read More »
-
TSB #ST-001-2019-03-0
Mandatory Tool List bulletin: Volvo mandatory Special Tools are necessary for technicians to properly diagnose and repair Volvo cars. Read More »
-
TSB #ST-231-2019-02-1
This is a Special Tool Bulletin: Newsletter 81 Mandatory Tools Read More »
-
TSB #ST-231-2019-02-1
This is a Special Tool Bulletin: Newsletter 81 Mandatory Tools Read More »
-
TSB #PB77-006-2019-02
Winter Wheel Applications including rim sizes, steel wheel parts numbers and wheel cover part numbers Read More »
-
TSB #SMB00-437-2019-0
This is a Service Manager Bulletin: Volvo Special Tool Warranty Coverage and Claims Process Read More »
-
TSB #SMB00-437-2019-0
This is a Service Manager Bulletin: Volvo Special Tool Warranty Coverage and Claims Process Read More »
-
TSB #TJ33165.4.0-2019
This is a Technical Journal: Ghost DTC set, VCM-B15F855, CEM-B158151 Read More »
-
TSB #TJ31423-11-0-201
This is a Technical Journal: Blown fuse, compressor - air suspension. Perform Total Upgrade, replace fuse and compressor according to VIDA. Read More »
-
TSB #TJ34262-1-0-2018
This is a Technical Journal: Wind noise, front and/or rear door area Read More »
-
TSB #TJ34141.1.0-2018
This is a Technical Journal: Performing a Total Upgrade, Service 2.0 or PDS Upgrade after the 2018 week 40 software release, will reset the sound settings back to default settings on the MY 2016 - 2018 vehicles listed above. Read More »
-
TSB #TJ34222.1.1-2018
This is a Technical Journal: Addition of USB Hub and Android Auto Read More »
-
TSB #SMB00321
To further enhance the customer?s Volvo ownership experience, Volvo Car USA, LLC offers the MY 2013 and later Volvo Complimentary Factory Scheduled Maintenance Program. Read More »
-
TSB #TJ33284
Floor hatch compartment, hard to open or handle too loose Read More »
-
TSB #TJ34021
SiriusXM Radio inop or No Sound on SAT Source Read More »
-
TSB #PB85-056-2018-08
Please return stock of Heaters 32206448, 32206450 to your servicing distribution center. Read More »
-
TSB #PB85-056-2018-08
Please return stock of Heaters 32206448, 32206450 to your servicing distribution center. Read More »
-
TSB #ST-002-2018-08-1
This is a Service Manager Bulletin. This bulletin is a list of equipment recommended by Volvo to it's dealer or any shop maintaining or repairing Volvo's. Read More »
-
TSB #TJ30816-2-0-2018
This is a Technical Journal: Unwanted call(s) come in through VOC system. If the above symptom(s) should occur, please perform a Total Upgrade Read More »
-
TSB #ST-002-2018-08-1
This is a Service Manager Bulletin. This bulletin is a list of equipment recommended by Volvo to it's dealer or any shop maintaining or repairing Volvo's. Read More »
-
TSB #ST-227-2018-08-1
Road Force wheel balancing is the proper tool for diagnosing and repairing such issues and all of our retailers need to be prepared for these issues. Read More »
-
TSB #ST-227-2018-08-1
Road Force wheel balancing is the proper tool for diagnosing and repairing such issues and all of our retailers need to be prepared for these issues. Read More »
-
TSB #TJ34013-1-2-2018
This is a Technical Journal: Vehicle Key Not Found Read More »
-
TSB #TJ34013-1-2-2018
This is a Technical Journal: Vehicle Key Not Found Read More »
-
TSB #TJ33284
This is a Technical Journal: Floor hatch compartment, hard to open or handle too loose. Follow repair instruction. Read More »
-
TSB #ST002
This is a Service Manager Bulletin. This bulletin is a list of equipment recommended by Volvo to it's dealer or any shop maintaining or repairing Volvo's. Read More »
-
TSB #ST-228
This is a Special Tool Bulletin: Kits 33300313 and 33300315 Read More »
-
TSB #TJ31423 6 0-2018
This is a Technical Journal: Blown fuse, compressor - air suspension. Perform Total Upgrade, replace fuse and compressor according to VIDA. Read More »
-
TSB #TJ31543-4-6
This is a Technical Journal: This Journal is a guide for performing Software Downloads. Service: *See guide updated Oct. 12, 2016 for relevant P5/SPA Software Download information: P5_SPA_SW_Guide. Read More »
-
TSB #TJ33389-2-0
This is a Technical Journal: If the preconditioning timer function in the Volvo on call app does not work, but setting the calendar function in the car and direct start of the climate settings from the app does work, please follow the ... Read More »
-
TSB #TJ19245114
VOLVO CARS SERVICE AND PARTS BUSINESS Technical Journal TITLE : Vehicle type and platform identification REF NO : ISSUING DEPARTMENT : CAR MARKET : United States and Canada TJ 19245 Technical Service PARTNER : ISSUE DATE : 3 US 7510 Volvo ... Read More »
-
TSB #TJ3321120
This is a Technical Journal: The voice control system on the above referenced models is continuously being improved. Read More »
-
TSB #TJ19245114
VOLVO CARS SERVICE AND PARTS BUSINESS Technical Journal TITLE : Vehicle type and platform identification REF NO : ISSUING DEPARTMENT : CAR MARKET : United States and Canada TJ 19245 Technical Service PARTNER : ISSUE DATE : 3 US 7510 Volvo ... Read More »
-
TSB #TJ33442d
Left engine pad click sound Read More »
-
TSB #PB82-005-2018-03
Please return stock of part numbers 39849933, 39849999 fender flare to your servicing distribution center. Read More »
-
TSB #PB85-055-2018-03
Please return stock of part number 39825191 side panel to your servicing distribution center. Read More »
-
TSB #TJ33633-1-2-2018
This is a Technical Journal: No Internet Connection With Car Modem/"SIM Card Not Inserted" message. In order to restore the connectivity functions, the "Roaming" function must be activated in the vehicle menus. Read More »
-
TSB #TJ20803-17-0-201
This is a Technical Journal: In case of complaint of Noise, some "tools" have been created to help you to do a better and more precise fault tracing Read More »
-
TSB #PB26-036-2018-03
Please return stock of part number 31686821 bleeder hose to your servicing distribution center. Read More »
-
TSB #TJ31423-4-0-2018
This is a Technical Journal: Blown fuse, compressor - air suspension. Perform Total Upgrade, replace fuse and compressor according to VIDA. Read More »
-
TSB #TJ32469-3-0-2018
This is a Technical Journal: Gear shift lever inoperable Read More »
-
TSB #SPJ33554-1-0-201
This is a Service Product Journal: Software Purchase Failed - General error occured - VDS / SPA / CMA cars. Download software fix Read More »
-
TSB #TJ32469-3-0-2018
This is a Technical Journal: Gear shift lever inoperable Read More »
-
TSB #TJ33442c
Left engine pad click sound Read More »
-
TSB #TJ32747.1.2-2017
DIM = Driver's Information Module On May 8th, 2017 new DIM software was released that contained a graphic system check of the vehicle's Intellisafe systems. Read More »
-
TSB #TJ30499
This is a Technical Journal: This TJ is released to highlight the importance of not storing the remote control key close to objects that may shield radio communication between the remote control key and the car or could cause interference ... Read More »
-
TSB #TJ30499
This is a Technical Journal: This TJ is released to highlight the importance of not storing the remote control key close to objects that may shield radio communication between the remote control key and the car or could cause interference ... Read More »
-
TSB #PB28-S29842-1
Volvo Car USA LLC on behalf of Volvo Car Corporation, has decided to launch Service Action S29842 on certain model year 2015 ? 2016 XC60, S60, V60, S80, XC70 & 2016 XC90 vehicles. Read More »
-
TSB #ST-111A
MIDTRONICS PSC-550S and PSC-700 VEHICLE POWER SUPPLY information Read More »
-
TSB #PB39-026
Please return stock of 31659854 charger to your servicing distribution center. Read More »
-
TSB #PB28-S29842-1
Volvo Car USA LLC on behalf of Volvo Car Corporation, has decided to launch Service Action S29842 on certain model year 2015 ? 2016 XC60, S60, V60, S80, XC70 & 2016 XC90 vehicles. Read More »
-
TSB #PB39-026
Please return stock of 31659854 charger to your servicing distribution center. Read More »
-
TSB #PB28-S29842
Volvo Car USA LLC on behalf of Volvo Car Corporation, has decided to launch Service Action S29842 on certain model year 2015 ? 2016 XC60, S60, V60, S80, XC70 & 2016 XC90 vehicles. Read More »
-
TSB #SPJ33152
This is a Service Product Journal: Read More »
-
TSB #SPJ33152
This is a Service Product Journal: Read More »
-
TSB #TJ29131 7 0-2017
This is a Technical Journal: Customer may experience a low oil level warning in DIM and /or oil leakage from the engine. Read More »
-
TSB #TJ20803.14.0-201
This is a Technical Journal: In case of complaint of Noise, some "tools" have been created to help you to do a better and more precise fault tracing Read More »
-
TSB #SMB00-325-2017-1
Service Manager Bulletin TITLE : Service Action Notification Re - Mails GROUP : NO : ISSUING DEPARTMENT : CAR MARKET : Product Safety & Compliance United States and Canada 00 325 REFERENCE BULLETINS : DATE : SMB00 - 323 and SMB00 - 323A ... Read More »
-
TSB #TJ32267 2 0-2017
This is a Technical Journal: Climate system, unusual noise from dashboard area. replace the heater core according to the attached instruction. Read More »
-
TSB #TJ32185
Voice recognition database upgrades Read More »
-
TSB #TJ31698
Difficulty to add/program remote key, Read More »
-
TSB #TJ3235310-2017-0
This is a Technical Journal: Customer may hear a high frequency noise from the climate system shortly after starting the car. Read More »
-
TSB #SMB00-354-2017-0
Warranty, customer pay and/or internal repairs performed must be verified by a punched time flag on the back of the Repair Order hard copy. Read More »
-
TSB #ST-221-2017-06-0
Latest mandatory tool bulletin. Read More »
-
TSB #ST-221
Latest mandatory tool bulletin. Read More »
-
TSB #PB77-006
Winter Wheel Applications including rim sizes, steel wheel parts numbers and wheel cover part numbers Read More »
-
TSB #TJ32033.2.0
This is a Technical Journal: Audio switches on right side of steering wheel, intermittent no function. Read More »
-
TSB #SMB00-006-2017-0
Software Installation Policy changes. Read More »
-
TSB #SMB39-014-2017-0
This is a Service Manager Bulletin: It is in support of Technical Journal 32714 Sensus Infotainment Interface Changes, May 2017 Read More »
-
TSB #PB21-047-2017-05
Please return stock of part number 31460615 tooth belt kit to your servicing distribution center. Read More »
-
TSB #TJ31542.7.0-2017
This is a Technical Journal: Water may accumulate on the rear door sill. Water may come out of the lower edge of the rear doors when opening the rear doors. remove weather strip and add sealing tape Read More »
-
TSB #PB89-026-2017-04
Please return stock of part number 31664288 Decal Set to your servicing distribution center. Read More »
-
TSB #TJ32633.1.0-2017
This is a Technical Journal: In-car apps not working after app version upgrade Read More »
-
TSB #SPJ32587.2.0-201
This is a Service Product Journal: VIDA will not support Windows 8.1 after June 30th 2017 Read More »
-
TSB #PB85-002-2017-04
Please return stock of 39843523, 39843524, 39843525, 39843526 covers to your servicing distribution center. Read More »
-
TSB #PB21-046-2017-04
Please return stock of 31430070 service kit to your servicing distribution center. Read More »
-
TSB #SPJ32507-2017-04
This is a Service Product Journal: Network card Intel I219-LM causing communication problems with XC90/S90/V90 Read More »
-
TSB #SMB00-004-2017-0
This is a Service Manager Bulletin: Factory Scheduled Maintenance menu. Read More »
-
TSB #SMB00-342C-2017-
VOLVO CARS SERVICE AND PARTS BUSINESS Service Manager Bulletin TITLE : Volvo Lifetime Replacement Parts & Labour Warranty GROUP : NO : ISSUING DEPARTMENT : CAR MARKET : Warranty Canada 00 342C REFERENCE BULLETINS : DATE : YEAR MONTH DAY ... Read More »
-
TSB #SMB00-342-2017-0
VOLVO CARS SERVICE AND PARTS BUSINESS Service Manager Bulletin TITLE : The Volvo Replacement Part Lifetime Warranty GROUP : NO : ISSUING DEPARTMENT : CAR MARKET : Warranty United States 00 342 REFERENCE BULLETINS : DATE : YEAR MONTH DAY ... Read More »
-
TSB #PB85-001-2017-03
Please return stock of part number 31447976 Service Kit to your servicing distribution center. Read More »
-
TSB #SMB00-425-2017-0
Wiper blade replacements due to wear or a quantifiable manufacturing defect are covered under the Adjustment Coverage period for 12 months or 12,000 miles/20,000 kilometers, whichever occurs first. Read More »
-
TSB #TJ29012.5.0-2017
VOLVO CARS SERVICE AND PARTS BUSINESS Technical Journal TITLE : Leather dashboard , leather comes loose REF NO : ISSUING DEPARTMENT : CAR MARKET : United States and Canada TJ 29012 Technical Service PARTNER : ISSUE DATE : 3 US 7510 Volvo ... Read More »
-
TSB #TJ31542.1.3-2017
This is a Technical Journal: Water may accumulate on the rear door sill. Water may come out of the lower edge of the rear doors when opening the rear doors. remove weather strip and add sealing tape Read More »
-
TSB #ST-219-2017-02-2
Please produce a Special Tool Bulletin using the attached draft copy. Read More »
-
TSB #PB87-025-2017-02
Please return stock of part numbers 31390488, 31390489, 31455693, 31455694 Draining hose to you servicing distribution center. Read More »
-
TSB #TJ32044.4.1-2017
This is a Technical Journal: SPA IHU LOG Read More »
-
TSB #TJ31295.1.5-2017
the infotainment system in the vehicle restarts or reboots repeatedly while driving. When this happens the CCD and the center area of the DIM will go blank for a few moments and then start back up as if the vehicle has just been started up. Read More »
-
TSB #TJ31542.1.2-2017
This is a Technical Journal: Water may accumulate on the rear door sill. Water may come out of the lower edge of the rear doors when opening the rear doors. remove weather strip and add sealing tape Read More »
-
TSB #TJ31218.1.3-2017
This is a Technical Journal: A new front license plate frame was introduced on MY16 XC90 2015w45. The H frame P/N (part number) 31391625 is no longer needed.Install front license plate using four (4) Wurth screws P/N 02151012. Read More »
-
TSB #PB36-064-2017-02
Please return stock of part number 31419660 Shell to your servicing distribution center. Read More »
-
TSB #TJ32044.4.0-2017
This is a Technical Journal: SPA IHU LOG Read More »
-
TSB #TJ31295.1.4-2017
the infotainment system in the vehicle restarts or reboots repeatedly while driving. When this happens the CCD and the center area of the DIM will go blank for a few moments and then start back up as if the vehicle has just been started up. Read More »
-
TSB #SMB00-003-2017-0
This is a Service Manager Bulletin: Service Scheduling system enhancements. Improving Service Action/Recall scheduling. Read More »
-
TSB #TJ32183.1.3-2017
This is a Technical Journal: Service Action S89807 Volvo Car USA LLC and Volvo Car of Canada Ltd (Volvo) on behalf of Volvo Car Corporation, has decided to launch Service Campaign S89807 on certain model year 2016 ? 2017 XC90 and S90 ... Read More »
-
TSB #S89807-2017-02-0
This is a quality bulletin. Volvo Car USA LLC and Volvo Car of Canada Ltd (Volvo) on behalf of Volvo Car Corporation, has decided to launch Service Campaign S89807 on certain model year 2016 ? 2017 XC90 and S90 vehicles. Read More »
-
TSB #TJ31218.1.2-2017
This is a Technical Journal: A new front license plate frame was introduced on MY16 XC90 2015w45. The H frame P/N (part number) 31391625 is no longer needed.Install front license plate using four (4) Wurth screws P/N 02151012. Read More »
-
TSB #TJ29131.6.0-2017
This is a Technical Journal: Customer may experience a low oil level warning in DIM and /or oil leakage from the engine. Read More »
-
TSB #TJ29131.5.0-2017
This is a Technical Journal: Customer may experience a low oil level warning in DIM and /or oil leakage from the engine. Read More »
-
TSB #TJ31295.1.3-2017
the infotainment system in the vehicle restarts or reboots repeatedly while driving. When this happens the CCD and the center area of the DIM will go blank for a few moments and then start back up as if the vehicle has just been started up. Read More »
-
TSB #TJ31292.1.1-2017
This is a Technical Journal: 1.Remove oil pump from AOC (Active On demand Coupling)and inspect the strainer. (See att.) 2.Clean strainer with lint-free cloth, do not use any cleaning liquids (this can contaminate the oil) 3. Read More »
-
TSB #PB77-006-2017-01
Winter Wheel Applications including rim sizes, steel wheel parts numbers and wheel cover part numbers Read More »
-
TSB #ST-211-2017-01-2
VOLVO CARS SERVICE AND PARTS BUSINESS Special Tools Bulletin TITLE : Newsletter 64 : Mandatory Tools NO : DATE : CAR MARKET : United States and 211 YEAR MONTH DAY Page 1 of 13 Canada 2015 05 04 All tools have been classified as required , ... Read More »
-
TSB #TJ31218.1.1-2017
This is a Technical Journal: A new front license plate frame was introduced on MY16 XC90 2015w45. The H frame P/N (part number) 31391625 is no longer needed.Install front license plate using four (4) Wurth screws P/N 02151012. Read More »
-
TSB #PB36-062-2017-01
Please return stock of part numbers 31419911, 31419918 Remote Control and 31439211, 31439212 Shell to your servicing distribution center. Read More »
-
TSB #TJ32183.1.2-2017
This is a Technical Journal: Service Action S89807 Volvo Car USA LLC and Volvo Car of Canada Ltd (Volvo) on behalf of Volvo Car Corporation, has decided to launch Service Campaign S89807 on certain model year 2016 ? 2017 XC90 and S90 ... Read More »
-
TSB #TJ30794.1.0-2017
This is a Technical Journal: New Remote Controls and Shells for XC90/S90 The remote control shell fastening concept has been changed to solve issues with the shells coming loose. Read More »
-
TSB #SMB00-199-2017-0
This is a Service Manager Bulletin: The online bookstore, www.volvotechinfo.com, serves Volvo Retailers, employees, Independent Repairers and customers throughout the United States and Canada by providing easy order-access to service, ... Read More »
-
TSB #TJ31542.1.1-2017
This is a Technical Journal: Water may accumulate on the rear door sill. Water may come out of the lower edge of the rear doors when opening the rear doors. remove weather strip and add sealing tape Read More »
-
TSB #ST-186-2017-01-0
Title : No . Page Volvo Special Tool 186 1 of 1 Cabinet Car Market : SPECIAL United States , Canada TOOLS Date : YEAR MONTH DAY BULLETIN 2012 02 02 Take Your Special Tool Storage to the Next Level Maintain Your Parts & Service Department ... Read More »
-
TSB #PB87-R89707-2016
This is a Parts Bulletin: Condensation water, transferred through the air conditioning drain hose, may leak into the passenger compartment due to incorrect installation during vehicle assembly. Read More »
-
TSB #TJ30646.4.0-2016
This is a Technical Journal: Title Graphic HUD may loose height adjustment Head Up Display HUD/Does not work Under some conditions, the height adjustment for the Head Up Display (HUD) returns to its default (full "up") setting at a ... Read More »
-
TSB #TJ25153.7.1-2016
This is a Technical Journal: Washer system layout for identifying leakage points REF NO : ISSUING DEPARTMENT : CAR MARKET : United States and Canada TJ 25153 Technical Service PARTNER : ISSUE DATE : STATUS DATE : 3 US 7510 Volvo Car USA ... Read More »
-
TSB #TJ31007.8.1-2016
This is a Technical Journal: If symptom of noise occurs from the rear brakes during braking follow advice under service. New brake pads have been implemented for service and production , 2015week34. Read More »
-
TSB #TJ30961.4.0-2016
This is a Technical Journal: The front passenger seat heater may not start or turns itself off after a few minutes of driving. A new IHU (Integrated Head Unit) software with changed functionality has been introduced in week 46, 2016. Read More »
-
TSB #TJ32005.1.1-2016
This is a Technical Journal: Leather seats, improvements on wrinkles and wear. Always replace both together, seat cushion upholstery and seat cushion foam . Read More »
-
TSB #PB23-004-2016-12
Please return stock of 31478161 insert, 31669071 Filler Pipe to your servicing distribution center. Read More »
-
TSB #TJ31863.3.0-2016
This is a Technical Journal: * New VCM software release date CCD = Center Console Display DIM = Driver Information Module VCM = Vehicle Connectivity Master After upgrading an XC90 with the previous Total Upgrade software package, the ... Read More »
-
TSB #TJ32004.1.0-2016
This is a Technical Journal: The Remote Control slider button is now available as a spare part. If the slider button is missing or damaged, there is no need to replace the entire remote control. Read More »
-
TSB #TJ29122.3.0-2016
This is a Technical Journal: The front park assist sensor bracket may come loose from the lower grill. The clamping force on the bracket in the lower grill may be too low. Read More »
-
TSB #PB77-017-2016-12
This is a Parts Bulletin: Wheel Cross Reference, used to assist in identifying the correct spare replacement wheel, by stamping, name and size. Read More »
-
TSB #TJ32025.1.0-2016
Seat hard to push back, second row seat (7 seater) Read More »
-
TSB #R89707-2016-12-2
Quality Bulletin TITLE: Recall R89707: Air Conditioning Drain Hose Model Year 2016 - 2017 XC90, 2017 S90 Read More »
-
TSB #PB88-R89708-2016
Volvo Car USA LLC and Volvo Car Canada LTD (Volvo) on behalf of Volvo Car Group has decided to launch Recall R89708 on certain model year 2016 - 2017 XC90, S90, XC60, V60CC, V60, S60, S60CC, S60 Inscription vehicles. Read More »
-
TSB #TJ30934.9.0
If squealing noise occurs from front brakes, then follow the instruction under Service. Read More »
-
TSB #R89702
VOLVO CAR SERVICE AND PARTS BUSINESS QUALITY BULLETIN TITLE : RECALL R89702 : PANORAMIC SUNROOF SWITCH SOFTWARE MODEL YEAR 2016 XC90 GROUP : CAT / NO : ISSUING DEPARTMENT : CAR MARKET : WARRANTY UNITED STATES AND CANADA 30 R89702 ... Read More »
-
TSB #SMB00-339
THIS IS A SERVICE MANAGER BULLETIN: THIS PROGRAM WILL NOW PROVIDE VOLVO RETAILERS ADDITIONAL LATITUDE, TO PROACTIVELY ADDRESS NON-WARRANTY CUSTOMER CONCERNS IN AN EXPEDITIOUS MANNER. Read More »
-
TSB #SPJ31342
THIS IS A SERVICE PRODUCT JOURNAL: ATTACHED YOU FIND THE NEW RESCUE INFORMATION IN MOST LANGUAGES AS A PDF-FILE. MORE DETAILED INFORMATION CAN BE FOUND AT WWW.MODITECH. Read More »
-
TSB #R89707-2016-11-1
Volvo Car USA LLC and Volvo Car Canada LTD (Volvo) on behalf of Volvo Car Group has decided to launch Recall R89707 on model year 2016 & 2017 XC90 & S90 vehicles. Read More »
-
TSB #SMB17-2017A
VOLVO CARS SERVICE AND PARTS BUSINESS SERVICE MANAGER BULLETIN TITLE : RETAIL CAR DELIVERY PROCESS ALL MY 2016 S60 , V60 , XC60 , XC70 AND S80 GROUP : NO:ISSUING DEPARTMENT : CAR MARKET : UNITED STATES AND CANADA 17 2016A SERVICE ... Read More »
-
TSB #TJ30825202016092
THIS IS A TECHNICAL JOURNAL: SOME CUSTOMERS MAY EXPERIENCE THAT THE FRONT LID ON CENTER CONSOLE MAY COME LOOSE OR GET STUCK. IF THE LID IS NOT SCRATCHED OR DAMAGED, IT CAN BE REINSTALLED. USE ATTACHED INSTRUCTIONS. Read More »
-
TSB #SMB0007120160907
THIS IS A SERVICE MANAGER BULLETIN: OCCASIONALLY, CUSTOMERS REQUEST FINANCIAL ASSISTANCE WHEN THE NEW CAR LIMITED WARRANTY, CPO LIMITED WARRANTY AND/OR THE VIP EXTENDED WARRANTY DOES NOT APPLY. Read More »
-
TSB #ST21720160901
SPECIAL TOOL BULLETIN: VOLVO MANDATORY SPECIAL TOOLS ARE NECESSARY FOR TECHNICIAN TO PROPERLY DIAGNOSE AND REPAIR VOLVO CARS. Read More »
-
TSB #SPJ3176020
This document is a Service Product Journal: Memory used for VIDA is not fully optimized and below examples of symptoms might therefore occur. VIDA will run slow after some time. VIDA might freeze. Certain operations might stop working. Read More »
-
TSB #TJ3138510
This document is a Technical Journal: In the event of a damaged floor harness, Instead of replacing terminals, a floor harness can be repaired according to the method in VIDA under Bulletins/ Product fix/Special tools Bulletins/3 ... Read More »
-
TSB #TJ20803.9.0
In case of complaint of Noise, some "tools" have been created to help you to do a better and more precise fault tracing Read More »
-
TSB #TJ31319
*No Description Read More »
-
TSB #TJ31535
If you need to perform a tuner replacement on any vehicle that is factory equipped with SiriusXM satellite radio, please follow the step by step instructions. Read More »
-
TSB #ST21520160422
THIS IS A SPECIAL TOOL : NEWSLETTER 69 Read More »
-
TSB #TJ3099120160419
THIS IS A TECHNICAL JOURNAL : BEGINNING NOVEMBER 23RD 2015, THE XC90 COURTESY UPGRADE (QBC-10006) MUST BE PERFORMED ON ALL VEHICLES PRIOR TO STRUCTURE WEEK 2015W46 BEFORE DOWNLOADING ANY OTHER SOFTWARE, INCLUDING PRE DELIVERY SERVICE ... Read More »
-
TSB #TJ3127220160418
THIS IS A TECHNICAL JOURNAL : IF CUSTOMER COMPLAINTS OF WATER LEAKAGE, AND THE DIAGNOSE SHOWS THAT IT IS COMING FROM THE REAR SUNROOF CASSETTE, PLEASE FOLLOW ADVICE UNDER SERVICE. Read More »
-
TSB #TJ31272
XC90 Sunroof Cassette rear leak Read More »
-
TSB #SMB0032120160411
THIS IS A SERVICE MANAGER BULLETIN : TO FURTHER ENHANCE THE CUSTOMER?S VOLVO OWNERSHIP EXPERIENCE, VOLVO CAR USA, LLC ANNOUNCES THE MY 2013 ? MY2016 VOLVO COMPLIMENTARY FACTORY SCHEDULED MAINTENANCE PROGRAM USA. Read More »
-
TSB #SMB0034920160411
THIS IS A SERVICE MANAGER BULLETIN : TO FURTHER ENHANCE THE VOLVO OWNERSHIP EXPERIENCE, VOLVO CAR CANADA LIMITED OFFERED FACTORY SCHEDULED MAINTENANCE (FSM) ON CERTAIN MY14, 15 AND 16 VEHICLES. Read More »
-
TSB #SMB0034020160411
THIS IS A SERVICE MANAGER BULLETIN : TO FURTHER ENHANCE THE VOLVO?S OWNERSHIP EXPERIENCE, VOLVO CAR CANADA LIMITED IS OFFERING THE VOLVO PREPAID MAINTENANCE (VPM) PROGRAM. Read More »
-
TSB #SMB0032120160408
THIS IS A SERVICE MANAGER BULLETIN : TO FURTHER ENHANCE THE CUSTOMER?S VOLVO OWNERSHIP EXPERIENCE, VOLVO CAR USA, LLC ANNOUNCES THE MY 2013 ? MY2016 VOLVO COMPLIMENTARY FACTORY SCHEDULED MAINTENANCE PROGRAM USA. Read More »
-
TSB #Service Manager
ICUP/Google Built-In Diagnostic Operations Read More »
-
TSB #TJ 35978 1 0
New Software Products (SP) have been developed to convert a Care Key to a standard key. Read More »
-
TSB #TJ20803.20.1-201
This is a Technical Journal: In case of complaint of Noise, some "tools" have been created to help you to do a better and more precise fault tracing Read More »
-
TSB #TJ34222 1 4 2019
Model year 2016 XC90s were built with a single USB port which is not capable of supporting Android Auto functionality. Read More »
-
TSB #TJ34222 1 3 2019
This is a Technical Journal: Addition of USB Hub and Android Auto Read More »
-
TSB #TJ30816-2-0-2018
This is a Technical Journal: Unwanted call(s) come in through VOC system. If the above symptom(s) should occur, please perform a Total Upgrade Read More »
-
TSB #TJ33389-2-0
This is a Technical Journal: If the preconditioning timer function in the Volvo on call app does not work, but setting the calendar function in the car and direct start of the climate settings from the app does work, please follow the ... Read More »
-
TSB #TJ3321120
This is a Technical Journal: The voice control system on the above referenced models is continuously being improved. Read More »
-
TSB #TJ33285-3-0-2018
This is a Technical Journal: DTC IHU-B156C8F sets incorrectly. For the cars in the header this DTC can be ignored as it doesn't affect any of the functions in the car. Read More »
-
TSB #PB39-026
Please return stock of 31659854 charger to your servicing distribution center. Read More »
-
TSB #SPJ33152
This is a Service Product Journal: Read More »
-
TSB #ST-211-2017-10-0
VOLVO CARS SERVICE AND PARTS BUSINESS Special Tools Bulletin TITLE : Newsletter 64 : Mandatory Tools NO : DATE : CAR MARKET : United States and 211 YEAR MONTH DAY Page 1 of 13 Canada 2015 05 04 All tools have been classified as required , ... Read More »
-
TSB #TJ32033.2.0
This is a Technical Journal: Audio switches on right side of steering wheel, intermittent no function. Read More »
-
TSB #TJ30646.4.0-2016
This is a Technical Journal: Title Graphic HUD may loose height adjustment Head Up Display HUD/Does not work Under some conditions, the height adjustment for the Head Up Display (HUD) returns to its default (full "up") setting at a ... Read More »
-
TSB #TJ32185.1.1-2016
This is a Technical Journal: As of 11/28/2016 a voice recognition speech database file will no longer be included with the latest map upgrade for SPA vehicles (SPJ 29181) and must be downloaded separately from the maps. Read More »
-
TSB #TJ20803.12.0-201
This is a Technical Journal: In case of complaint of Noise, some "tools" have been created to help you to do a better and more precise fault tracing Read More »
-
TSB #SMB36-001
THIS IS A SERVICE MANAGER BULLETIN: DUE TO LONG SOFTWARE DOWNLOAD TIMES AND ADDITIONAL WORK CONNECTED TO THIS, THE FOLLOWING VST TIMES WILL BE TEMPORARILY INCREASED FOR SPA PLATFORM VEHICLES ONLY. Read More »
-
TSB #TJ31535
If you need to perform a tuner replacement on any vehicle that is factory equipped with SiriusXM satellite radio, please follow the step by step instructions. Read More »
-
TSB #SPJ31593
There has been an increasing amount of reports where users state that its not possible to perform a vehicle readout when pressing ?Connect? There will be an error message asking the user if they wants to retry after an error message ... Read More »
-
TSB #TJ35344.1.1-2019
This is a Technical Journal: Removal of "SiriusXM Subscription has Expired" Message Read More »
-
TSB #TJ34021
SiriusXM Radio inop or No Sound on SAT Source Read More »
-
TSB #TJ3321120
This is a Technical Journal: The voice control system on the above referenced models is continuously being improved. Read More »
-
TSB #TJ32921
This is a Technical Journal: Infotainment system switches to FM radio source at random Read More »
-
TSB #TJ31360.1.1
This TJ is only valid for SPA cars equipped with a CD player (also referred to as ODP or Optical Disc Player). Read More »
-
TSB #TJ31535
If you need to perform a tuner replacement on any vehicle that is factory equipped with SiriusXM satellite radio, please follow the step by step instructions. Read More »
-
TSB #TJ35058.1.3-2019
This is a Technical Journal: Sensus/Sensus Connect Navigation Base Map Versions Read More »
-
TSB #TJ35037.1.2-2020
This is a Technical Journal: Infotainment System Reboots Repeatedly after Software Download Read More »
-
TSB #TJ31602
Infotainment System Reboots while driving (blank screen) Read More »
-
TSB #ST-228
This is a Special Tool Bulletin: Kits 33300313 and 33300315 Read More »
-
TSB #TJ33239.1.0-2017
This is a Technical Journal: Brake vibrations due to lockable wheel screws Read More »
-
TSB #TJ32958 1 1-2017
This is a Technical Journal: A whining or rattling sound may appear when revving up the engine. ( see attached sample files ). Read More »
-
TSB #STB216
News Letter 70 Read More »
-
TSB #STB215
News Letter 69 Read More »
-
TSB #36678.1.0
This is a Technical Journal. Recovering control modules stuck in a??not respondinga?? after failed SW download. Connect VIDA to read-out the car. Follow steps outlined in this TJ. Read More »
-
TSB #P10186
Extended Warranty P10186 Read More »
-
TSB #P10207
Extended Warranty P10207 Read More »
-
TSB #21P10186
Extended Warranty P10186: VEP4 Oil Consumption Replace Read More »
-
TSB #P10186
Extended Warranty P10186: VEP4 Oil Consumption Replace; Read More »
-
TSB #P10207
Extended Warranty P10207 Read More »
-
TSB #P10186A
Extended Warranty P10186: VEP4 Oil Consumption Replace Read More »
-
TSB #P10186
Extended Warranty P10186: VEP4 Oil Consumption Replace Read More »
-
TSB #SMB00-108C
Expendable Items Parts List. Read More »
-
TSB #SMB00-015-2020-1
This is a Service Manager Bulletin : Volvo Electric Vehicle Technical De-Energization Permit to Work Form Read More »
-
TSB #TJ35514.1.0-2020
This is a Technical Journal: Prior Approval for VCM Replacement Read More »
-
TSB #SMB39-015-2020-0
This is a Service Manager Bulletin: Prior Approval for VCM Replacement Read More »
-
TSB #SMB00 438 2019-0
This is a Service Manager Bulletin: Technician Skillset Requirments Read More »
-
TSB #SMB00 340 2019-0
CUSTOMER OFFER To further enhance the Volvo?s ownership experience , Volvo Cars of Canada Corp . is offering the Volvo Prepaid Maintenance ( VPM ) program . Read More »
-
TSB #ST-231-2019-02-1
This is a Special Tool Bulletin: Newsletter 81 Mandatory Tools Read More »
-
TSB #TJ28941-4-0-2019
This is a Technical Journal: When sensitive information, like vehicle speed, brake usage, etc. (customer behavoiur information) of a car is required from Volvo Car Corporation from external sources, either of these two documents should be ... Read More »
-
TSB #PB00-013-2019-02
This is a Parts Bulletin: Hazmat Return Transportation Documentation and requirements Read More »
-
TSB #PB77-006-2019-02
Winter Wheel Applications including rim sizes, steel wheel parts numbers and wheel cover part numbers Read More »
-
TSB #TJ28941-4-0-2019
This is a Technical Journal: When sensitive information, like vehicle speed, brake usage, etc. (customer behavoiur information) of a car is required from Volvo Car Corporation from external sources, either of these two documents should be ... Read More »
-
TSB #PB00-013-2019-02
This is a Parts Bulletin: Hazmat Return Transportation Documentation and requirements Read More »
-
TSB #SMB00-437-2019-0
This is a Service Manager Bulletin: Volvo Special Tool Warranty Coverage and Claims Process Read More »
-
TSB #TJ21965-5-0-2019
This is a Technical Journal: Oil in cooling system. New cleaning method developed. Read More »
-
TSB #TJ31423-11-0-201
This is a Technical Journal: Blown fuse, compressor - air suspension. Perform Total Upgrade, replace fuse and compressor according to VIDA. Read More »
-
TSB #TJ34246-1-0-2018
This is a Technical Journal: SPA Brake noise Read More »
-
TSB #TJ34246-1-0-2018
This is a Technical Journal: SPA Brake noise Read More »
-
TSB #TJ31423-11-0-201
This is a Technical Journal: Blown fuse, compressor - air suspension. Perform Total Upgrade, replace fuse and compressor according to VIDA. Read More »
-
TSB #SMB88-001A-2018-
This bulletin is a service manager bulletin. Seat Belt Extender. Read More »
-
TSB #TJ34165-1-0-2018
This is a Technical Journal: No VIDA communication with vehicle Read More »
-
TSB #TJ34165-1-0-2018
This is a Technical Journal: No VIDA communication with vehicle Read More »
-
TSB #PB85-056-2018-08
Please return stock of Heaters 32206448, 32206450 to your servicing distribution center. Read More »
-
TSB #PB85-056-2018-08
Please return stock of Heaters 32206448, 32206450 to your servicing distribution center. Read More »
-
TSB #TJ33616-1-1-2018
This is a Technical Journal: If the front seat belt catch makes noise when moving against the seat upholstery, follow instruction under Service. Add adhesive tape. Read More »
-
TSB #TJ31543 4 6-2018
This is a Technical Journal: This Journal is a guide for performing Software Downloads. Service: *See guide updated Oct. 12, 2016 for relevant P5/SPA Software Download information: P5_SPA_SW_Guide. Read More »
-
TSB #PB82-005-2018-03
Please return stock of part numbers 39849933, 39849999 fender flare to your servicing distribution center. Read More »
-
TSB #PB85-055-2018-03
Please return stock of part number 39825191 side panel to your servicing distribution center. Read More »
-
TSB #PB77-017-2018-03
This is a Parts Bulletin: Wheel Cross Reference, used to assist in identifying the correct spare replacement wheel, by stamping, name and size. Read More »
-
TSB #SMB00-006-2018-0
Software Installation Policy changes. Read More »
-
TSB #SMB00-006C-2018-
Software Installation Policy changes - Canada Read More »
-
TSB #PB85-055-2018-03
Please return stock of part number 39825191 side panel to your servicing distribution center. Read More »
-
TSB #PB77-017-2018-03
This is a Parts Bulletin: Wheel Cross Reference, used to assist in identifying the correct spare replacement wheel, by stamping, name and size. Read More »
-
TSB #SMB00-006-2018-0
Software Installation Policy changes. Read More »
-
TSB #SMB00-006C-2018-
Software Installation Policy changes - Canada Read More »
-
TSB #TJ20803-17-0-201
This is a Technical Journal: In case of complaint of Noise, some "tools" have been created to help you to do a better and more precise fault tracing Read More »
-
TSB #SMB00-006C-2018-
Software Installation Policy changes - Canada Read More »
-
TSB #SMB00-006C-2018-
Software Installation Policy changes - Canada Read More »
-
TSB #SMB00-006-2018-0
Software Installation Policy changes. Read More »
-
TSB #SMB00-006-2018-0
Software Installation Policy changes. Read More »
-
TSB #SMB00-006C-2018-
Software Installation Policy changes - Canada Read More »
-
TSB #PB26-036-2018-03
Please return stock of part number 31686821 bleeder hose to your servicing distribution center. Read More »
-
TSB #PB26-036-2018-03
Please return stock of part number 31686821 bleeder hose to your servicing distribution center. Read More »
-
TSB #TJ33285-3-0-2018
This is a Technical Journal: DTC IHU-B156C8F sets incorrectly. For the cars in the header this DTC can be ignored as it doesn't affect any of the functions in the car. Read More »
-
TSB #TJ31543-4-5-2018
This is a Technical Journal: This Journal is a guide for performing Software Downloads. Service: *See guide updated Oct. 12, 2016 for relevant P5/SPA Software Download information: P5_SPA_SW_Guide. Read More »
-
TSB #TJ31423-4-0-2018
This is a Technical Journal: Blown fuse, compressor - air suspension. Perform Total Upgrade, replace fuse and compressor according to VIDA. Read More »
-
TSB #TJ31543-4-5-2018
This is a Technical Journal: This Journal is a guide for performing Software Downloads. Service: *See guide updated Oct. 12, 2016 for relevant P5/SPA Software Download information: P5_SPA_SW_Guide. Read More »
-
TSB #SMB00-006-2018-0
Software Installation Policy changes. Read More »
-
TSB #SMB00-006C-2018-
Software Installation Policy changes - Canada Read More »
-
TSB #SMB00-006-2018-0
Software Installation Policy changes. Read More »
-
TSB #SMB00-006C-2018-
Software Installation Policy changes - Canada Read More »
-
TSB #SPJ33554-1-0-201
This is a Service Product Journal: Software Purchase Failed - General error occured - VDS / SPA / CMA cars. Download software fix Read More »
-
TSB #TJ20803.15.0-201
This is a Technical Journal: In case of complaint of Noise, some "tools" have been created to help you to do a better and more precise fault tracing Read More »
-
TSB #TJ20803 14 0-201
This is a Technical Journal: In case of complaint of Noise, some "tools" have been created to help you to do a better and more precise fault tracing Read More »
-
TSB #PB28-001-2017-10
Please return stock of part number 31380014 spark plug kit to your servicing distribution center. Read More »
-
TSB #TJ32958 1 1-2017
This is a Technical Journal: A whining or rattling sound may appear when revving up the engine. ( see attached sample files ). Read More »
-
TSB #SMB00-427-2017-0
This is a Service Manager Bulletin: Claiming for Map Upgrades is not a matter for warranty. Claims submitted for map upgrades will be debited Read More »
-
TSB #TJ3134720-2017-0
This is a Technical Journal: Message in DIM "Windscreen Sensor Blocked" ASDM= Active Safety Domain Master *If the customer experiences the warning message "Windscreen sensor blocked. See manual. Read More »
-
TSB #PB51-001-2017-06
Please return stock of part number 31400779 Brake Disc Kit to your servicing distribution center. Read More »
-
TSB #SMB00-288-2017-0
The Warranty Retailer Counseling Process (WRCP) is used to gauge individual retailer performance on objective measures over time. Read More »
-
TSB #SMB00-354-2017-0
Warranty, customer pay and/or internal repairs performed must be verified by a punched time flag on the back of the Repair Order hard copy. Read More »
-
TSB #SMB00-325-2017-0
Service Manager Bulletin TITLE : Service Action Notification Re - Mails GROUP : NO : ISSUING DEPARTMENT : CAR MARKET : Product Safety & Compliance United States and Canada 00 325 REFERENCE BULLETINS : DATE : SMB00 - 323 and SMB00 - 323A ... Read More »
-
TSB #SMB00-287-2016-1
Please use attached file to create new version of bulletin. Please remove original bulletin by same number dated 2/18/2010. Read More »
-
TSB #PB77-017-2016-12
This is a Parts Bulletin: Wheel Cross Reference, used to assist in identifying the correct spare replacement wheel, by stamping, name and size. Read More »
-
TSB #PB77-017-2016-12
This is a Parts Bulletin: Wheel Cross Reference, used to assist in identifying the correct spare replacement wheel, by stamping, name and size. Read More »
-
TSB #TJ31938.2.0-2016
This is a Technical Journal: If the vehicle is turned off and restarted again within 1-10 minutes, the P-SIM may not be working. ?No connection to service? will then be shown in the Download Center. Read More »
-
TSB #SMB00-424-2016-1
While performing repairs, on vehicles covered by Volvo's New Vehicle Warranty, the Technical Help Desk may support the dealer by providing a specific diagnostic labor operation. Read More »
-
TSB #SMB17-2017A
VOLVO CARS SERVICE AND PARTS BUSINESS SERVICE MANAGER BULLETIN TITLE : RETAIL CAR DELIVERY PROCESS ALL MY 2016 S60 , V60 , XC60 , XC70 AND S80 GROUP : NO:ISSUING DEPARTMENT : CAR MARKET : UNITED STATES AND CANADA 17 2016A SERVICE ... Read More »
-
TSB #SMB00-354
WARRANTY, CUSTOMER PAY AND/OR INTERNAL REPAIRS PERFORMED MUST BE VERIFIED BY A PUNCHED TIME FLAG ON THE BACK OF THE REPAIR ORDER HARD COPY. Read More »
-
TSB #SMB17-2016
THIS IS A SERVICE MANAGER BULLETIN: THIS BULLETIN CONTAINS INFORMATION ON THE FOLLOWING STEPS WHICH MAKE UP THE RETAIL CAR DELIVERY PROCESS. Read More »
-
TSB #TJ20278612201609
THIS IS A TECHNICAL JOURNAL: IT IS PROVIDED AS A GUIDE FOR PERFORMING SOFTWARE DOWNLOADS. FOLLOW INSTRUCTIONS PROVIDED FOR PROPER SOFTWARE DOWNLOADS BY YEAR AND MODEL. Read More »
-
TSB #TJ31491.1.0
This document is a Technical Journal: If the air outlet on rear center console comes loose (see picture "TJ 31491.pdf") follow the instructions under "Service". Read More »
-
TSB #C10006
This document is a Quality Bulletin: Volvo Cars of North America, LLC. (Volvo) on behalf of Volvo Car Corporation, has decided to launch a Courtesy Upgrade on certain model year 2016 XC90 vehicles. Read More »
-
TSB #PB260-034
This document is a Parts Bulletin: Please return stock of part number 31439968 Thermostat to your servicing Distribution Center. Read More »
-
TSB #TJ3151410
This document is a Technical Journal: ASDM = Active Safety Domain Master To prevent unnecessary replacements of ASDM and as a troubleshooting aid for the Intellisafe system, please follow the advice in Technical ... Read More »
-
TSB #TJ31236.8.0
If the vehicle is equipped with air suspension and if customer is complaining over a knock/rattle/clatter noise from the front suspension when driving on rough roads or over a road hump, then follow the advice under Service. Read More »
-
TSB #SMB-00-353
The Volvo Technical Helpdesk (THD) is a central contact point available to authorized Volvo dealer technicians to assist with difficult to repair situations. Read More »
-
TSB #TJ31236
If the vehicle is equipped with air suspension and if customer is complaining over a knock/rattle/clatter noise from the front suspension when driving on rough roads or over a road hump, then follow the advice under Service. Read More »
-
TSB #Service Manager
3G Network Sunset Read More »
-
TSB #TJ Instruction V
Steering column cover, squeaking noise Read More »
-
TSB #TJ29012.6.0-2020
VOLVO CARS SERVICE AND PARTS BUSINESS Technical Journal TITLE : Leather dashboard , leather comes loose REF NO : ISSUING DEPARTMENT : CAR MARKET : United States and Canada TJ 29012 Technical Service PARTNER : ISSUE DATE : 3 US 7510 Volvo ... Read More »
-
TSB #TJ33442.10.0-202
This is a technical Journal:If the vehicle has a click sound from the left engine pad, follow the advice under "Service". Make sure that the sound is coming from the engine pad, NOT from the drive shaft. Read More »
-
TSB #ST-001-2020-09-1
Mandatory Tool List bulletin: Volvo mandatory Special Tools are necessary for technicians to properly diagnose and repair Volvo cars. Read More »
-
TSB #ST-231-2019-02-1
This is a Special Tool Bulletin: Newsletter 81 Mandatory Tools Read More »
-
TSB #ST-231-2019-02-1
This is a Special Tool Bulletin: Newsletter 81 Mandatory Tools Read More »
-
TSB #TJ28941-4-0-2019
This is a Technical Journal: When sensitive information, like vehicle speed, brake usage, etc. (customer behavoiur information) of a car is required from Volvo Car Corporation from external sources, either of these two documents should be ... Read More »
-
TSB #PB77-006-2019-02
Winter Wheel Applications including rim sizes, steel wheel parts numbers and wheel cover part numbers Read More »
-
TSB #SMB00-437-2019-0
This is a Service Manager Bulletin: Volvo Special Tool Warranty Coverage and Claims Process Read More »
-
TSB #TJ34262-1-0-2018
This is a Technical Journal: Wind noise, front and/or rear door area Read More »
-
TSB #SMB88-001A-2018-
This bulletin is a service manager bulletin. Seat Belt Extender. Read More »
-
TSB #SMB88-001A-2018-
This bulletin is a service manager bulletin. Seat Belt Extender. Read More »
-
TSB #SMB88-001A-2018-
This bulletin is a service manager bulletin. Seat Belt Extender. Read More »
-
TSB #PB85-056-2018-08
Please return stock of Heaters 32206448, 32206450 to your servicing distribution center. Read More »
-
TSB #PB85-056-2018-08
Please return stock of Heaters 32206448, 32206450 to your servicing distribution center. Read More »
-
TSB #ST-002-2018-08-1
This is a Service Manager Bulletin. This bulletin is a list of equipment recommended by Volvo to it's dealer or any shop maintaining or repairing Volvo's. Read More »
-
TSB #ST-227-2018-08-1
Road Force wheel balancing is the proper tool for diagnosing and repairing such issues and all of our retailers need to be prepared for these issues. Read More »
-
TSB #PB31-004-2018-08
This is a Parts Bulletin: 12 Volt support batteries, part number 30659531 must be maintained 9 months from the month of manufacture and every 9 months thereafter. Read More »
-
TSB #TJ33867-1-1-2018
This is a Technical Journal: we find with automobiles. Radial force variation ( RFV ) is a condition where excessive run out will create the same symptom as an unbalanced tire. Read More »
-
TSB #TJ31423 6 0-2018
This is a Technical Journal: Blown fuse, compressor - air suspension. Perform Total Upgrade, replace fuse and compressor according to VIDA. Read More »
-
TSB #TJ20803-17-0-201
This is a Technical Journal: In case of complaint of Noise, some "tools" have been created to help you to do a better and more precise fault tracing Read More »
-
TSB #TJ31423-5-0-2018
This is a Technical Journal: Blown fuse, compressor - air suspension. Perform Total Upgrade, replace fuse and compressor according to VIDA. Read More »
-
TSB #TJ33633-1-2-2018
This is a Technical Journal: No Internet Connection With Car Modem/"SIM Card Not Inserted" message. In order to restore the connectivity functions, the "Roaming" function must be activated in the vehicle menus. Read More »
-
TSB #TJ20803-17-0-201
This is a Technical Journal: In case of complaint of Noise, some "tools" have been created to help you to do a better and more precise fault tracing Read More »
-
TSB #PB26-036-2018-03
Please return stock of part number 31686821 bleeder hose to your servicing distribution center. Read More »
-
TSB #TJ32469-3-0-2018
This is a Technical Journal: Gear shift lever inoperable Read More »
-
TSB #TJ32469-3-0-2018
This is a Technical Journal: Gear shift lever inoperable Read More »
-
TSB #TJ30934
This is a Technical Journal: * If squealing noise occurs from front brakes on cars built before chassis number 040328, then Replace front discs according to VIDA, the new brake discs have changed metal composition in order to reduce ... Read More »
-
TSB #ST-211-2017-10-0
VOLVO CARS SERVICE AND PARTS BUSINESS Special Tools Bulletin TITLE : Newsletter 64 : Mandatory Tools NO : DATE : CAR MARKET : United States and 211 YEAR MONTH DAY Page 1 of 13 Canada 2015 05 04 All tools have been classified as required , ... Read More »
-
TSB #TJ29012.5.0-2017
VOLVO CARS SERVICE AND PARTS BUSINESS Technical Journal TITLE : Leather dashboard , leather comes loose REF NO : ISSUING DEPARTMENT : CAR MARKET : United States and Canada TJ 29012 Technical Service PARTNER : ISSUE DATE : 3 US 7510 Volvo ... Read More »
-
TSB #TJ31218.1.2-2017
This is a Technical Journal: A new front license plate frame was introduced on MY16 XC90 2015w45. The H frame P/N (part number) 31391625 is no longer needed.Install front license plate using four (4) Wurth screws P/N 02151012. Read More »
-
TSB #TJ29131.6.0-2017
This is a Technical Journal: Customer may experience a low oil level warning in DIM and /or oil leakage from the engine. Read More »
-
TSB #TJ31292.1.1-2017
This is a Technical Journal: 1.Remove oil pump from AOC (Active On demand Coupling)and inspect the strainer. (See att.) 2.Clean strainer with lint-free cloth, do not use any cleaning liquids (this can contaminate the oil) 3. Read More »
-
TSB #PB77-006-2017-01
Winter Wheel Applications including rim sizes, steel wheel parts numbers and wheel cover part numbers Read More »
-
TSB #ST-211-2017-01-2
VOLVO CARS SERVICE AND PARTS BUSINESS Special Tools Bulletin TITLE : Newsletter 64 : Mandatory Tools NO : DATE : CAR MARKET : United States and 211 YEAR MONTH DAY Page 1 of 13 Canada 2015 05 04 All tools have been classified as required , ... Read More »
-
TSB #PB87-R89707-2016
This is a Parts Bulletin: Condensation water, transferred through the air conditioning drain hose, may leak into the passenger compartment due to incorrect installation during vehicle assembly. Read More »
-
TSB #TJ30646.4.0-2016
This is a Technical Journal: Title Graphic HUD may loose height adjustment Head Up Display HUD/Does not work Under some conditions, the height adjustment for the Head Up Display (HUD) returns to its default (full "up") setting at a ... Read More »
-
TSB #TJ25153.7.1-2016
This is a Technical Journal: Washer system layout for identifying leakage points REF NO : ISSUING DEPARTMENT : CAR MARKET : United States and Canada TJ 25153 Technical Service PARTNER : ISSUE DATE : STATUS DATE : 3 US 7510 Volvo Car USA ... Read More »
-
TSB #TJ31826.5.0-2016
This is a Technical Journal: If a customer experience an incorrect ambient temperature reading in DIM or reduced A/C performance due to a defective ambient temp sensor, and the symptom is confirmed, replace the ambient temperature sensor ... Read More »
-
TSB #TJ32204.1.1-2016
This is a Technical Journal: P-SIM = Personal Subscriber Identity Module When using the in-car modem and P-SIM connection, the following symptoms may appear: 1 - In car apps such as TuneIn and Pandora connect to the service but say ... Read More »
-
TSB #TJ31955.1.8-2016
Technical Journal TITLE: Recall R89707: Air conditioner drain hose Read More »
-
TSB #TJ32005.1.1-2016
This is a Technical Journal: Leather seats, improvements on wrinkles and wear. Always replace both together, seat cushion upholstery and seat cushion foam . Read More »
-
TSB #SMB00-424-2016-1
While performing repairs, on vehicles covered by Volvo's New Vehicle Warranty, the Technical Help Desk may support the dealer by providing a specific diagnostic labor operation. Read More »
-
TSB #TJ32004.1.0-2016
This is a Technical Journal: The Remote Control slider button is now available as a spare part. If the slider button is missing or damaged, there is no need to replace the entire remote control. Read More »
-
TSB #TJ29122.3.0-2016
This is a Technical Journal: The front park assist sensor bracket may come loose from the lower grill. The clamping force on the bracket in the lower grill may be too low. Read More »
-
TSB #TJ31826.3.0-2016
This is a Technical Journal: If a customer experience an incorrect ambient temperature reading in DIM or reduced A/C performance due to a defective ambient temp sensor, and the symptom is confirmed, replace the ambient temperature sensor ... Read More »
-
TSB #TJ31798.2.0-2016
Inverter Generator Module "DTC IGM- P0DFC00, Generator Position Sensor Not learned" may be noticed at a VIDA readout. No reported customer symptoms. Ignore the DTC, work is ongoing to find the root cause. Read More »
-
TSB #PB77-017-2016-12
This is a Parts Bulletin: Wheel Cross Reference, used to assist in identifying the correct spare replacement wheel, by stamping, name and size. Read More »
-
TSB #TJ30599.3.1-2016
When driving on rough roads, a creaking/squeaking noise can be heard from the second row seats. Add felt tape on the top half of the striker pins, according to attached files. * Use new tape, (Service kit) p/n 31447976. Read More »
-
TSB #PB88-R89708-2016
Volvo Car USA LLC and Volvo Car Canada LTD (Volvo) on behalf of Volvo Car Group has decided to launch Recall R89708 on certain model year 2016 - 2017 XC90, S90, XC60, V60CC, V60, S60, S60CC, S60 Inscription vehicles. Read More »
-
TSB #TJ32033.1.0-2016
After using a voice command to adjust the climate, the buttons for ?Forward?, ?Back? and ?Confirm? on the audio switches on the right side of the steering wheel may not function (marked as ?1?, ?2?and ?3? in attachment). Read More »
-
TSB #R89707-2016-11-1
Volvo Car USA LLC and Volvo Car Canada LTD (Volvo) on behalf of Volvo Car Group has decided to launch Recall R89707 on model year 2016 & 2017 XC90 & S90 vehicles. Read More »
-
TSB #PB84-P89405
This is a Parts Bulletin:VOLVO EMBLEM EXTENDED. Volvo has determined that there is the potential for the VOLVO Iron Mark logo emblem on the radiator grille to peel off. Read More »
-
TSB #TJ31491.1.0
This document is a Technical Journal: If the air outlet on rear center console comes loose (see picture "TJ 31491.pdf") follow the instructions under "Service". Read More »
-
TSB #TJ19967
Blisters/bubbles may appear on the air vent surfaces. The blistering of the material is often caused by an air freshener applied directly to the air vents. Do not attach any sort of air freshener directly on air vents. Read More »
-
TSB #SPJ31593
There has been an increasing amount of reports where users state that its not possible to perform a vehicle readout when pressing ?Connect? There will be an error message asking the user if they wants to retry after an error message ... Read More »
-
TSB #TJ34648.1.3-2019
This is a Technical Journal: Prior Approval - Lack of airflow causing poor cabin cooling Read More »
-
TSB #TJ34648 1 2 2019
This is a Technical Journal: Prior Approval - Lack of airflow causing poor cabin cooling Read More »
-
TSB #TJ32040212019-05
This is a Technical Journal: Title Dash absorber insulation, Damp or bad smell Water seepage from sealing to Climate unit in plenum area. Read More »
-
TSB #TJ32267 2 0-2017
This is a Technical Journal: Climate system, unusual noise from dashboard area. replace the heater core according to the attached instruction. Read More »
-
TSB #TJ32139.1.0-2017
This is a Technical Journal: Climate system, high fan speed noise. Customer may experience a high fan speed noise regardless of the fan speed selection. This may be due to accidentally touching the 2nd row display. Read More »
-
TSB #PB87-R89707-2016
Parts Bulletin TITLE: Recall R89707: Air Conditioning Drain Hose Model Year 2016 XC90 & S90 Read More »
-
TSB #PB87-R89707-2016
Parts Bulletin TITLE: Recall R89707: Air Conditioning Drain Hose Model Year 2016 XC90 & S90 Read More »
-
TSB #TJ30925.7.0-2016
Technical Journal TITLE: SPA Climate system, unexpected behavior Read More »
-
TSB #PB87-R89707-2016
This is a Parts Bulletin: Condensation water, transferred through the air conditioning drain hose, may leak into the passenger compartment due to incorrect installation during vehicle assembly. Read More »
-
TSB #TJ31826.5.0-2016
This is a Technical Journal: If a customer experience an incorrect ambient temperature reading in DIM or reduced A/C performance due to a defective ambient temp sensor, and the symptom is confirmed, replace the ambient temperature sensor ... Read More »
-
TSB #TJ31826.3.0-2016
This is a Technical Journal: If a customer experience an incorrect ambient temperature reading in DIM or reduced A/C performance due to a defective ambient temp sensor, and the symptom is confirmed, replace the ambient temperature sensor ... Read More »
-
TSB #R89707-2016-12-2
Quality Bulletin TITLE: Recall R89707: Air Conditioning Drain Hose Model Year 2016 - 2017 XC90, 2017 S90 Read More »
-
TSB #PB87-R89707-2016
Update: NEW GROMMET AND PLUG PART NUMBERS REPLACE EXISTING DRAIN HOSES Volvo Car USA LLC and Volvo Car Canada LTD (Volvo) on behalf of Volvo Car Group has decided to launch Recall R89707 on model year 2016 & 2017 XC90 & S90 vehicles. Read More »
-
TSB #TJ30925
THIS IS A TECHNICAL JOURNAL: CUSTOMER MAY EXPERIENCE UNEXPECTED CLIMATE REGULATION DURING DRIVING, CLIMATE SYSTEM MIGHT SUDDENLY STARTS TO BLOW HOT/COLD AIR. CCM SW NOW IMPLEMENTED 2016W38 IN PRODUCTION AND FOR SERVICE. Read More »
-
TSB #R89707-2016-11-1
Volvo Car USA LLC and Volvo Car Canada LTD (Volvo) on behalf of Volvo Car Group has decided to launch Recall R89707 on model year 2016 & 2017 XC90 & S90 vehicles. Read More »
-
TSB #TJ31955102016092
THIS IS A TECHNICAL JOURNAL: CONDENSATION WATER, TRANSFERRED THROUGH THE AIR CONDITIONING DRAIN HOSE, MAY LEAK INTO THE PASSENGER COMPARTMENT DUE TO INCORRECT INSTALLATION DURING VEHICLE ASSEMBLY. Read More »
-
TSB #TJ30925502016092
THIS IS A TECHNICAL JOURNAL: CUSTOMER MAY EXPERIENCE UNEXPECTED CLIMATE REGULATION DURING DRIVING, CLIMATE SYSTEM MIGHT SUDDENLY STARTS TO BLOW HOT/COLD AIR. CCM SW NOW IMPLEMENTED 2016W38 IN PRODUCTION AND FOR SERVICE. Read More »
-
TSB #TJ31826.1.0
This is a Technical Journal: If a customer experience an incorrect ambient temperature reading in DIM or reduced A/C performance due to a defective ambient temp sensor, and the symptom is confirmed, replace the ambient temperature sensor ... Read More »
-
TSB #TJ31286.1.0
This is a Technical Journal: If a customer experience an incorrect ambient temperature reading in DIM or reduced A/C performance due to a defective ambient temp sensor, and the symptom is confirmed, replace the ambient temperature sensor ... Read More »
-
TSB #TJ19967
Blisters/bubbles may appear on the air vent surfaces. The blistering of the material is often caused by an air freshener applied directly to the air vents. Do not attach any sort of air freshener directly on air vents. Read More »
-
TSB #TJ35912.4.0
Updated Chassis Range. Read More »
-
TSB #C00009
COMPLIMENTARY UPGRADE C00009 DESCRIPTION. Read More »
-
TSB #TJ3656330
Rubber cushion Read More »
-
TSB #TJ34295
PHEV High Voltage Battery Repairs Read More »
-
TSB #Special Tools Bu
The Deutronic DBL-1200 is an advanced battery maintainer/charger with the flexibility to be updated as products and repair methods evolve. Read More »
-
TSB #Service Manager
ICUP/Google Built-In Diagnostic Operations Read More »
-
TSB #Service Manager
Battery Charger/maintainer requirement Read More »
-
TSB #TJ3321120
This is a Technical Journal: The voice control system on the above referenced models is continuously being improved. Read More »
-
TSB #TJ26745.7.2
This document is a Technical Journal: Effective immediately, all 12V batteries may be tested using the hand held battery tester 9513030 (BT3300). The VIDA test is still available but no longer required. Read More »